2002 TOYOTA CAMRY Engine And Engine Coolingengine Problems

IT IS 2002 TOYOTA CAMRY LE WITH 2.4L 2AZ-FE ENGINE. IT HAPPENED WHILE CAR WAS DRIVEN. ENGINE PRODUCED A LOUD BANG AND STALLED. DID NOT STARTED AFTER CRANKING IT. BEFORE TRIP THERE WAS NOTICEABLE STEAM OUT OF EXHAUST. AFTER CONSIDERING HEAD GASKET FAILURE THERE WAS ATTEMPT TO REPLACE THE GASKET. DURING REPAIR WAS FOUND THAT SEVERAL HEAD BOLTS WERE LOOSE DUE TO STRIPING FROM THEIR SITS. AFTER DIGGING IN GOOGLE IT WAS FOUND THAT WAS A COMMON PROBLEM FOR THIS ENGINES. IT SEEMS LIKE IT IS A MANUFACTURER DESIGN FLOW. ALL 2AZ-FE ENGINES ARE PRONE TO THIS BECAUSE OF INADEQUATE HEAT DISPERSION AT THE BACK OF THE ENGINE. TOYOTA CUSTOMER SERVICE RESPONSE IS THAT THEY HAVE NOTHING TO DO WITH IT. THIS IS A MAJOR DESIGN FLOW AND THERE SHOULD BE A RECALL. ALL ENGINES FROM 2002 ARE PRONE TO IT. *TR

MY 2002 TOYOTA CAMRY HAD STALLED-ENGINE PROBLEM THESE YEARS. MOST OF THE PROBLEM HAPPENED WHEN THE CAR STOPPED AT THE TRAFFIC RED LIGHT OR STOP SIGN. WHEN I APPLY THE BRAKE TO SLOW DOWN AND WAITING AT THE TRAFFIC LIGHTS OR AT THE STOP SIGN, MY CAMRY CAR ENGINE ABRUPTLY CEASES OPERATING AND STOPS TURNING. I HAVE TO TURN THE KEY AND START THE ENGINE AGAIN. THIS PROBLEM HAPPENED A LOT OF TIMES THESE YEARS AND GIVE ME A BIG TROUBLE WHEN A LOT OF OTHER CARS WAITING BEHIND ME. IT'S NOT SAFE AND BE DANGEROUS ESPECIALLY IN HEAVY TRAFFIC. THIS STALLED ENGINE PROBLEM JUST HAPPENED THIS MORNING WHEN I SENT MY SON TO THE BASEBALL GAME. *TR

2002 TOYOTA CAMRY SE V6 - AROUND SEPTEMBER 2009 I BEGAN TO NOTICE SUDDEN SURGES IN ACCELERATION WHILE DRIVING BETWEEN 40-45 MPH. WITHOUT CHANGING THE POSITION OF THE GAS PEDAL, THE VEHICLE WOULD SURGE-HESITATE-SURGE SEVERAL TIMES THEN SUDDENLY STOP THE BEHAVIOR. SINCE THEN, I NOTICE IT OCCURS AT LEAST ONCE EVERY 3 OUT OF 4 TIMES I'M DRIVING THE CAR. TO ME, THIS IS NOT RELATED TO ANYTHING ON THE FLOOR OR THE GAS PEDAL ITSELF. IT APPEARS TO COME FROM WITHIN THE ENGINE OR OTHER COMPONENT. NO REPAIRS HAVE BEEN INVESTIGATED OR PERFORMED. I AM CONSIDERING A VISIT TO THE DEALER. *TR

TL*THE CONTACT OWNS A 2002 TOYOTA CAMRY XLE. WHILE HE WAS AT A TRAFFIC LIGHT ON AN INCLINE, THERE WAS A VERY LOUD ROARING NOISE COMING FROM THE ENGINE. THE WEATHER WAS NOT A FACTOR. THE VEHICLE RESPONDED AS IF IT WERE GOING TO TAKE OFF AT FULL SPEED BUT IT DIDN'T. THE FAILURE OCCURRED A SECOND TIME WITH HER FOOT DEPRESSING THE BRAKE PEDAL. NEITHER THE DEALER NOR MANUFACTURER WAS CONTACTED. THE FAILURE MILEAGE WAS 74,800 AND THE CURRENT MILEAGE WAS 75,474.

