2006 SUZUKI VZR1800 Power Train Problems

I HAVE A 2006 M109R WITH THE INFAMOUS 2ND GEAR SLIPPING OUT IN TO NEUTRAL ISSUE. THE BIKE HAS 12,000 MILES BUT THE SYMPTOMS STARTED AS EARLY AS 7,000 MILES. I HAVE THE BIKE IN THE SHOP WITH A $3600 BILL FOR FIXING THE TRANSMISSION. I'VE NEVER HAD ANY PROBLEMS OF THIS NATURE WITH ANY OTHER MOTORCYCLES I'VE EVER OWNED. I OWN A 2016 DUCATI MONSTER 1200R THAT SHIFTS PERFECTLY. SUZUKI DROPPED THE BALL WITH THESE TRANSMISSIONS AND SHOULD OWN UP TO IT.

THE 2006 VZR1800 SUZUKI MADE, AS WELL AS MODELS UP THOUGH 2010 HAVE SHIFTING FORKS IN THE TRANSMISSION THAT ARE TOO SOFT, THEY BEND AND THE TRANSMISSION IS SENT BACK INTO NEUTRAL. UNDER EXTREME CIRCUMSTANCE WHERE RIDERS DO NOT HAVE THE FINANCIAL MEANS TO FIX THIS PROBLEM, >$3000+S&H [MYSELF INCLUDED], THE TRANSMISSION FULLY LOCKS UP, THE REAR WHEEL ALSO, AND THE MOTOR. CATASTROPHIC FAILURE OCCURS. RIDER INJURY IS HIGHLY LIKELY IN THIS EVENT. THE ABOVE MENTIONED EVENT HAPPENS WHEN THE MOTORCYCLE IS IN OPERATION WITH RIDER ENGAGED, ANYTIME. *TR

THE BIKE HAS A ROUTINE SLIP IN 2ND GEAR ONLY ABOVE 20 MPH AT A DEAD STOP. IT'S NOT SAFE TO DRIVE WHEN SHIFTING FROM 1ST TO 2ND GEAR UNDER HEAVY ACCELERATION, AS THE SLIP COULD CAUSE AN ACCIDENT OR RIDER INJURY. THE SLIPPING FROM 1ST TO 2ND GEAR IS WORSE WHEN THERE'S A PASSENGER AND/OR HEAVIER LOADS. THIS ISSUE CAUSES YOU TO EITHER SKIP 2ND GEAR OR NOT RIDE THE BIKE AT ALL. THE REPAIR IS VERY EXPENSIVE AND TIMELY, IF YOU CAN EVEN GET ANYONE TO DO THE WORK. I'VE OWNED SEVERAL SUZUKI'S AND HAVE NEVER HAD AN ISSUE, BUT THIS ONE IS VERY DISAPPOINTING. SUZUKI REFUSES TO ASSIST AT ALL, AND THERE ARE SEVERAL CASES OF THE EXACT SAME THING, ESPECIALLY WITH 2006 AND 2007 MODELS. MY BIKE ONLY HAS 15,000 MILES ON IT WITH LOTS OF CUSTOM ACCESSORIES. IT'LL ALL GO TO WASTE IF I TRADE...

TL*THE CONTACT OWNS A 2006 SUZUKI VZR1800K6 MOTORCYCLE. THE CONTACT STATED THAT THE TRANSMISSION WAS SLIPPING. THE CONTACT MENTIONED THAT THE TRANSMISSION WOULD SLIP FROM SECOND TO THIRD GEAR BEFORE IT SEIZED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO THE DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 0.

BIKE WOULD BUCK, AS IF MAYBE BROKEN TEETH ON GEAR, POP OUT OF GEAR, AND ON OTHER OCCASIONS ACT NORMAL, TOOK BIKE IN UNDER WARRANTY TOLD ME IT WAS A CLUTCH PROBLEM, KEPT BIKE EXCESSIVE TIME SUPPOSEDLY REPLACED CLUTCH. PICKED UP THE BIKE PROBLEM STILL EXISTED, TOOK IT BACK, THEY TEST DROVE IT, DID NOT SEE A PROBLEM. SO I TOOK IT HOME AGAIN PROBLEM GOT WORSE AGAIN, DID NOT HAVE TIME TO GET IT BACK TO THEM, WHEN I FINALLY GOT TIME TO TAKE IT BACK, THEY SAID IT WAS NO LONGER UNDER WARRANTY BUT THEY ATTEMPTEDE ANOTHER REPAIR ANYWAY, RETURNED IT TO ME SAYING IT WAS REPAIRED. TURNED OUT STILL THE SAME PROBLEM BUT THEN STREESED IT WAS NO LONGER UNDER WARRANTY AND THE REPAIR WOULD COST APPROX. $2000 TO REPAIR. TOO MAKE A LONGER STORY SHORT I HAVE LIVED WITH IT BUT NOW IT CONSTANTLY POPS OUT...

