2001 VOLKSWAGEN JETTA Fuel System Diesel Problems

8 NHTSA complaints on file

Check any vehicle history by VIN - Free vehicle history report

Fuel System Diesel Issues in the 2001 VOLKSWAGEN JETTA

8 fuel system diesel complaints have been filed with NHTSA for the 2001 VOLKSWAGEN JETTA. Of these, 0 involved a crash, 0 involved a fire, and 0 resulted in injury.

Complaints

Crashes

Fires

Injuries

Deaths

All Fuel System Diesel Complaints

#10096377 | October 25, 2004

I OWN A 2001 VW JETTA TDI (DIESEL). I TOOK MY CAR TO THE WEST BROAD VOLKSWAGEN, RICHMOND, VA ON 10/22/04, CONCERNING THE FACT THAT MY CAR WOULD NOT START AND THAT IT FELT LIKE THE CAR WAS NOT RECEIVING ANY FUEL. ADDITIONALLY, THE CAR IS STEADILY LOOSING ITS ABILITY TO ACCELERATE INTO TRAFFIC. NOT ONLY WAS I CHARGED $69.95 FOR A DIAGNOSTIC, BUT I WAS THEN TOLD THE INTAKE WAS FULL OF CARBON AND THAT IT WOULD COST $978.00 TO FIX THE PROBLEM! ADDITIONALLY, THE CAR DIED DURING THE SUMMER MONTHS AS I WAS TRYING TO GET ON TO THE HIGHWAY. AS THE STEERING WHEEL BECAME STIFF, I VEERED OFF OF THE ROAD TO KEEP FROM BEING KILLED! WHEN I TRIED TO RESTART THE CAR, IT FELT LIKE THE CAR WASN'T GETTING FUEL. I WAS TOWED TO THE NEAREST DEALERSHIP, BROWNS VOLKSWAGEN, MIDLOTHIAN VA. THEY KEPT MY CAR FOR...

#10058202 | February 15, 2004

PURCHASED A 2001 JETTA TDI IN SEPT OF 2003 WITH 52000 KM'S. AT 64,000 KM CHECK ENGINE LIGHT WENT ON. CAR WAS DUE FOR 64,000 KM SERVICE ANYWAY. GLOW PLUG BUS BAR NEED REPLACEMENT. NOT ENOUGH, OR NO CURRENT GETTING TO GLOW PLUGS TO WARM THEM FOR THE CAR TO START. THREE WEEKS AFTER 64,000KM SERVICE, PULLED OUT OF DRIVEWAY, CHECK ENGINE LIGHT GOES ON, CHECK OIL LIGHT FLASHES, BELL GOES OFF, GLOW PLUG LIGHT FLASHES, VEHICLE FEELS SLUGGISH WITH NO POWER. MASS AIR FLOW SENSOR NEEDED REPLACEMENT (UNDER WARRENTY, $467). REPLACED NEEDLE SENSOR/INJECTOR ASSEMBLY, REPLACED FAULTY BREAK LIGHT SWITCH, TRACED AND REPAIRED WIRIING SENSOR. COST $671. IN THREE WEEKS SPENT $1250 ON SERVICE AND REPAIRS ON A THREE YEAR OLD CAR.*AK

#10056980 | February 11, 2004

DIESEL FUEL GELLING IN LOW TEMPS. VW ADMITS TO HAVING NO SOLUTION FOR THE PROBLEM. ONE OF THE MECHANICS DID ADMIT THAT THE FUEL LINE WAS TOO SMALL. WE HAVE BEEN TOWED IN TWICE LATE AT NIGHT IN DANGEROUS TEMPERATURES. FORTUNATELY MY WIFE HAD A CELL PHONE-8 YEAR OLD BOY ON BOARD ALSO. [email protected] HAD SAME PROBLEM.*AK

#10054655 | January 22, 2004

I TOOK MY CAR IN TO BE SERVICED FOR WHAT I THOUGHT WAS A TURBO PROBLEM, WHICH THE DEALER PROMISED TO COVER. IT TURNS OUT THAT MY INTAKE MANIFOLD AND EGR WERE SO CLOGGED WITH CARBON THAT MY TURBO FAILED. DEALER REFUSED TO COVER SINCE IT WAS NOT THE TURBO ITSELF.