TOYOTA CAMRY 2002. THE CHECK LIGHT CAME ON. THREE BOLTS WERE STRIP FROM THE ENGINE. TOYOTA IS AWARE OF IT AND DIDN'T DO ANYTHING. IT COST ME APPROX $4,000 TO FIX. TOYOTA ISSUED A TSB 2 YEARS AGO ABOUT THIS FAILURE: TSB 01507, NHTSA #10021542, DATED APRIL 6 2007. I FOUND THIS IN MY RESEARCH. MY MECHANIC TOLD ME TOYOTA SAID TO REPLACE THE HEAD, HEAD GASKET AND BOLTS. THAT THE HEAD HAD BEEN REDESIGNED SINCE IT WAS A KNOW ISSUE. IT WAS ALLEGED CAUSED WHEN TOYOTA CHANGED BUILDING THE HEAD FROM CAST IRON TO ALUMINUM. I AM NOT THE ONLY ONE WITH THIS ISSUE. WWW.TOYOTANATION.COM/FORUM/PRINTTHREAD.PHP?T=274802&PP=40. *TR

I KEPT HEARING RUSHING WATER COMING FROM SOMEWHERE BUT NOTHING SEEMS TO BE WRONG. SO AT THE END OF NOVEMBER MY CAR RAN HOT I TOOK IT TO THE MECHANIC AND WAS TOLD THE THERMOSTAT MAY NEED TO BE REPLACED. I REPLACED IT'.IT RAN HOT AGAIN THE NEXT DAY. WAS TOLD I HAD A COOLANT LEAK. TO MAKE A LONG STORY SHORT' I NEED AN ENGINE! STRIPPED HEAD BOLTS IN THE BLOCK, NO NOT JUST A HEAD GASKET PROBLEM I WAS TOLD THE HEAD BOLTS HAVE LET GO FROM THE BLOCK. I ASKED THE MECHANIC FOR A WRITE UP OF HIS FINDINGS: (PARAPHRASED) 'THE ONLY OPTION LEFT IS TO REMOVE THE HEAD, WHICH REQUIRES AN EXTENSIVE DISASSEMBLY (R AND R CYLINDER HEAD). AFTER LOOSENING THE BOLTS IN SEQUENCE, I NOTICE THE HEAD BOLTS IN THE BACK OF THE ENGINE ARE LOOSE. FROM MY EXPERIENCE IN THE FIELD, I CAN CONFIDENTLY...

LOSS OF COOLANT. TOOK TO AUTO REPAIR. TOLD TO REPLACE HEAD GASKET. UPON REPLACEMENT OF HEAD, DISCOVERED HEAD BOLTS WOULD NOT TIGHTEN BECAUSE THREADS IN ALUMINUM BLOCK WERE STRIPPED. *TR

2002 CAMRY XLE V6...AT 138,000 MILES WHILE WAITING AT A TRAFFIC SIGNAL DURING RUSH HOUR THE ENGINE STALLS AND AFTER 4 ATTEMPTS FINALLY RESTARTS. THE CAR CONTINUED TO NOT IDLE THE REST OF MY TRIP HOME - STALLING EVERY TIME I SLOWED DOWN TO STOP OR TURN A CORNER...VERY UNSAFE...DIDN'T TRUST THE CAR TO MAKE IT TO MECHANIC. CAR WAS TOWED, MECHANIC COULD FIND NOTHING WRONG. IT HAPPENED AGAIN 3 MORE TIMES WITHIN A WEEK. SAME SCENARIO, TOWED TO MECHANIC, FOUND NOTHING WRONG BECAUSE THE CHECK ENGINE LIGHT DOES NOT COME ON AND THEREFORE THE COMPUTER DOES NOT REGISTER ANY ISSUES. MECHANIC CLEANED ALL SENSORS, IDLE VALVE, DEALERSHIP AND INDEPENDENT MECHANIC FIND NOTHING WRONG. CAR WAS FINE UNTIL JULY 4, WEEKEND AND DID THE SAME THING TWICE AGAIN. MECHANIC FINDS NOTHING BECAUSE IT SO RANDOM. SAME SITUATION IN NOVEMBER WHILE TURNING CAR STALLED BECAUSE IT WOULD NOT IDLE, LOST POWER...

