2001 TOYOTA 4RUNNER Structurebody Problems

The contact owns a 2001 Toyota 4Runner. The contact stated that he noticed a swaying while driving the vehicle. The vehicle was taken to a certified mechanic who stated that the sub frame was severely rusted between the sway bar and the differential. The certified mechanic referred the contact to the dealer. The contact took the vehicle to the dealer and was informed that the sub frame needed to be replaced. The dealer was concerned that the job was too extensive. The vehicle was not repaired. The manufacturer was made aware of the issue and referred the contact to the NHTSA for assistance. The approximate failure mileage was 119,000.

FIRST THERE WERE 3 RECALLS 1. 135468 2. 135469 AND 3. 135469 DATING BACK TO 2005 THAT I WAS NEVER NOTIFIED OF AND I HAVE A VERY BAD CORRUGATED METAL BUMPERS AND WHEN I DRIVE MY VEHICLE AND I HIT A BUMP OR SOMETHING IN THE ROAD IT FEELS LIKE MY CAR IS GOING TO TURN OVER. I HAD THE SHOCKS REPLACED AND IT HASN'T HELPED

THE VEHICLE FRAME HAS RUSTED THROUGH. MY MECHANIC SAYS THIS IS UNABLE TO BE INSPECTED AND SHOULD NOT BE DRIVEN.

THE FRAME OF MY 2001 TOYOTA 4RUNNER IS RUSTED TO THE POINT THAT YOU CAN BREAK SOME OF IT OFF IN OUR HAND. RECENTLY TOOK MY VEHICLE IN FOR AN OIL CHANGE AND WAS TOLD THAT IT WOULD NOT PASS INSPECTION IN ITS CURRENT CONDITION. THIS REQUIRED WELDING TO SOME SECTIONS IN ORDER TO KEEP DRIVING. THE WELDING WILL ONLY KEEP ME ON THE ROAD FOR NOW BUT THE OVERALL CONDITION OF THE FRAME IS VERY DETERIORATED. THE VEHICLE HAS OVER 205,000 MILES ON IT BUT HAS BEEN GARAGE KEPT AND MAINTAINED TO ALL OTHER STANDARDS. THE AUTO SHOP SAID THAT THE VEHICLE SHOULD NOT RUST THIS MUCH. I CALLED TOYOTA NATIONAL HEADQUARTERS AND THEY SAID THAT THE YEAR AND MODEL WAS NOT INCLUDED IN ANY RECALLS. I NEED THIS CAR SO I HAD THE GARAGE REPAIR THE IMMEDIATE SAFETY CONCERN. THIS WAS DISCOVERED BY THE TECHNICIAN CONDUCTING THE OIL...

PURCHASED VEHICLE TOOK FOR MASS INSPECTION AND FAILED DUE TO ROTTED FRAME WAS TOLD NOT ROAD WORTHY AND UNSAFE TO DRIVE CALLED TOYOTA THEY WOULD NOT ASSIST ON REPAIR VEHICLE HAS 145K MILES ON NOW VEHICLE DOTS ON MY DRIVEWAY OLDER GENTLEMAN I PURCHASED FROM WILL NOT ASSIST EITHER SPENT $4K NEED ASSISTANCE IF POSSIBLE PLEASE AND THANKS

I JUST PURCHASED A 2001 TOYOTA 4RUNNER. ALL SEEMED FINE .BUT WHEN I WENT TO GET IT INSPECTED THEY WOULD NOT PASS STARTING IT HAD FRAME RUST THROUGH. I CALLED TOYOTA CUSTOMER SERVICE WHO SAID AND I ALSO READ ONLINE THAT THOUSANDS OF TOYOTA TRUCKS HAVE A FRAME RECALL BUT MINE DOES NOT. AND THEY ARE NOT WILLING TO DO ANYTHING. OTHERS HAD THE FRAME REPLACED, REPAIRED OR BOUGHT BACK. HOPEFULLY YOU CAN HELP ME.

