2007 THOMAS BUILT BUSES MINOTOUR — Problems, Recalls & Safety Data
N/A
Safety Rating
0
Owner Complaints
23
Recalls
1
Service Bulletin
0
Investigations
Overview of the 2007 THOMAS BUILT BUSES MINOTOUR
The 2007 THOMAS BUILT BUSES MINOTOUR has received a total of 0 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). There have been 23 recall campaigns affecting this vehicle, covering issues with EQUIPMENT ADAPTIVE/MOBILITY. 1 technical service bulletin have been issued by FREIGHTLINER LLC for this model year.
Recalls for the 2007 THOMAS BUILT BUSES MINOTOUR
NHTSA has recorded 23 recalls for the 2007 THOMAS BUILT BUSES MINOTOUR, potentially affecting up to 36,175 vehicles.
Recall 19V170000 — EQUIPMENT ADAPTIVE/MOBILITY
| 410 vehicles affected
Defect: Daimler Trucks North America LLC (DTNA) is recalling certain 2003-2019 Thomas Built Buses Minotour school buses built on a Ford chassis equipped with a specific wheelchair lift option. The wheelchair lift can be operated without the parking brake being engaged after they key is turned off.
Consequence: When the vehicle is in neutral with the ignition and the parking brake off, the vehicle may move. Using the wheelchair lift during this time can increase the risk of injury.
Remedy: DTNA has notified owners, and dealers will modify the wheelchair lift wiring harness, free of charge. DTNA issued owners an interim notification on April 10, 2019. The recall began December 20, 2019. Owners may contact DTNA customer service at 1-800-547-0712....
View full details →Recall 18V301000 — EQUIPMENT ADAPTIVE/MOBILITY
| 1,688 vehicles affected
Defect: Daimler Trucks North America LLC (DTNA) is recalling certain 2002-2018 Thomas Built Buses Minotour school buses built on a Ford chassis and equipped with an optional wheelchair lift. The wheelchair lift may be allowed to operate when the vehicle is in neutral or drive, due to missing relay in the interlock wiring harness.
Consequence: If the vehicle can be moved while the wheelchair lift is being used, there is an increased the risk of injury.
Remedy: DTNA will notify owners, and dealers will inspect the wheelchair lift wiring, correcting it as necessary, free of charge. Daimler issued an interim notification to owners on June 19, 2018. The recall began November 15, 2019. Owners may contact DTNA...
View full details →Recall 18V157000 — EQUIPMENT ADAPTIVE/MOBILITY
| 3,304 vehicles affected
Defect: Daimler Trucks North America LLC (DTNA) is recalling certain 2007-2018 Thomas Built Buses Minotour school buses built on GM chassis and equipped with wheelchair lifts. The wheelchair lift may be operated while the vehicle is in Neutral or Drive.
Consequence: If the wheelchair lift can be operated when the vehicle is not in Park, there is increased risk of injury to the lift user.
Remedy: DTNA will notify owners, and dealers will inspect the wheelchair lift, correcting the electrical connections as necessary, free of charge. DTNA issued owners an interim notification on April 26, 2018. The recall began November 15, 2018. Owners may contact DTNA...
View full details →Recall 18V158000 — EQUIPMENT ADAPTIVE/MOBILITY
| 14 vehicles affected
Defect: Daimler Trucks North America LLC (DTNA) is recalling certain 2007-2018 Thomas Built Buses Minotour transit buses built on GM chassis and equipped with wheelchair lifts. The wheelchair lift may be operated while the vehicle is in Neutral or Drive.
Consequence: If the wheelchair lift can be operated when the vehicle is not in Park, there is increased risk of injury to the lift user.
Remedy: DTNA will notify owners, and dealers will inspect the wheelchair lift, correcting the electrical connections as necessary, free of charge. DTNA issued owners an interim notification on April 26, 2018. The recall began November 15, 2018. Owners may contact DTNA...