I OWN A 2002 TOYOTA CAMRY V6 LE WITH A MILEAGE READING OF ABOUT 115000. I DO REGULAR OIL CHANGES AND ALL NECESSARY SERVICES. HOWEVER OFF LATELY THE CAR HAS RANDOMLY STARTED TO STALL IN THE MIDDLE OF ROAD WHILE BEING DRIVEN. THIS HAS STARTED TO BE A BIG PROBLEM AND I HESITATE TO DRIVE THE CAR FOR LONG DISTANCE. THE CAR WOULD SUDDENLY DIE IN THE MIDDLE OF ROAD SPECIALLY WHEN I STOP FOR A LIGHT OR STOP SIGN AND THEN WOULD REFUSE TO START AGAIN. I HAVE TO KEEP THE GAS PEDAL DEPRESSED IN ORDER FOR THE CAR TO STAY IDLE AND NOT DIE. AFTER ABOUT 5-10 MINS THE CAR WOULD AGAIN START UP AND WORK NORMALLY. I'VE HAD THIS PROBLEM ABOUT THREE TIMES THIS PAST 2 WEEKS AND ITS SCARY NOW TO EVEN DRIVE THIS CAR ANYWHERE. I TOOK IT TO A MECHANIC WHERE I GET ALL...

MY 2002 TOYOTA CAMRY WITH 72,500 MILES HAD THE CHECK LIGHT COME ON. I TOOK IT TO A TOYOTA DEALER IN COLUMBIA, SC. I WAS TOLD THE ENGINE HAD SLUDGE AND WOULD SOON STOP WORKING. I TOLD THE DEALER I CHANGED THE OIL REGULARLY WHEN NEEDED BUT THE DEALER SAID IT WAS MY FAULT. *TR

MY 2002 CAMRY LE CHECK ENG. LIGHT CAME ON FROM A COOLANT LEAK WAS TOLD BY THE DEALERSHIP I NEEDED A NEW MOTOR AT THE COST OF $3,500 THE CAR WAS ONLY THREE YEARS OLD IT WAS A LEASE CERTIFIED BUY BACK ALSO WHEN I BOUGHT IT THE WINDSHIELD WASHER WENT BAD LESS THEN A MONTH WAS TOLD I HAD TO FIX ON MY OWN THEY THE MOTOR RAN HOT BUT THE COOLANT GAGE NEVER INDICATED THE PROBLEM. *TR

AT SUBZERO TEMPERATURE (BELOW 0) CAR STARTS WITH CHECK ENGINE LIGHT ON (ERROR CODE P1128), TRACTION CONTROL AND VSC DISABLED. IDLE AT 600-800 RPM. ENGINE DOES NOT RESPOND TO ACCELERATION PEDAL, SO CAR IS NOT DRIVABLE. AFTER WARMING ENGINE UP AND ERASING ERROR CODE FROM ECU CAR DRIVES NORMALLY. *TR

3/21/2008 CAR STOPPED RUNNING WHILE ON EXPRESSWAY. TOWED 50 MILES INTO DEALERSHIP ALAMO TOYOTA, SAN ANTONIO, TX =NOT WHERE PURCHASED 100 MILES FROM RESIDENCE. TOLD ENGINE MOUNTING BOLTS SHEERED OFF INTO THE ENGINE BLOCK WHICH CAUSED CRACK. ENGINE HAD TO BE REPLACED. DEALER FOUND SALVAGE ENGINE WITH 37000 MILES ON IT. OWNER DID NOT RECEIVE PROOF OF THE MILEAGE. DEALER KEPT USED ENGINE $4,000.00+. INCLUDED USED LONGBLOCK, OIL, OIL FILTER COOLANT REAR MAIN SEAL, FIPC, RADIATOR CLEANING. OWNER RENTED AT OWN EXPENSE RENTAL VEHICLE. TOLD CAR WAS REPAIRED. PICKED CAR UP DROVE OFF LOT, TURNED AROUND AND WENT BACK INTO DEALERSHIP. CAR WAS MISFIRING. HAD TO LEAVE CAR AGAIN. ADDITIONAL $235.00 TO REPLACE 4 COILS APRIL 11,2008. ON MAY 2 2008, A/C STOPPED COOLING. TOOK CAR INTO CHAMPION TOYOTA, AUSTIN TEXAS. $613.00 FOR AC CONDENSER, CONDENSER ASSY, RELAY, WARRANTY. AC CONDENSER LEAKING, PROBABLY DAMAGED DURING RADIATOR CLEANING AT ALAMO TOYOTA....

