2024 TOYOTA RAV4 Wheels Problems

2024 Toyota RAV4 XLE AWD, VIN [XXX]. Steering defect appeared at approximately 12,000 miles (April 2025). Vehicle pulls significantly to the right, requiring constant steering correction. Driver must continuously hold left side of steering wheel to maintain straight path. If steering wheel released, vehicle immediately drifts right. Pull is constant and especially noticeable at highway speeds. THREE REPAIR ATTEMPTS FAILED: June 2025 (14,715 miles): Two wheel alignments performed same day - both failed to correct pull. November 2025 (16,091 miles): Replaced blown passenger rear shock absorber - pull persisted. December 2025 (16,819 miles): Performed 10+ wheel alignments. Toyota Corporate Technical Assistance filed case #53530239 and instructed ABS/SAS reset - failed. Technicians documented "rear suspension binding" but did not mechanically repair. SUSPECTED CAUSE: Strut mount bearing binding/failure or suspension binding. Dealership replaced shock but not strut mounts (industry best practice is replacing both together when shock fails at low mileage). Documented...

- Passenger side rear tire failed - Tire is at dealer and available for inspection - Extremely dangerous situation, tire failed on a section of interstate highway under construction. Only 2 lanes available and they were narrower than normal width. Part of the shoulder was converted to driving lane so almost no shoulder to pull off on. The incident happened on a Sunday afternoon and interstate was extremely busy with weekend traffic. My wife was extremely lucky not to be involved in a serious accident. - Tire has not been inspected by anyone other than the car dealer - If the tire pressure warning light came on it wasn't noticed. There were no symptoms or warnings prior to the failure.