DEALER DECLINE TO DO A TRANSFER CASE REPAIR BECAUSE THE VEHICLE FRAME IS SEVERELY RUSTED TO THE POINT THAT THE TRAILING ARM MOUNT IS ALMOST GONE. DEALER ADVISED ME THAT THE VEHICLE IS UNSAFE AND THE FRAME WILL BREAK THROUGH. I WILL NEED TO BUY A NEW VEHICLE

VEHICLE FRAME CORROSION/ROT.. BAD FRAME (JUST LIKE THE TACOMA I HAD RECALLED DUE TO BAD FRAME)

I NOTICED A PRETTY DISTINCT WOBBLE WHEN DRIVING MY 2001 $RUNNER ON THE HIGHWAY RECENTLY. I TOOK IT TO A MECHANIC WHO INFORMAED MY THE FRAME HAS A 1 INCH WIDE 18 INCH LONG HOLE FROM RUST. THE MECHANIC SAYS THEY CAN WELD IT TO POSSIBLY GIVE IT SOME MORE TIME TO LIVE BUT THAT IT IS A TICKING TIME BOMB. THERE VERY WELL COULD BE RUST ON THE FRAME HIDDEN BEHIND THE GAS TANK, BUT I AM UNABLE TO LOOK BEHIND IT. TOYOTA NEEDS TO TAKE RESPONSIBILITY FOR THEIR MISTAKE WHEN NOT PROPERLY COATING THESE FRAMES. THEY RECALLED OTHER MODELS FOR THIS SAME ISSUE BUT FAILED TO ADDRESS THE ISSUE WITH THE 4RUNNER.

FRAME RUST ON MULTIPLE LOCATIONS. SUSPENSION SHOT RIGHT THROUGH ROTTED FRAME. FRAME HAS STRUCTURAL DAMAGE AS A RESULT OF RUST. CAR IS NOT SAFE TO DRIVE! I ALMOST KILLED MYSELF DRIVING THE CAR WHEN THE SUSPENSION PENETRATED RIGHT THROUGH THE ROTTED RUSTED FRAME.

EXTREME FRAME RUST. HUSBAND SAYS VEHICLE IS UNSAFE TO DRIVE. EVEN THOUGH THE BODY LOOKS GREAT, THE FRAME, WHERE WE CAN SEE IT, IS IN TERRIBLE CONDITION, WITH HOLES RUSTED THROUGH THE METAL. NO ACCIDENTS YET, BUT IT'S OMINOUS TO KNOW IN A COLLISION THIS VEHICLE WOULD CRUMPLE LIKE PAPER. THERE ARE MANY OTHER COMPLAINTS OF SERIOUS FRAME RUST FOR OTHER YEARS OF TOYOTA 4RUNNERS. PLEASE ADD MY VEHICLE AND SAFETY CONCERN TO THE GROWING LIST OF OTHER TOYOTA OWNERS FACING THE SAME FRAME DISINTEGRATION.

"TAKATA RECALL" MY 2001 TOYOTA 4RUNNER FRAME IS RUSTED OUT AND WON'T PASS STATE INSPECTION.

TL* THE CONTACT OWNS A 2001 TOYOTA 4RUNNER. THE CONTACT STATED THAT THE ENTIRE FRAME OF THE VEHICLE WAS RUSTED. THE VEHICLE WAS TAKEN TO NORTHWAY TOYOTA (727 NEW LOUDON RD, LATHAM, NY 12110, (888) 885-1583) AND THE CONTACT WAS INFORMED THAT THERE WAS NO RECALL TO COVER THE REPAIR. THE MANUFACTURER ECHOED THE DEALER'S STATEMENT AND ISSUED CASE NUMBER: 1809211044. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 150,000.