View full details →Recall 18V083000 — EQUIPMENT
| 606 vehicles affected
Defect: Daimler Trucks North America LLC (DTNA) is recalling certain 2002-2017 Thomas Built Buses Saf-T-Liner C2, Saf-T-Liner HDX, FS65, and Minotour school buses, equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach...
Consequence: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.
Remedy: DTNA will notify owners instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall is expected to begin March 30, 2018. Owners may contact DTNA customer service at 1-800-547-0712 or Kidde customer service at 1-855-262-3540...
View full details →Recall 15V565000 — EQUIPMENT ADAPTIVE/MOBILITY
| 4,334 vehicles affected
Defect: Daimler Trucks North America LLC (DTNA) is recalling certain model year 2006-2015 Thomas Built Buses FS-65, Saf-T-Liner C2, Saf-T-Liner EF, Saf-T-Liner EFX, Saf-T-Liner HDX, and Minotour DRW school buses manufactured January 3, 2006, to August 1, 2014, and equipped with certain Ricon model S2005, S2010, S5005, S5010, S5505, S5510 wheelchair lifts. The affected lifts are equipped with folding link arms...
Consequence: If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.
Remedy: DTNA will notify owners, and dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began onNovember 2, 2015. Owners...
View full details →Recall 15V564000 — EQUIPMENT ADAPTIVE/MOBILITY
| 52 vehicles affected
Defect: Daimler Trucks North America LLC (DTNA) is recalling certain model year 2006-2015 Thomas Built Buses Saf-T-Liner HDX, Saf-T-Liner EF, Saf-T-Liner EFX, and Minotour DRW transit buses manufactured January 3, 2006, to August 1, 2014, and equipped with certain Ricon model S2005, S2010, S5005, S5010, S5505, S5510 wheelchair lifts. The affected lifts are equipped with folding link arms that may have...
Consequence: If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.
Remedy: DTNA will notify owners, and dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on November 2, 2015....
View full details →Recall 12V226000 — EQUIPMENT ADAPTIVE/MOBILITY
| 100 vehicles affected
Defect: DAIMLER TRUCKS NORTH AMERICA (DTNA) IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2011 SAF-T-LINER EF, MINOTOUR, SAF-T-LINER C2, SAF-T-LINER HDX TRANSIT BUSES EQUIPPED WITH BRAUN CENTURY-2 AND VISTA-2 WHEELCHAIR LIFTS. OVER TIME, AND WITH FREQUENT USE, THE ROLL STOP LATCHES ON THE OUTER BARRIER MAY BECOME BENT OR MISALIGNED.
Consequence: A WHEELCHAIR OCCUPANT MAY DEFEAT OR RIDE OVER THE INSUFFICIENTLY LATCHED ROLL STOP. IF THIS OCCURS WHEN THE LIFT PLATFORM IS IN AN ELEVATED POSITION, THE WHEELCHAIRS OCCUPANT COULD FALL AND SUSTAIN INJURY.
Remedy: DTNA WILL NOTIFY OWNERS, AND THE REPAIRS WILL BE PERFORMED BY AUTHORIZED BRAUN DEALERS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 28, 2012. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.
View full details →Recall 12V225000 — EQUIPMENT ADAPTIVE/MOBILITY
| 890 vehicles affected
Defect: DAIMLER TRUCKS NORTH AMERICA (DTNA) IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2011 SAF-T-LINER EF, MINOTOUR, SAF-T-LINER C2, AND SAF-T-LINER HDX SCHOOL BUSES EQUIPPED WITH BRAUN CENTURY-2 AND VISTA-2 WHEELCHAIR LIFTS. OVER TIME, AND WITH FREQUENT USE, THE ROLL STOP LATCHES ON THE OUTER BARRIER MAY BECOME BENT OR MISALIGNED.
Consequence: A WHEELCHAIR OCCUPANT MAY DEFEAT OR RIDE OVER THE INSUFFICIENTLY LATCHED ROLL STOP. IF THIS OCCURS WHEN THE LIFT PLATFORM IS IN AN ELEVATED POSITION, THE WHEELCHAIRS OCCUPANT COULD FALL AND SUSTAIN INJURY.