TL* THE CONTACT OWNS A 2006 SUZUKI VZR1800 MOTORCYCLE. THE CONTACT STATED THAT WHILE TRAVELING 35 MPH, THE VEHICLE SLIPPED OUT OF GEAR AND FORCED THE CONTACT TO THE SIDE OF THE ROAD. THE FAILURE ONLY OCCURRED IN SECOND GEAR. THE CONTACT CALLED TO SPEAK WITH THE DEALER AND WAS ADVISED THAT THE TRANSMISSION WOULD NEED REPLACING. THE VIN WAS NOT AVAILABLE. THE FAILURE AND THE CURRENT MILEAGE WAS 21,000. *TR

I RECENTLY TOOK A RIDE ON MY 2006 SUZUKI M109R AND THE TRANSMISSION KEPT SLIPPING IN AND OUT OF 1ST-4TH GEARS WHILE I WAS ACCELERATING. IF I ACCELERATED VERY SLOWLY THIS WOULDN'T HAPPEN SO I RODE HOME SLOWLY. LAST FRIDAY THE 20TH OF MAY 2011 I WAS CHANGING MY OIL ON MY MOTORCYCLE AND BEFORE LOWERING THE LIFT TO CLEAN UP I NOTICED THE REAR SWING ARM WAS CRACKED IN 2 PLACES. IT IS CRACKED NEAR THE MOUNTING FLANGE FOR THE REAR DIFFERENTIAL. I WAS NOT RIDING WHEN IT BROKE. IF I WOULD HAVE BEEN THE SPEED LIMIT ON I-90 GOING TO STURGIS,SOUTH DAKOTA IS 75MPH AND I BELIEVE THE RESULTS WOULD HAVE BEEN FATAL. THE SWING ARM ON A MOTORCYCLE WITH ONLY 4100 MILES ON IT SHOULD NOT BREAK. ALSO THE TRANSMISSION IS PROBABLY MESSED UP BECAUSE OF THE SWING ARM FAILURE. I PROBABLY GOIN TO SELL THIS MOTORCYCLE...

LEAVING A TRAFFIC LIGHT, ACCELERATING THUR FIRST GEAR GOING TO SECOND GEAR, IT WILL POP OUT OF SECOND GEAR AND GO INTO NUETREL. AND NOW I HAVE TRAFFIC RUNNING OVER MY BACK. VERY SCARY.

REAR BRAKE ROTOR ON 2006 M109R SUZUKI MOTORCYCLE, WHAT IS SUPPOSE TO BE A SEMIFLOATING ROTOR HAS TURNED INTO A FULL FLOATING ROTOR (THE RIVETS THAT ATTACH THE OUTER RING TO THE INNER RING HAVE BECOME LOOSE, BOTH SIDE-TO-SIDE AND FRONT-TO-BACK). SUZUKI TOLD ME AT 9K MILES THIS WAS NORMAL, YET OTHER OWNERS HAVE HAD THEIRS REPLACED AT NO CHARGE. I HAVE SINCE BOUGHT ANOTHER ROTOR BUT I STILL HAVE THE OLD ONE. ALSO THE BIKE IS DEVELOPING A VIOLENT SHUTTER (CLUTCH RELATED I THINK) WHEN STARTING OFF, DOESN'T DO IT EVERY TIME BUT WHEN IT DOES THE ONLY WAY TO CORRECT IT IS TO PULL IN THE CLUTCH ALL THE WAY AND START OVER. THIS COULD BE QUITE HAZARDOUS IF YOU HAVE TRAFFIC BEHIND YOU. *TR

1.) ENTERING THE HIGHWAY AND MOVING INTO TRAFFIC. 2.) TRANSMISSION FAILURE. 3.) 2ND AND 3RD GEAR AND ALL THREE SHIFTER FORKS ARE BEING REPLACED. NO COVERAGE FROM SUZUKI OR 3RD PARTY EXTENDED WARRANTY (WESTERN STATES). BIKE WAS PURCHASED IN JULY OF 2006, 11K MI. AT TIME OF FAILURE. FEEL THAT THE DEALERSHIP DID WHAT THEY COULD TO GET IT COVERED. *TR