#10054416 | January 18, 2004

CAR STARTS POORLY. UPON INVESTIGATION, FOUND THAT EGR VALVE AND INTAKE MANIFOLD ARE PACKED WITH BLACK, NASTY CARBON BUILD-UP. I REMOVED THE EGR VALVE AND SCRAPED OUT APPROXIMATELY ONE AND ONE-HALF CUPS OF THIS BLACK 'GUNK' FROM THE EGR VALVE AND THE INTAKE MANIFOLD. I CAN ONLY IMAGINE WHAT THE INTAKE PORTS LOOK LIKE IN THE CYLINDER HEAD. *CB

#10030934 | August 6, 2003

LOSS OF POWER IN JETTA WITH TDI ENGINE. I EXPERIENCED SERIOUS LOSS OF POWER IN MY 2001 VW JETTA TDI .. THE LOSS WAS VERY SUDDEN AND RESULTED MADE IT UNSAFE TO GET ON THE HIGHWAY. *AK I DID SOME RESEARCH AND FOUND NUMEROUS NEWS GROUP POSTINGS ABOUT FAILING MAF SENSORS ON BOTH THE GAS AND DIESIL ENGINES. I VERIFIED THIS BY DISCONNECTING THE MAF AND DRIVING THE CAR. THERE WAS AN IMMEDIATE INCREASE IN POWER. I THEN HAD THE DEALER CHECK IT OUT WHEN I HAD THE TIMING BELT REPLACED. AT FIRST THE TECH THOUGHT IT WAS BECAUSE THE INTAKE MANIFOLD WAS CLOGGING UP. HE CLEANED IT, BUT THE POWER LOSS WAS STILL PRESENT. HE THEN DETERMINED THE MAF IS THE PROBLEM. I PURCHASED A NEW MAF FOR $250 AND THAT RESOLVED THE PROBLEM. HOWEVER, THIS PART CAN COST UP TO $400 FROM THE DEALER. THE DEALER CLAIMS THE...

#10023892 | June 27, 2003

LAST WEEK ON 6-20-03 I PULLED OUT ONTO STATE ROAD 2 IN VALPARAISO AND MY 2001 VOLKSWAGEN JETTA TDI WOULD NOT ACCELERATE. I HAD MY 6-YEAR-OLD SON IN THE CAR AND HAD TO PULL OVER TO THE SHOULDER OF THE ROAD TO AVOID BEING HIT. THE CAR IS UNDRIVEABLE. A MECHANIC HAS DIAGNOSED THE PROBLEM AS A FAULTY TURBO DIESEL SYSTEM. THIS SYSTEM WAS INSTALLED NEW IN THE 2001 JETTA AND HAD PREVIOUSLY NEVER BEEN INSTALLED IN ANY OTHER VOLKSWAGEN. MY MECHANIC INDICATES THE NEW SYSTEM IS FAULTY AND AS A RESULT, FUEL IS NOT BURNED CLEANLY. THE ENTIRE ENGINE, INTAKE MANIFOLD, AND VALVES ARE CLOGGED WITH CARBON. I HAVE BEEN TOLD I NEED A NEW ENGINE. MY MECHANIC HAS DIAGNOSED THE SAME PROBLEM IN OTHER 2001 JETTAS AND STATES THAT THE PROBLEM SEEMS TO HIM TO BE UNIVERSAL IN THIS YEAR AND MODEL. THIS CAR IS ONLY TWO YEARS...

#10006488 | February 5, 2003

TWICE, VEHICLE HAS STALLED ALMOST CAUSING COLLISION. PH

Other 2001 VOLKSWAGEN JETTA Problem Areas

← Back to 2001 VOLKSWAGEN JETTA overview