Remedy: DTNA WILL NOTIFY OWNERS, AND THE REPAIRS WILL BE PERFORMED BY AUTHORIZED BRAUN DEALERS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 28, 2012. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.
View full details →Recall 11V204000 — EQUIPMENT:OTHER:LABELS
| 526 vehicles affected
Defect: CERTAIN MODEL YEAR 2000-2003, 2005 AND 2006 THOMAS BUILT MINOTOUR SCHOOL BUSES BUILT ON FORD AND GM CHASSIS FROM APRIL 17, 2000, THROUGH AUGUST 29, 2008. THESE BUSES WERE EQUIPPED WITH AN INCORRECT TIRE LOAD CERTIFICATION LABEL. THE CERTIFICATION LABELS LIST "D" LOAD RANGE TIRES WITH A RECOMMENDED COLD TIRE INFLATION PRESSURE GREATER THAN 65 PSI. THE BUSES ARE EQUIPPED...
Consequence: INCORRECT TIRE INFORMATION MAY LEAD TO VEHICLE OVERLOADING THAT CAN RESULT IN A TIRE FAILURE WHICH MAY LEAD TO A VEHICLE CRASH.
Remedy: DTNA WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE INCORRECT LABEL WITH A CORRECT LABEL FREE OF CHARGE OR, IF THE OWNER WISHES, THEY MAY REPLACE THE LABEL THEMSELVES. OWNERS SHOULD CONTACT DTNA AT 1-800-547-0712 OR THOMAS BUILT AT 1-336-889-4871...
View full details →Recall 11V222000 — EQUIPMENT:APPLIANCE:AIR CONDITIONER
| 6,831 vehicles affected
Defect: DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2011 SAF-T-LINER C2, SAF-T-LINER HDX, MVP-EF, FS-65, AND MINOTOR SCHOOL BUSES MANUFACTURED FROM JANUARY 2, 2006, THROUGH JANUARY 31, 2011, EQUIPPED WITH CARRIER GENV EM-1 EVAPORATOR UNITS. DUE TO TIME, TEMPERATURE, AND/OR VIBRATION, THE FUSE MAY LOOSEN IN THE FUSE HOLDER RESULTING IN HIGH RESISTANCE AND ARCING.
Consequence: IF SUFFICIENT ARCING OCCURS, THE FUSE HOLDER MAY MELT, AND A VEHICLE FIRE MAY OCCUR.
Remedy: DTNA WILL NOTIFY OWNERS AND PROVIDE INFORMATION ON HOW TO OBTAIN THE RETROFIT KIT FROM CARRIER ALONG WITH REPAIR INSTRUCTIONS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 20, 2011. (SEE CARRIER'S RECALL CAMPAIGN...
View full details →Recall 11V223000 — EQUIPMENT:APPLIANCE:AIR CONDITIONER
| 64 vehicles affected
Defect: DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2011 SAF-T-LINER HDX, MVP-EF, AND MINOTOR NON SCHOOL BUSES MANUFACTURED FROM JANUARY 2, 2006, THROUGH JANUARY 31, 2011, EQUIPPED WITH CARRIER GENV EM-1 EVAPORATOR UNITS. DUE TO TIME, TEMPERATURE, AND/OR VIBRATION, THE FUSE MAY LOOSEN IN THE FUSE HOLDER RESULTING IN HIGH RESISTANCE AND ARCING.
Consequence: IF SUFFICIENT ARCING OCCURS, THE FUSE HOLDER MAY MELT, AND A VEHICLE FIRE MAY OCCUR.
Remedy: DTNA WILL NOTIFY OWNERS AND PROVIDE INFORMATION ON HOW TO OBTAIN THE RETROFIT KIT FROM CARRIER ALONG WITH REPAIR INSTRUCTIONS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 20, 2011. (SEE CARRIER'S RECALL CAMPAIGN...
