2022 TOYOTA RAV4 PRIME — Problems, Recalls & Safety Data

The mechanized power liftgate— the rear door, the primary way to access the back of vehicle—fails to open & close as intended. A continuous beeping noise sounds due to the liftgate’s failure to fully open and close. We reported this issue to the dealer multiple times during 2025. The dealer refused to acknowledge or fix the problem.

The contact owns a 2022 Toyota Rav4 Prime. The contact stated that while driving approximately 50 MPH, there was a loud bang like a gunshot heard, and the sunroof shattered. The vehicle was pulled over to the side of the road, and the contact inspected the vehicle, but the contact was unable to determine the cause of the shattering of the sunroof glass. The vehicle was then taken to the residence. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 49,500.

The 12v battery keeps dying. The dealer has checked it multiple times and finally replaced it with a new one which has now died twice. The weather has not been freezing, car is garage, i don't leave anything on that would drain battery and I drive it several times a week. I have over 23,000 miles. It dies at worst time when I really need to go somewhere.

The idling on this car has had a slight knocking sound but it goes off when engine is warm and i have never got a check engine light. i noticed recently when driving the car had a slight jerk but still no check engine light. until traveling on day it came on and i scanned the codes and replaced all applicable parts - the electrical system is pointing to a bypass hose which was changed as well as a camshaft sensor which still didi not solve the issue. i check online it found many others had this problem. My camshaft was ticking when the car was under warranty around 40k miles but now the car is not. Code p136001 'A' Camshaft Actuator bank 1:General Electrical Failure Code p136415 'C' Camshaft Actuator bank 1: Circuit short to battery or open P268111 Engine coolant bypass valve: circuit short to Ground

The idling on this car has had a slight knocking sound but it goes off when engine is warm and i have never got a check engine light. i noticed recently when driving the car had a slight jerk but still no check engine light. until traveling on day it came on and i scanned the codes and replaced all applicable parts - the electrical system is pointing to a bypass hose which was changed as well as a camshaft sensor which still didi not solve the issue. i check online it found many others had this problem. My camshaft was ticking when the car was under warranty around 40k miles but now the car is not. Code p136001 'A' Camshaft Actuator bank 1:General Electrical Failure Code p136415 'C' Camshaft Actuator bank 1: Circuit short to battery or open P268111 Engine coolant bypass valve: circuit short to Ground