TL*THE CONTACT OWNS A 2002 TOYOTA CAMRY. WHILE DRIVING 2 MPH, SHE HEARD A GRINDING NOISE THEN THE VEHICLE SHUT OFF WITHOUT WARNING. THE DEALER STATED THAT ENGINE MOUNTING BOLTS SHEERED OFF INTO THE ENGINE BLOCK, WHICH CAUSED THE CORNER OF THE ENGINE TO CRACK. THE DEALER WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. AS OF JUNE 6, 2008, THE DEALER HAD NOT REPAIRED THE VEHICLE. THE FAILURE AND CURRENT MILEAGES WERE 92,000. THE VIN WAS UNAVAILABLE

TL*THE CONTACT OWNS A 2002 TOYOTA CAMRY. THE CONTACT STATED THAT THE ENGINE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. SHE STATED THAT THERE WAS A FAULTY CHARCOAL CANISTER THAT NEEDED TO BE REPLACED. THE CURRENT AND FAILURE MILEAGES WERE 82,630. UPDATED 07/15/08 *BF UPDATED *JB 07/15/08

AT ABOUT 105,000 MILES ON MY 2002 CAMRY V6, THE CAR EXPERIENCED HESITATING DRIVING WHILE DRIVEN AT SPEEDS ABOVE 40 MPH WHEN REMOVING SLIGHTLY THE FOOT FROM THE THROTTLE PEDAL. THE CAR IS BUCKING BACKWARD AND FORWARD FOR INDEFINITE TIME UNTIL THE THROTTLE PEDAL IS FULLY DEPRESSED OR FULLY PRESSED. THIS IS AN UNSAFE SITUATION SINCE ON THE HIGHWAY THE SPEED CANNOT BE DECREASED OR INCREASED ANY TIME. NOTIFIED DEALER AND TOLD THAT THIS CANNOT BE IDENTIFIED SINCE THERE IS NO ERROR CODE GENERATED (NO CHECK ENGINE LIGHT ON). REPLACED ALL SPARK PLUGS AT 108,000 MILES ON AUG 24, 2007. PROBLEM NOT SOLVED. SPOUSE NOTICED INCREASED BUCKING WHILE DRIVING DOWN HILL. WENT BACK TO THE DEALER. PERFORMED TEST DRIVE WITH TECHNICIAN IN THE CAR AND THE DIAGNOSE SYSTEM HOOKED TO THE CAR'S COMPUTER. DETECTED SOME MISFIRES ON CYLINDERS 5 AND 6. REPLACED SOLENOID IGNITION PACKS FOR CYLINDER 5 & 6...

I PURCHASED MY CAR IN 2001, USED WITH 17K MILES, FORM TOYOTA OF DURHAM. I HAVE 105K MILES NOW ON IT. I KEPT THE ROUTINE OIL CHANGE AND HAD SLUGGISH OIL PROBLEMS EVERY TIME I GOT MY OIL CHANGED. THERE WAS NO DOCUMENTED OIL SLUGGISH PROBLEM FROM TOYOTA. MY VEHICLE IS CLICKING WITH A STRANGE SOUND. I HAD IT LOOKED AT AND THE MECHANIC DETERMINED THE TIMING BELT IS GOING. BUT HE ADVISED ME TO TAKE IT TO THE DEALERSHIP WHERE I PURCHASED IT. I DID AND THEY TOLD ME THAT IT WAS THE ENGINE. I NEED A NEW ENGINE. A NEW ENGINE, NO WAY. HOW IS IT THAT A TOYOTA CAMRY WITH BARELY 100K MILES NEED A NEW ENGINE AND NOTHING IS SAID TO BE WRONG WITH THIS VEHICLE. I HAVE OWNED TOYOTA AND LEXUS MODELS FOR A LONG TIME NOW AND HAVE YET TO DEAL WITH SUCH SHAME...

