1996 TOYOTA T100 Structurebody Problems

1996 TOYOTA T100 WITH APPROX 77000 MILES, RARELY DRIVEN, GARAGE KEPT AND WELL CARED FOR, CANNOT PASS SAFETY INSPECTION DUE TO UNUSUAL AMOUNT OF RUST ON FRAME, CONTROL ARMS, UNDERBODY COMPONENTS, REAR BUMPER. AM CONCERNED IF VEHICLE IS IN AN ACCIDENT, IT WILL DISINTEGRATE AND CAUSE BODILY INJURY OR DEATH TO DRIVER AND PASSENGER, OR IF STRUCTURE FAILS WHILE VEHICLE IS IN MOTION IT CAN CAUSE HARM TO OTHER DRIVERS/PASSENGERS. TOYOTA LEFT THIS MODEL OUT OF THE RECALL BUT THESE ARE THE EXACT SAME ISSUES REPORTED WITH TACOMA AND TUNDRA OF SAME MODEL YEAR RANGE. TRUCK WOULD RUN FOREVER IF NOT FOR EXCESSIVE RUST. YOU CAN DO BETTER TOYOTA, SO DO BETTER. *TR

I AM A OWNER OF A 1996 TOYOTA T100 WITH SERIOUS RUST ISSUES ON MY TRUCK. I HAVE BEEN LOOKING ONLINE AND FOUND THAT OTHER OWNERS HAVE THE SAME PROBLEMS. THERE WAS A RECALL ON OTHER TRUCK SUCH AS THE TACOMA. WHY HASN'T A RECALL BEEN ISSUED FOR THE T100.

THE TRUCKS UNDER CARRAIGE IS NOTHING BUT RUST SCARY RUSTY , ALSO THE BODY ESPECIALY FENDER WELLS RUST GROWING, REAR BUMBER RUSTED OFF THE TRUCK NEARLY COMPLETELY GONE. FRAME SO RUSTY GETTING SCARED TO TOW A TRAILER. GREAT RUNNING HAS BEEN A GOOD ONE. JUST DON'T UNDERSTAND THE BAD RUST PROBLEM, I KNOW THE THE SMALLER TOYOTA TRUCKS WERE RECALLED AND REPLACED OR BOUGHT OUT, WHOS TO SAY THE FRAMES ON THESE TOYOTA T100 WILL NOT BREAK ALSO CAUSING WRECK AND POSSIBLE INJURY.

I WAS RETURNING FROM A SHORT TRIP AND THE DRIVER'S SIDE CONTROL ARM BROKE WHILE TRAVELING DOWN THE ROAD AT APPROX. 35 MPH. THE FRAME, BODY AND STEERING COMPONENTS ARE ALL RIDDLED WITH RUST. I HAVE REPLACED NUMEROUS PARTS THAT HAD FAILED DUE TO RUST, INCLUDING A FUEL PUMP WHOSE DESIGN TRAPPED MOISTURE AND ROAD SALT ON TOP OF THE FUEL TANK UNTIL FUEL WAS LEAKING ON THE ROADWAY. THE REAR BUMPER RUSTED OFF. TOYOTA TRUCKS OF SIMILAR TYPE AND YEAR HAVE BEEN RECALLED BECAUSE OF SIMILAR PROBLEMS, BUT NOT THE 1996 T100. TOYOTA FORUMS ARE FILLED WITH THE SAME ISSUE WITH THIS VEHICLE. I HAVE OWNED THIS VEHICLE SINCE IT WAS BRAND NEW.TOYOTA WILL NOT BACK THIS PRODUCT. *TR

TL* THE CONTACT OWNS A 1996 TOYOTA T100. THE CONTACT STATED WHILE TRAVELING 15 MPH THE VEHICLE HIT A BUMP IN THE ROAD AND THEN A RUBBING AND CLICKING NOISE COULD BE HEARD COMING FROM THE DRIVER FRONT WHEEL WELL. THE VEHICLE THEN BECAME DIFFICULT TO STEER. THE CONTACT MERGED TO THE SIDE OF THE ROAD. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT PART OF THE FRAME WAS MISSING. THE VEHICLE WAS ABLE TO BE DRIVEN TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT TAKEN TO A MECHANIC. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 151,000. THE VIN WAS NOT AVAILABLE.

TL* THE CONTACT OWNS 1996 TOYOTA T100. THE CONTACT STATED THAT THE VEHICLE FRAME WAS SEVERELY CORRODED. AS A RESULT, HOLE DEVELOPED IN THE FUEL TANK CAUSING IT TO SEPARATE FROM THE VEHICLE. THE FUEL TANK WAS REPLACED; HOWEVER THE DEALER ADVISED THAT THE VEHICLE CANNOT BE REPAIRED. THE MANUFACTURE WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 131,288 AND THE CURRENT MILEAGE WAS 136,426.

TL* THE CONTACT OWNS A 1996 TOYOTA T100. THE CONTACT STATED THAT THERE WAS RUST ON THE FRAME OF THE VEHICLE THAT WAS CAUSING THE REAR BUMPER TO COLLAPSE. THE DEALER HAS NOT BEEN CONTACTED ABOUT THE RUST AND THE VEHICLE WAS NOT INSPECTED FOR THE FAILURE NOR REPAIRED. THE FAILURE AND THE CURRENT MILEAGES WERE UNKNOWN.

I HAD MY VEHICLE IN FOR AN EXHAUST RATTLE AS WELL AS AN OIL CHANGE TODAY TO MY LOCAL INDEPENDENT MECHANIC. THE MECHANIC, NOTING HOW ROTTED OUT THE FRAME WAS IN THE REAR AS WELL AS FRONT, RECOMMENDED THAT I NOT DRIVE THE VEHICLE ANY LONGER. THE SHOP DIDN'T DO ANY SERVICE WORK DUE TO THE CONDITION OF THE VEHICLE. KNOWING THAT TOYOTA DID A RECALL ON A SIMILAR TRUCK MODEL OF THE SAME VINTAGE, I TOOK THE TRUCK TO THE NEARBY TOYOTA DEALER WHERE I ASKED THEIR SERVICE DEPARTMENT TO DO AN ASSESSMENT OF THE VEHICLE. I THOUGHT TOYOTA COULD THEN BETTER UNDERSTAND WHAT IS HAPPENING WITH ONE OF THEIR PRODUCTS. THE SERVICE MANAGER WAS RATHER RUDE AND SAID THE WARRANTY ON THE TRUCK HAD EXPIRED AFTER THREE YEARS AND THAT IF I WANTED AN INSPECTION, I WOULD HAVE TO PAY FOR IT. I AM SHOCKED THAT WHAT I...

MY 1996 TOYOTA T100 FIRE WALL UNDER CLUTCH ASSEMBLY FAILED AND CRACKED FROM FATIGUE. DISTANCE OF CLUTCH TRAVEL WAS INADEQUATE TO DISENGAGE. REPLACED CLUTCH FOR NO REASON. *TR

TRANSMISSION WORE OUT AT 28000 MILES REPAIR TO FIREWALL WAS MADE AT 57000 MILES WHEN CLUTCH FAILED TO DISENGAGE BRACKET FOR PEDAL COMPLETELY FAILED AT 110000 SEAT BELT WAS REPLACED ONCE AND IT CONTINUES TO GET CAUGHT IN DOOR BECAUSE OF WEAK RETRACTOR

THERE IS A HOUSING CRACK ON VEHICLE. CONTACTED DEALER, AND DEALER IS NOT WILLING TO DO ANYTHING ABOUT IT.*AK