View full details →Recall 11V201000 — EQUIPMENT:OTHER:LABELS
| 6,360 vehicles affected
Defect: CERTAIN MODEL YEAR 2000 THROUGH 2009 THOMAS BUILT SCHOOL BUSES MANUFACTURED FROM APRIL 17, 2000, THROUGH DECEMBER 21, 2009, WERE EQUIPPED WITH AN INCORRECT TIRE LOAD CERTIFICATION LABEL. THE CERTIFICATION LABELS LIST "D" LOAD RANGE TIRES WITH A RECOMMENDED COLD TIRE INFLATION PRESSURE GREATER THAN 65 PSI. THE BUSES ARE EQUIPPED WITH LOAD RANGE "E" TIRES THAT REQUIRE A HIGHER...
Consequence: INCORRECT TIRE INFORMATION MAY LEAD TO VEHICLE OVERLOADING THAT CAN RESULT IN A TIRE FAILURE WHICH MAY LEAD TO A VEHICLE CRASH.
Remedy: DTNA WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE INCORRECT LABEL WITH A CORRECT LABEL FREE OF CHARGE OR, IF THE OWNER WISHES, THEY MAY REPLACE THE LABEL THEMSELVES. OWNERS SHOULD CONTACT DTNA AT 1-800-547-0712 OR THOMAS BUILT AT 1-336-889-4871...
View full details →Recall 10V394000 — ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES
| 14 vehicles affected
Defect: DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2004 THROUGH 2010 MINOTOUR NON SCHOOL BUSES BUILT ON FORD CHASSIS MANUFACTURED FROM MAY 6, 2004 THROUGH FEBRUARY 2, 2010. ON AFFECTED VEHICLES, MAIN BODY POWER CABLES WERE ROUTED IN THE AREA OF AN UNPROTECTED EDGE ON THE PASSENGER'S SIDE INNER-FENDER. UNDER CERTAIN CONDITIONS A POWER CABLE MAY CONTACT THE SHARP EDGE. IF...
Consequence: A SHORT CIRCUITED POWER CABLE COULD RESULT IN A VEHICLE FIRE AND INJURY TO VEHICLE OCCUPANTS.
Remedy: DAIMLER TRUCKS WILL INSPECT AND REROUTE AND/OR REPLACE AS NEEDED. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE NOVEMBER 15, 2010. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712.
View full details →Recall 10V393000 — ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES
| 4,179 vehicles affected
Defect: DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2004 THROUGH 2010 SCHOOL BUSES BUILT ON FORD CHASSIS MANUFACTURED FROM MAY 6, 2004 THROUGH FEBRUARY 2, 2010. ON AFFECTED VEHICLES, MAIN BODY POWER CABLES WERE ROUTED IN THE AREA OF AN UNPROTECTED EDGE ON THE PASSENGER'S SIDE INNER-FENDER. UNDER CERTAIN CONDITIONS A POWER CABLE MAY CONTACT THE SHARP EDGE. IF UNDETECTED, CONTINUED...
Consequence: A SHORT CIRCUITED POWER CABLE COULD RESULT IN A VEHICLE FIRE AND INJURY TO VEHICLE OCCUPANTS.
Remedy: DAIMLER TRUCKS WILL INSPECT AND REROUTE AND/OR REPLACE AS NEEDED. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE NOVEMBER 15, 2010. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712.
View full details →Recall 09V219000 — VISIBILITY:GLASS, SIDE/REAR
| 216 vehicles affected
Defect: DAIMLER TRUCKS IS RECALLING 216 MODEL YEAR 2004 THROUGH 2009 THOMAS BUILT MINOTOUR SCHOOL BUSES MANUFACTURED FROM FEBRUARY 5, 2003 THROUGH JULY 3, 2008. VEHICLES WITH CERTAIN SEAT BACK AND WINDOW COMBINATIONS MAY BE CONFIGURED IN SUCH A WAY THAT THE EMERGENCY WINDOW RELEASE MECHANISM IS LOCATED OUTSIDE OF THE LOW-FORCE REGION WHICH FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE...