I WAS SITTING AT A RED LIGHT WAITING TO TURN LEFT. I SUDDENLY HEARD MY ENGINE REV AND LOOKED AT THE DASH. THE RPM'S WERE ALL THE WAY OVER TO THE RIGHT. MY CAR LURCHED FORWARD, HARD, AND HIT A LINCOLN NAVIGATOR IN FRONT OF ME. I PRESSED THE BRAKE AS HARD AS I COULD, WITH BOTH FEET, TO TRY AND STOP, BUT ULTIMATELY HAD TO TURN THE CAR OFF TO STOP IT FROM MOVING FORWARD. I AM NOW WAITING FOR AN INVESTIGATION, WHICH THEY HAVE TOLD ME COULD TAKE UP TO 30 DAYS. I WAS TOLD THAT IF THEY DETERMINED THAT IT WAS A MECHANICAL FAILURE, THEY HAVE ANOTHER 30 DAYS TO FIX IT. I AM IN SALES AND USE MY CAR ALL DAY, EVERY DAY. THEY WEREN'T VERY CONCERNED ABOUT IT. *NM

DURING A REGULAR MAINTENANCE CHECK, IT WAS DISCOVERED THE ENGINE HAD A CRACK IN THE ENGINE BLOCK. THE CONSUMER MADE CONTACT WITH THE MANUFACTURER AND THEY WILL BE REPLACING THE ENGINE. *JB. TOYOTA HAS CORRECTED THE PROBLEM IN THE NEW MODELS OF CAMRY.*AK

DRIVER SIDE WINDOW DID NOT ROLL SMOOTHLY. SQUEAKED BUT WAS ONLY FIXED AFTER TAKING THE CAR A DEALER A THIRD TIME. SPUTTERING/RATTLING SOUND SEEMS TO BE COMING FROM THE ENGINE WHEN THE CAR IS IDLE OR UPON COLD START. SOUND GETS PROGRESSIVELY LOUDER. DEALER CLAIMS THAT NO SOUNDS WERE HEARD. CAR ALSO HESITATES WHEN RESPONDING TO ACCELERATION. IN RESEARCHING FOR ANSWERS, I FOUND THAT THE DRIVER'S SIDE AIRBAG HAS A RECALL. I WAS IN DISBELIEF WHEN I FOUND THAT NO EFFORTS WERE MADE IN CONTACTING ME ABOUT AN AIRBAG RECALL! I FEEL UTTERLY DISAPPOINTED. I'D COME FROM A "HONDA" FAMILY AND DECIDED TO GIVE TOYOTA A TRY. I HAVE LEARNT MY LESSON NOW THAT BUYING A BRAND NEW TOYOTA MEANS HAVING TO CHECK UP ON RECALLS AND PROBLEMS.*AK

CONSUMER TOOK VEHICLE' TO DEALER FOR AN OIL CHANGE, AND SINCE THEN THE VEHICLE EMITTED GRAY SMOKE. DEALER DETERMINED THAT TRANSMISSION NEEDED TO BE REPLACED. CONSUMER TOOK VEHICLE TO AN INDEPENDENT MECHANIC, WHO REPLACED CORRODED SPARK PLUG WIRES, AND GAVE THE VEHICLE A TUNE UP. ALSO THE MECHANIC DETERMINED THAT SMOKE CAME FROM A DEFECTIVE VALVE SEAL OR RINGS . *AK IT WAS FINALLY DETERMINED THAT THE TRANSMISSION WAS NOT THE PROBLEM IT WAS THE ENGINE WHICH NEEDED TO BE REPLACED. *JB

THE TRANSMISSION WAS NOT WORKING PROPERLY. THE VEHICLE WOULD SHIFT HARSHLY INTO DRIVE WHEN THE ENGINE WAS COLD BUT WHEN WARMED UP THE VEHICLE DROVE SMOOTHLY. THE STEERING WHEEL HUMMED WHEN TURNED WHILE DRIVING 45 MPH. IT WAS LATER DETERMINED THAT A BUSHING FOR THE STEERING SHAFT NEEDED TO BE LUBRICATED. THE UPPER AND LOWER BELT MOLDING AROUND THE DRIVER'S DOOR CAME OFF. A FAULTY CHARCOAL CANISTER CAUSED THE CHECK ENGINE LIGHT TO ILLUMINATE. *AK *NLM