THE FRAME ON MY 2001 ROTTED VERY QUICKLY FROM THE INSIDE OUT. IT IS THE SAME EXACT FRAME USED ON THE TACOMA (WHICH WAS RECALLED) AND ON THE 2002 4RUNNER, WHICH IS CURRENTLY UNDER INVESTIGATION. IF I DIDN'T GET THE NECESSARY FRAME REPAIRS IT EASILY COULD HAVE CRACKED IN HALF WHEN ON THE ROAD. THE MAIN AREAS OF ROT ARE LOCATED AT THE REAR CONTROL ARM (WHICH I HAD PROFESSIONALLY REPAIRED), AND UP FRONT NEAR THE SUSPENSION AND AXLE. MY BROTHERS 1997 4RUNNER AXLE AND SUSPENSION COMPLETELY FELL APART WHEN HE WAS DRIVING ON THE ROAD. HE WAS LUCKY TO NOT BE ON THE HIGHWAY. SOMEONE DEFINITELY NEEDS TO LOOK INTO THIS ISSUE. I PURCHASED THE VEHICLE FROM THE SOUTH FOUR YEARS AGO (2014) WITH A SPOTLESS ROCK HARD FRAME. FOUR YEARS LATER THE REAR CONTROL ARM AREAS MENTIONED ABOVE COMPLETELY ROTTED THROUGH. THIS SHOULD NOT HAPPEN! I LOVE MY...

WENT FOR INSPECTION FOR 2001 TOYOTA 4 RUNNER. FRAME IS RUSTED AND TOO BAD. MECHANIC SAID UNSAFE TO BE ON THE ROAD. WHAT A SHAME EVERYTHING RUNS GOOD. NOW I AM WITHOUT A VEHICLE. THE TOYOTA 4 RUNNERS SHOULD HAVE BEEN RECALLED JUST LIKE THE TACOMA'S AND SEQUOIAS.

FRAME OF VEHICLE HAS SEVERE RUST DAMAGE THROUGHOUT, TOLD BY STATE SAFETY INSPECTOR THAT IT IS BEYOND REPAIR. APPEARS TO HAVE OCCURRED SLOWLY OVER THE COURSE OF MANY YEARS.

I WAS DRIVING MY TRUCK ON A CITY STREET IN BROOKLYN, NEW YORK ( FLATBUSH AVE) WHEN I SUDDENLY SMELLED SMOKE FOLLOWED BY FIRE COMING FROM THE HOOD. I DID NOT HIT ANY BUMP AND WAS NOT INVOLVED IN ANY ACCIDENT. BY THE TIME THE FIRE DEPARTMENT CAME, THE ENTIRE FRONT COMPARTMENT OF THE TRUCK WAS ON FIRE.

I WAS AT THE TOYOTA DEALERSHIP HAVING MY BRAKELINE ON THE FRONT LEFTSIDE REPAIRED, AFTER HITTING A POTHOLE; AND I WAS TOLD BY PHONE, MY FRAME IS BADLY RUSTED THROUGH IN MULTIPLE SPOTS.

TL* THE CONTACT OWNS A 2001 TOYOTA 4RUNNER. WHILE DRIVING 40 MPH, THE FRAME FAILED WITHOUT WARNING AND CAUSED THE VEHICLE TO WOBBLE. THE VEHICLE WAS DRIVEN HOME WHERE IT WAS PIECED BACK TOGETHER. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 180,000. UPDATED 11/13/17 *BF THE CONSUMER STATED THE FRAME RUSTED. UPDATED 11/16/2017*JS

FRAME RUSTED THROUGH IN SEVERAL PLACES. UNSAFE TO DRIVE.

MY FRAME HAS RUSTED OUT. I HAVE KEPT IT VERY CLEAN AND PROTECTED BUT STILL IS RUSTING.

TL* THE CONTACT OWNS A 2001 TOYOTA 4RUNNER. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR MAINTENANCE. THE MECHANIC NOTICED SEVERE RUST UNDER THE VEHICLE AND PIECES OF METAL FALLING OUT BY CHUNKS, INCLUDING THE FRAME. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 143,000.