Consequence: IN THE EVENT OF AN EMERGENCY EVACUATION, IMPROPERLY LOCATED EMERGENCY EXIT RELEASE MECHANISMS MAY DELAY EVACUATION AND INCREASE THE RISK OF PERSONAL INJURY TO VEHICLE OCCUPANTS.
Remedy: DAIMLER TRUCKS WILL NOTIFY OWNERS AND REPAIR THE BUSES FREE OF CHARGE. REPAIRS WILL BE PERFORMED BY DAIMLER TRUCKS NORTH AMERICA. THE SAFETY RECALL BEGAN ON NOVEMBER 17, 2009. OWNERS MAY CONTACT DAIMLER TRUCKS CUSTOMER SUPPORT OFFICE AT 1-336-889-4871.
View full details →Recall 08V648000 — EQUIPMENT:OTHER:LABELS
| 2,590 vehicles affected
Defect: DAIMLER TRUCKS NORTH AMERICA (DTNA) IS RECALLING 2,590 MY 2005 THROUGH 2009 THOMAS BUILT MINOTOUR SCHOOL BUSES WITH GVWR OF 10,000 POUNDS OR LESS, MANUFACTURED BETWEEN SEPTEMBER 1, 2004 AND NOVEMBER 26, 2008. THE TIRE PLACARD CONTAINS INCORRECT INFORMATION WHICH FAILS TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, TIRE SELECTION AND RIMS.
Consequence: INCORRECT INFORMATION ON THE TIRE PLACARD MAY LEAD TO TIRE OVERLOADING AND POSSIBLY CAUSE TIRE FAILURE WHICH MAY RESULT IN A VEHICLE CRASH.
Remedy: NEW LABELS WILL BE SENT TO OWNERS FOR INSTALLATION. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT NOVEMBER 3, 2009. OWNERS MAY CONTACT DTNA AT 1-800-547-0712 OR THOMAS BUILT AT 1-336-889-4871.
View full details →Recall 08V432000 — EQUIPMENT ADAPTIVE/MOBILITY
| 1,046 vehicles affected
Defect: DAIMLER TRUCKS IS RECALLING 2,250 MY 2006 AND 2007 THOMAS BUILT MINOTOUR, FS65, C2, HDX, AND MVP EF SCHOOL BUSES AND RECREATIONAL VEHICLE CHASSIS MANUFACTURED BETWEEN MARCH 9, 2005 AND FEBRUARY 23, 2007, EQUIPPED WITH RICON S OR K SERIES WHEELCHAIR LIFTS. THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING...
Consequence: A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.
Remedy: DAIMLER TRUCKS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS (PLEASE SEE 07E097). THE RECALL BEGAN ON NOVEMBER 26, 2008. OWNERS MAY CONTACT RICON AT 1-800-322-2884 OR THOMAS BUILT AT 1-336-889-4871.
View full details →Recall 08V430000 — EQUIPMENT ADAPTIVE/MOBILITY
| 1,419 vehicles affected
Defect: DAIMLER TRUCKS IS RECALLING 1,419 MY 2006 THROUGH 2008 THOMAS BUILT SCHOOL BUSES AND RECREATIONAL VEHICLE CHASSIS MANUFACTURED BETWEEN MARCH 7, 2005 AND MAY 27, 2008, EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY...
Consequence: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
Remedy: THOMAS BUILT IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). THE RECALL BEGAN ON NOVEMBER 26, 2008. OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR THOMAS BUILT 1-336-889-4871.
View full details →Recall 08V088000 — EQUIPMENT ADAPTIVE/MOBILITY
| 760 vehicles affected
Defect: DAIMLER TRUCKS IS RECALLING 760 MY 2003-2007 THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JULY 6, 2005 AND JULY 19, 2006, EQUIPPED WITH BRAUN WHEELCHAIR LIFTS, MODELS NL, NCL, OR NVL. THE THRESHOLD WARNING SYSTEMS OF THE SUBJECT MODEL WHEELCHAIR LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES.