WHILE TRAVELING ON THE HIGHWAY AND WITHOUT PRIOR WARNING ENGINE CHECK LIGHT APPEARED ON THE DASHBOARD. *AK

2002 XLE CAMRY OIL AND FILTER HAS BEEN CHANGED EVERY 3000-3500 MILES. AT THE FIRST 3000 MARK A SMALL AMOUNT OF METALLIC METAL WAS FOUND IN THE OIL. AT THE 9000 MARK OIL AND FILTER CHANGE (THIRD OIL CHANGE) A LARGER AMOUNT OF METALLIC METAL WAS FOUND IN THE OIL. BETWEEN THE THIRD OIL AND FILTER CHANGE THERE WAS NO EVIDENCE OF METAL UNTIL THE OIL CHANGE THAT WAS DONE AT 18145 MILES. MORE METAL IS FOUND IN THE OIL AT THE 18145 MILE OIL AND FILTER CHANGE. *NLM

WHILE TRAVELING ON INDIAN HEAD HIGHWAY, CONSUMER SWERVED TO AVOID A DEER, INSTEAD SWERVED TO THE RIGHT/LOST CONTROL AND HIT A GUARD RAIL. UPON IMPACT, FRONT AIR BAGS FAILED TO DEPLOY, DRIVER SUFFERED INJURIES, AND VEHICLE WAS DEMOLISHED. IN ADDITION, THERE WAS A SULFUR-LIKE OR ROTTON EGG ODOR COMING FROM EXHAUST SYSTEM. ALSO, BROUGHT VEHICLE TO DEALER FOR FOLLOWING PROBLEMS: POOR ALIGNMENT/ENGINE CHECK LIGHT/FUEL INJECTOR/ SPARK PLUGS, MIRRORS, AND STRUCTURAL DEFECTS *AK

I HAVE A 2002 TOYOTA CAMRY, AUTO, 4 CYLS. THE CAR HAS A SURGE LIKE MOVEMENT WHEN I TRY TO PULL OUT OF STOP, REDUCE SPEED THEN REACCELERATE AND PRESS THE GAS PEDAL AFTER TURNING THE CAR AT AN INTERSECTION. WHEN THE CAR ACCELERATES, IT INCREASE SPEED INITIALLY, THEN LOOSE POWER FOR A SECOND, AFTER THAT REGAIN SPEED. THE CAR ALSO ABRUPTLY REDUCES SPEED WHEN CRUISING BETWEEN 40 AND 60 MPH IF I RELEASE THE GAS JUST A LITTLE.

SINCE I PURCHASED THIS CAR IT HAS BEEN PROBLEMS, FIRST IT WAS THE BRAKES VIBRATING, TOOK IT IN AND RIGHT AWAY THE DEALER KNEW WHAT IT WAS WITHOUT ME EVEN EXPLAINING IT TO HIM, THEY FIXED THAT IN 2 TRIPS. THEN IT WAS THE ROTTEN EGG SMELL, THEY COULD NOT FIND ANYTHING WRONG.(THEN WHY DOES MY CAR STINK WHEN I TRY TO GET POWER OUT OF THE ENGINE?) THEN IT WAS THE KNOCKING AND PINGING IN THE ENGINE, (I WAS TOLD THAT THEY COULD NOT DUPLICATE THE PROBLEM, BUT MY OCTANE LEVEL WAS LOW TO UPGRADE MY GAS. THE MANUFACTURERS PROVIDED OWNERS MANUAL STATES 87 OCTANE GAS OR HIGHER, I ALREADY USE 89 OCTANE AND HAVE SINCE THE DAY I BOUGHT THE CAR, SO WHY SHOULD I HAVE TO SPEND MONEY ON HIGHER PRICED GAS WHEN THE CAR IS ONLY 1 YEAR OLD AND THE ENGINE SHOULD NOT MAKE ANY...