TL* THE CONTACT OWNS A 2001 TOYOTA 4RUNNER. WHILE THE VEHICLE WAS UNDERGOING ROUTINE MAINTENANCE, THE CONTACT WAS INFORMED THAT THE REAR PASSENGER SIDE SUBFRAME DISPLAYED EXCESSIVE CORROSION. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS UNSAFE AND SHOULD NOT BE DRIVEN. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 125,063.

THE CHASIS RUSTS AND IS DAMAGED ON THE PASSENGER SIDE ABOUT 18 INCHES.

FRAME HAS RUSTED THROUGH THE FRAME RAILS IN MULTIPLE AREAS. ISSUE WAS NOT DISCLOSED WHEN THE VEHICLE WAS PURCHASED 01/13/2015, YET I FOUND A REPAIR ORDER FROM 09/24/2014 THAT STATED THERE WERE RUST HOLES IN THE FRAME. DEALER IS CURRENTLY INSPECTING THE EXTENT OF THE FRAME DAMAGE AND WILL RECOMMEND A RESOLUTION. I HAVE SEVERAL PHOTOS, BUT CURRENTLY DO NOT HAVE THEM HANDY.

FRAME RUSTING OUT. EXTERIOR OF TRUCK HAS NO RUST 170K MILES ON 4RUNNER

THE FRAME IS ROTTING AND THE 4RUNNER IS UNSAFE.

THE ISSUE WITH MY TOYOTA IS A RUSTED FRAME...RUSTED TO THE POINT THAT I WAS ADVISED TO PARK IT AND NEVER DRIVE IT AGAIN WITHOUT A NEW FRAME. ALTHOUGH IT IS A 2001 WITH 193,000 MILES, IT MECHANICALLY IS IN GREAT CONDITION. EXTERIOR AND INTERIOR IN GOOD CONDITION, AS WELL. I FIRST NOTICED THE VEHICLE HAD A FLOATING SENSATION ON THE HIGHWAY, AT TIMES FEELING LIKE I HAD NO CONTROL WITH THE STEERING WHEEL. AFTER ANOTHER 1-2 HRS OF DRIVING, I NOTICED THAT WHEN DRIVING OVER BUMPS OR DIPS IN THE ROAD, THE TRUCK WOULD ROCK SLIGHTLY SIDE TO SIDE. IT WAS SIGNIFICANT ENOUGH THAT ITEMS IN MY BACK SEAT ROCKED, AS WELL. AFTER SEVERAL MORE DAYS AND HOURS OF DRIVE-TIME THEREAFTER, THE ROCK ADVANCED TO THE POINT WHERE MY ENTIRE VEHICLE WAS ROCKING SO VIOLENTLY WHEN CROSSING A BRIDGE @40MPH, I HAD NO CONTROL OVER THE VEHICLE. EVEN BRAKING...

TL* THE CONTACT OWNS A 2001 TOYOTA 4RUNNER. WHILE REPLACING THE SHOCKS ON THE VEHICLE, THE CONTACT NOTICED SEVERE RUST ON THE FRAME AND A HOLE APPROXIMATELY 3 AND 1/2 INCHES WIDE UNDER THE DRIVER SIDE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 182,000.

WHILE CHANGING MY OIL, I NOTICED A FEW NICE SIZE HOLES IN THE FRAME, IN FRONT AND BESIDES THE MUFFLER. I WONDERING IS IT SAFE FOR ME AND MY FAMILY TO DRIVE ON A REGULAR BASIS.

MASSIVE RUST AND DETERIORATION ALONG INSIDE PANEL OF FRAME ON PASSENGER SIDE REVEALED ONCE EXHAUST SYSTEM WAS REMOVED FOR REPLACEMENT. DETERIORATED SECTION WAS ABOUT 24" LONG FROM REAR AXLE MOUNT TO CENTER STABILIZER BAR. UNKNOWN DETERIORATION ON DRIVER SIDE DUE TO LOCATION OF FUEL TANK.