Consequence: SHOULD THE THRESHOLD WARNING SYSTEM FAIL TO OPERATE, THE LIFT USER CAN FALL FROM THE VEHICLE AND BE SERIOUSLY INJURED.
Remedy: DAIMLER TRUCKS WILL NOTIFY OWNERS AND PROVIDE A FREE REMEDY WHICH WILL BE PERFORMED BY THOMAS BUILT DEALERSHIPS. THE RECALL BEGAN ON AUGUST 8, 2008. OWNERS MAY CONTACT THOMAS BUILT AT 336-889-4871.
View full details →Recall 07V135000 — EQUIPMENT ADAPTIVE/MOBILITY
| 329 vehicles affected
Defect: CERTAIN MY 2006 AND 2007 THOMAS BUILT MINOTOUR, FS-65, C2, HDX, AND EF SCHOOL BUSES MANUFACTURED BETWEEN JANUARY 6 AND SEPTEMBER 6, 2006, EQUIPPED WITH RICON WHEELCHAIR PLATFORM LIFT MODELS S2003, S2005, S2010, S5503, S5505, S5510, K2003, K2005, K2010, K5503, K5505, K5510. THE LIFTS INTERLOCK SWITCH SYSTEM MAY NOT DETECT THE PRESENCE OF A PASSENGER (EITHER WHEELCHAIR OR STANDEE) ON...
Consequence: THE DEFECT INVOLVES THE INTERLOCK SWITCH SYSTEM IN THE LIFT NOT DETECTING THE PRESENCE OF A PASSENGER (EITHER WHEELCHAIR OR STANDEE) ON THE RICON WHEELCHAIR PLATFORM LIFT. IN THE EVENT THIS CONDITION OCCURS DURING PASSENGER OPERATIONS IT MAY BE POSSIBLE FOR THE WHEELCHAIR TO TIP BACKWARDS ONTO THE PLATFORM WHEN THE PLATFORM WAS LOWERED. THIS COULD RESULT IN INJURY TO THE WHEELCHAIR'S OCCUPANT. ALSO, ANYONE STANDING ON THE PLATFORM COULD LOSE HIS OR HER BALANCE AND FALL, RESULTING IN INJURY.
Remedy: FREIGHTLINER WILL NOTIFY OWNERS AND WILL REPAIR THE AFFECTED BUSES FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON AUGUST 6, 2007. OWNERS CAN CONTACT FREIGHTLINER'S CUSTOMER ASSISTANCE CENTER AT 800-385-4357 OR CONTACT RICON AT 800-322-2884.
View full details →Recall 07V040000 — EQUIPMENT ADAPTIVE/MOBILITY
| 398 vehicles affected
Defect: CERTAIN MY 2006 AND 2007 THOMAS BUILT BUSES MINOTOUR SCHOOL BUSES MANUFACTURED BETWEEN JULY 1, 2005, AND NOVEMBER 1, 2006, EQUIPPED WITH A WHEELCHAIR LIFT OPTION. PLASTIC ZIP TIES FOUND AROUND THE WHEELCHAIR LIFT INTERLOCK SWITCHES MAY PREVENT THE SWITCH FROM OPERATING, DEFEATING THE INTERLOCK FUNCTION ALLOWING THE VEHICLE TO BE DRIVEN WITH THE LIFT STILL DEPLOYED.
Consequence: MOVING THE VEHICLE WITH THE LIFT DEPLOYED COULD CAUSE INJURY TO BYSTANDERS OR A CRASH.
Remedy: FREIGHTLINER WILL NOTIFY OWNERS AND INSPECT THE BUSES. ANY PLASTIC TIES FOUND ON THE SWITCHES WILL BE REMOVED. THE RECALL BEGAN ON MAY 21, 2007. OWNERS CAN CONTACT FREIGHTLINER CUSTOMER ASSISTANCE CENTER AT 800-385-4357.
