2019 TEREX TL80 — Problems, Recalls & Safety Data
N/A
Safety Rating
0
Owner Complaints
2
Recalls
2
Service Bulletins
0
Investigations
Overview of the 2019 TEREX TL80
The 2019 TEREX TL80 has received a total of 0 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). There have been 2 recall campaigns affecting this vehicle, covering issues with EQUIPMENT. 2 technical service bulletins have been issued by Terex South Dakota, Inc. for this model year.
Recalls for the 2019 TEREX TL80
NHTSA has recorded 2 recalls for the 2019 TEREX TL80, potentially affecting up to 83 vehicles.
Recall 20V696000 — EQUIPMENT
| 40 vehicles affected
Defect: Terex South Dakota, Inc. (Terex) is recalling certain 2019-2020 TL80 and TL100 aerial devices. The rotation bearing bolts may loosen during unit use, causing them to fail.
Consequence: If the rotation bearing bolts fail, the boom could fall, increasing the risk of injury or death.
Remedy: Terex will notify owners, and dealers will install Field Service Kit Z1604 which includes replacement rotation bearing bolts, washers, pedestal reinforcement plates, and bolt spacers, free of charge. Owners are advised to perform a pre-shift inspection procedure until the repair...
View full details →Recall 20V240000 — EQUIPMENT
| 43 vehicles affected
Defect: Terex South Dakota, Inc. (Terex) is recalling certain 2019-2020 TL80 and TL80/112 aerial devices. The installed slope indicator and decals incorrectly state that the chassis can be 5 degrees out of level for aerial device use.
Consequence: If the aerial device is used with the chassis out of level it may result in an unstable condition which may cause the unit to tip, increasing the risk of injury to the operator and any bystanders.
Remedy: Terex will notify owners, and dealers will replace the incorrect slope indicator and decals, free of charge. The recall began May 12, 2020. Owners may contact Terex customer service at 1-605-882-4000. Terex's number for this recall is SN685.
View full details →Owner Complaints for the 2019 TEREX TL80
No complaints have been filed with NHTSA for the 2019 TEREX TL80.
Safety Rating for the 2019 TEREX TL80
NHTSA has not yet tested the 2019 TEREX TL80 in its New Car Assessment Program.
Technical Service Bulletins for the 2019 TEREX TL80
Terex South Dakota, Inc. has issued 2 technical service bulletins (TSBs) for the 2019 TEREX TL80. TSBs are notices sent by manufacturers to their dealers describing a known issue and the recommended repair procedure.
TERE-05042021-02 — ENGINE AND ENGINE COOLING
Update older TL80, TL100, and TL80/112 aerials built from 03/2019 to 08/2020 to current production. Includes boom tie down, jib transport position, and reduce chance of control valve leakage.
TERE-05042021-03 — EQUIPMENT
Increase the rotation gearbox attachment torque on TL80, TL100, and TL80/112 aerial devices at the next maintenance interval to reduce chance of loosening and possible damage to the gearbox. Remind of required daily pre-shift inspection requirements.
NHTSA Investigations for the 2019 TEREX TL80
There are no NHTSA defect investigations on record for this vehicle.
Other Model Years of the TEREX TL80
- 2019 TEREX TL80 (current)
- 2020 TEREX TL80 — 0 complaints
Other TEREX Models
- TEREX AL4 — 1 total complaint
- TEREX DFP HD — 1 total complaint
- TEREX XT55 — 1 total complaint
- TEREX AERIAL DEVICES — 0 total complaints
- TEREX C4000 — 0 total complaints
- TEREX C5000 — 0 total complaints
- TEREX C6000 — 0 total complaints
- TEREX C7000 — 0 total complaints