TL* THE CONTACT OWNS A 2001 TOYOTA 4RUNNER. WHILE PERFORMING AN OIL CHANGE, THE TECHNICIAN NOTICED THAT THE REAR PASSENGER SIDE OF THE FRAME WAS COMPLETELY CORRODED. THE TECHNICIAN STATED THAT THE FRAME HAD TO EITHER BE RE-WELDED OR REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 160,000.

MASSIVE RUST CORROSION AND PIECES BREAKING AWAY LOCATED UNDERNEATH ENTIRE VEHICLE. THE RUST WITH BREAKAGE HAS INTENSIFIED GREATLY IN THE LAST COUPLE OF YEARS AND REQUIRED WELDING THIS YEAR TO PASS INSPECTION BECAUSE THE VEHICLE WAS UNSAFE. THE WELDING CONSISTED OF WELDING THE FRAME RAIL WHERE THE REAR SUSPENSION MOUNTS AND A NEW BRACKET HAD TO BE WELDED ON THE AXLE HOUSING THAT HOLDS AN UPPER REAR STRUT ROD BECAUSE IT RUSTED OFF. BOTH WERE ON THE PASSENGER SIDE OF VEHICLE. THIS VEHICLE ONLY HAS 101,000 MILES AND IS WASHED AND WAXED ON A REGULAR BASIS.

THE GRAM HAS RUST PERFORATION IN WHICH THE LEFT REAR CONTROL ARM HAS SEPARATED FROM THE FRAME. WHILE I WAS DRIVING A HEARD A POP AND STARTED TO LOSE PROPER CONTROL IN STEERING VEHICLE.

SINCE I GOT THE CAR, THE IGNITION KEY DOES NOT GET IN PROPERLY AND SOMETIMES DOES NOT START THE CAR. THE MOVEMENT OF THE WHEEL HELPS SOMETIMES. THERE HAVE ALSO BEEN LEAKING ENGINE COVERS THAT NEEDED TO BE REPLACED. THE STRUCTURE GETS RUSTY AND THERE IS PROBLEM WITH TRANSMISSION.

MY 2001 TOYOTA 4 RUNNER WAS UP ON THE LIFT FOR REGULAR OIL CHANGE. A SERVICE TECH BROUGHT ME TO THE SERVICE BAY AND INFORMED ME OF A CONSIDERABLE AMOUNT OF RUST FAILURE OF THE FRAME. NOT SURFACE RUST, BUT RUST THAT IS CAUSING THE FRAME TO SEPARATE CAUSING VISIBLE CRACKS TO APPEAR. HE ADVISED ME OF THE POTENTIAL DANGER. HE ADVISED ME THAT TOYOTA HAS ADDRESSED THIS ISSUE ON TUNDRA'S, TACOMA'S AND SEQUOIA'S BUT OFFERS NO RELIEF FOR 4RUNNER OWNERS. THE VEHICLE HAS 137,000 MILES ON IT. MY GUESS WAS THAT I HAD ANOTHER 20-30,000 MORE TO GO AS IT DOESN'T TRAVEL MANY MILES ON A DAILY BASIS. SEEMS HARD TO REASON THAT TOYOTA HAS HAD REPLACEMENT PLANS IN PLACE FOR OTHER MODELS WITH THE SAME PROBLEM BUT NOT FOR THE 4RUNNER.

THESE VEHICLES ARE NOTORIOUS FOR FRAME RUST/ROT. THE TACOMA OF THE SAME TIME PERIOD USED THE SAME FRAME AS THE 4RUNNER AND THE TACOMA HAS HAD A RECALL.

ECCESIVE RUST ON THE FRAME AND BODY MAKES IT UNSAFE TO DRIVE AS INTENDED

TL* THE CONTACT OWNS A 2001 TOYOTA 4RUNNER. THE CONTACT STATED THAT WHILE HAVING MAINTENANCE PERFORMED, THE TECHNICIAN NOTIFIED THE CONTACT THAT THE FRAME WAS ROTTED DUE TO EXCESSIVE CORROSION. THE DEALER WAS CONTACTED AND MADE AWARE OF THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 204,507.