View full details →Recall 06V150000 — EQUIPMENT ADAPTIVE/MOBILITY
| 45 vehicles affected
Defect: CERTAIN MY 2004-2007 THOMAS BUILT MINOTOUR, FS65, MVP-EF, AND HDX MODEL SCHOOL BUSES, MANUFACTURED BETWEEN JUNE 16 AND JULY 1, 2005, EQUIPPED WITH RICON WHEELCHAIR LIFTS. CRACKS IN THE LIFT ARMS MAY ALLOW THE MECHANISM TO TWIST DURING STOWAGE, PREVENTING CLOSURE OF THE SAFETY INTERLOCK SWITCHES.
Consequence: IN THE EVENT THIS CONDITION OCCURS DURING PASSENGER OPERATIONS IT MAY NOT BE POSSIBLE TO CLOSE THE LIFT DOOR CAUSING THE VEHICLE INTERLOCKS TO REMAIN ENGAGED PREVENTING MOVEMENT OF THE VEHICLE OR THE ABILITY TO LOAD OR UNLOAD PASSENGERS WITH DISABILITIES FROM THE VEHICLE.
Remedy: RICON IS CONDUCTING THIS RECALL (PLEASE SEE 06E008000) AND WILL REPLACE THE TWO VERTICAL ARMS EVEN IF ONLY ONE ARM IS CRACKED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON MAY 30, 2006. OWNERS MAY CONTACT RICON CUSTOMER...
View full details →Owner Complaints for the 2007 THOMAS BUILT BUSES MINOTOUR
No complaints have been filed with NHTSA for the 2007 THOMAS BUILT BUSES MINOTOUR.
Safety Rating for the 2007 THOMAS BUILT BUSES MINOTOUR
NHTSA has not yet tested the 2007 THOMAS BUILT BUSES MINOTOUR in its New Car Assessment Program.
Technical Service Bulletins for the 2007 THOMAS BUILT BUSES MINOTOUR
FREIGHTLINER LLC has issued 1 technical service bulletin (TSBs) for the 2007 THOMAS BUILT BUSES MINOTOUR. TSBs are notices sent by manufacturers to their dealers describing a known issue and the recommended repair procedure.
SF521 — EQUIPMENT:OTHER:LABELS
TBB Entrance Door Labels
NHTSA Investigations for the 2007 THOMAS BUILT BUSES MINOTOUR
There are no NHTSA defect investigations on record for this vehicle.
Other Model Years of the THOMAS BUILT BUSES MINOTOUR
- 2002 THOMAS BUILT BUSES MINOTOUR — 0 complaints
- 2003 THOMAS BUILT BUSES MINOTOUR — 0 complaints
- 2004 THOMAS BUILT BUSES MINOTOUR — 0 complaints
- 2005 THOMAS BUILT BUSES MINOTOUR — 1 complaint
- 2006 THOMAS BUILT BUSES MINOTOUR — 0 complaints
- 2007 THOMAS BUILT BUSES MINOTOUR (current)
- 2008 THOMAS BUILT BUSES MINOTOUR — 0 complaints
- 2009 THOMAS BUILT BUSES MINOTOUR — 0 complaints
- 2010 THOMAS BUILT BUSES MINOTOUR — 0 complaints
- 2011 THOMAS BUILT BUSES MINOTOUR — 0 complaints
- 2012 THOMAS BUILT BUSES MINOTOUR — 0 complaints
Other THOMAS BUILT BUSES Models
- THOMAS BUILT BUSES SAF-T-LINER C2 — 25 total complaints
- THOMAS BUILT BUSES C2 — 10 total complaints
- THOMAS BUILT BUSES SAF-T-LINER HDX — 10 total complaints
- THOMAS BUILT BUSES FS-65 — 6 total complaints
- THOMAS BUILT BUSES MVP EF — 4 total complaints
- THOMAS BUILT BUSES EF — 2 total complaints
- THOMAS BUILT BUSES HDX — 2 total complaints
- THOMAS BUILT BUSES SAF-T-LINER ER — 2 total complaints