THE BODY OF MY 2001 TOYOTA 4RUNNER IS COMPLETELY RUSTED OUT. RECENTLY, I BROUGHT THE VEHICLE TO A TOYOTA SERVICE CENTER WHO SUGGESTED THAT THE VEHICLE NO LONGER BE DRIVEN DUE TO SAFETY CONCERNS ASSOCIATED WITH DRIVING THE 4RUNNER IN ITS CURRENT CONDITION. I WAS TOLD THE FRAME WAS COMPLETELY RUSTED THROUGH, COMPROMISING THE INTEGRITY OF THE FRAME. *TR

THE 4RUNNER HAS DEVELOPED SURFACE RUST ON THE FRAME UNDERNEATH THE CAR. THE RUST IS ALSO APPARENT ON SUSPENSION COMPONENTS AND BRAKES. *TR

VEHICLE FAILED STATE INSPECTION DUE TO RUSTED FRAME. WITH THE EXCEPTION OF RUST ON THE BUMPERS (WHICH IS ALSO A COMMON PROBLEM FOR THIS GENERATION 4RUNNER) THE REST OF THE VEHICLE IS IN EXCELLENT SHAPE AND MECHANICALLY VERY RELIABLE. INSPECTION STATION SUGGESTED THAT I CONTACT TOYOTA SINCE THEY WERE AWARE OF RECALLS FOR RUSTED FRAMES ON OTHER TOYOTA TRUCKS (TACOMA, SEQUOIA FOR EXAMPLE.) TOYOTA STATED THAT THERE ARE NO RECALLS FOR 4RUNNERS BUT OFFERED A $500 CUSTOMER LOYALTY REBATE IF I WERE TO PURCHASE A NEW OR CERTIFIED USED TOYOTA VEHICLE. I BELIEVE THIS IS A POTENTIAL SAFETY ISSUE SINCE THE RUSTED FRAME PROBLEM WOULD ONLY BE IDENTIFIED BY A VERY THOROUGH INSPECTION OF THE UNDERBODY OF THE TRUCK. IT IS POSSIBLE THAT THERE ARE MANY OTHER 4RUNNERS OF THIS GENERATION THAT ARE ON THE ROAD WITH AN UNDIAGNOSED RUSTED FRAME PROBLEM. *TR

TOOK VEHICLE TO LOCAL TOYOTA DEALERSHIP FOR SAFETY AND MECHANICAL INSPECTION AFTER PURCHASING USED; MECHANIC NOTES THAT FRAME IS RUSTED THROUGH ON PASSENGER SIDE, NEAR LOWER TRAILING ARM BRACKET AND ON DRIVERS SIDE NEAR FUEL TANK SKID PLATE. DAMAGE APPEARS TO HAVE ORIGINATED ON THE INSIDE OF THE FRAME AND HAS EATEN ITS WAY TO THE OUTSIDE. MECHANIC ADVISED THAT VEHICLE MAY NOT BE SAFE TO DRIVE, NO RECALL BY TOYOTA ON 4RUNNERS DESPITE SIMILAR ISSUES WITH SAME YEAR TACOMA. *TR

TL* THE CONTACT OWNS A 2001 TOYOTA 4RUNNER. THE CONTACT STATED THAT THE DEALER FOUND THE SUFRAME CORRODED IN THE FUEL TANK AREA WHILE THE FRONT ROTORS AND BRAKE PADS WERE BEING REPLACED. THE FRAME WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 112,080.

BROUGHT VEHICLE TO TOYOTA DEALER FOR REMOVAL OF SEIZED HARDWARE. TECHNICIAN POINTED OUT RUST SPOT ON FRAME, ROT HAS SPREAD TO WHEEL WELL ON BOTH SIDES OF FRAME AND HAS CONTINUED DOWN TO TRANSMISSION CROSSMEMBER. TECHNICIAN POINTED OUT ROT HAS EATEN THROUGH FRAME ON BOTH SIDES AT REAR CONTROL ARM BRACKET. SPOKE WITH OTHER EARLY 2000'S 4RUNNER OWNERS WHO ALL HAVE ROT IN SAME PLACES. PREVENTATIVE MAINTENANCE PRACTICES HAVE BEEN USED ON THIS VEHICLE SINCE I PURCHASED IT. FRAME HAS NO DRAINAGE HOLES FORWARD OF RUST HOLES IN WHEEL WELLS. CONCERNED FOR OTHER 4RUNNER OWNERS WHO ARE UNAWARE OF RUST SPOTS BY CONTROL ARM BRACKETS. FURTHER RUST ON FRAME IN SAME SPOT ON OTHER VEHICLES COULD RESULT IN SEPARATION OF BRACKET, CONTROL ARM AND REAR AXLE FROM FRAME. *TR

TL* THE CONTACT OWNS A 2001 TOYOTA 4RUNNER. THE CONTACT STATED THAT THE FRAME WAS RUSTED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE THE FAILURE WAS CONFIRMED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED, SEVERAL TIMES. THE FAILURE MILEAGE WAS APPROXIMATELY 200,000. UPDATED 12/20/13*CN THE CONSUMER STATED THE VEHICLE IS ON THE SAME FRAME AS OTHER RECALLED TOYOTA VEHICLES. UPDATED 12/26/13

TL* THE CONTACT OWNS A 2001 TOYOTA 4RUNNER. THE CONTACT STATED THAT WHILE HAVING ROUTINE MAINTENANCE PERFORMED ON THE VEHICLE, SHE WAS INFORMED BY AN INDEPENDENT MECHANIC THAT DUE TO THE MASSIVE AMOUNT OF CORROSION TO THE FRAME, THE VEHICLE WAS UNSAFE TO DRIVE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 125,000.

TL* THE CONTACT OWNS A 2001 TOYOTA 4RUNNER. THE CONTACT STATED THAT HE NOTICED THE MUFFLER MAKING A LOUD NOISE WHEN DRIVING AT VARIOUS SPEEDS. THE CONTACT INSPECTED THE VEHICLE AND FOUND THAT THE REAR SUB FRAME MOUNT AREA WAS CORRODED AND EXHIBITED HOLES. THE MANUFACTURE ADVISED THE CONTACT THAT THE VEHICLE WAS A CANADIAN VEHICLE THEREFORE IT COULD NOT BE REPAIRED IN THE UNITED STATES. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 229,000.

FRAME RUSTED THROUGH AT REAR NEAR MUFFLER. BOTTOM OF FRAME SECTION APPROXIMATELY 4" MISSING , INSIDE OF FRAME PERFORATED THROUGH APPROXIMATELY 18". REAR SUPPORT ROD STRUCTURAL INTEGRITY COMPROMISED. VEHICLE WAS PURCHASED NEW FROM LOCAL DEAL (LYNCH TOYOTA, MANCHESTER CT) AND IS ONE OWNER GARAGED AND MAINTAINED. CONTACTED TOYOTA AND LOCAL DEALER. BOTH UNWILLING TO TAKE ANY ACTION. NO RECALL ON THIS VEHICLE. *TR

3RD GENERATION 2001 TOYOTA 4RUNNER WITH EXCESSIVE FRAME AND BODY RUST. THE GAS TANK STEM IS RUSTED, THE REAR DIFFERENTIAL IS LITERALLY POROUS AND LEAKING OIL DUE TO EXCESSIVE RUST. REAR BUMPER IS RUSTED, SPARE TIRE MOUNT IS RUSTED. OTHER AREAS OF RUST ARE TOO NUMEROUS TO LIST. REPAIR SHOP SAID CAR IS NOT WORTH FIXING. DANA CORP THAT MADE FRAMES FOR TOYOTA TACOMAS/TUNDRAS THAT WERE RECALLED ALSO IS BEST KNOW FOR REAR DIFFERENTIALS. WHY WEREN'T THE 4RUNNERS INCLUDED IN THE RECALL/BUYBACK BY TOYOTA? *TR