2003 SUZUKI SV1000S Electrical Systemignition Problems

HTTP://WWW.SV-PORTAL.COM/FORUMS/SHOWTHREAD.PHP?T=27074 NO ELECTRICAL POWER?? GREEN CONNECTOR ISSUE! MY BIKE LOST POWER AND CANNOT BE STARTED. FORTUNATELY I WAS NOT RIDING AT THE TIME THE POWER CUT OUT. I HAD TO FIND ANOTHER RIDE HOME AS THE BIKE WAS IMMOBILE. APPARENTLY THIS DOES OCCUR REGULARLY AND BOTH NHTSA AND SUZUKI ARE AWARE OF THE PROBLEM AND DOING NOTHING ABOUT IT. READ THE FORUM ABOVE FOR MANY INSTANCES OF THIS PROBLEM. *TR

TL*THE CONTACT OWNS A 2003 SUZUKI SV1000S MOTORCYCLE. ON TWO SEPARATE OCCASIONS, THE VEHICLE COMPLETELY SHUT OFF WITHOUT WARNING. THE VEHICLE WOULD NOT RESTART AND HAD TO BE TOWED BOTH TIMES. THE DEALER STATED THAT THE IGNITION HARNESS WAS FAULTY AND REPLACED IT TWICE. THE SPEED WAS UNKNOWN. THE CURRENT MILEAGE WAS 27,000 AND FAILURE MILEAGE WAS 23,000.

THE GREEN CONNECTOR ON THE SUZUKI SV1000S MOTORCYCLE BURNED OUT, CAUSING THE MOTORCYCLE ENGINE TO DIE COMPLETELY ON A HIGH TRAFFIC STREET. PRIOR TO THE COMPLETE FAILURE OF THE CONNECTOR THE MOTORCYCLE WOULD INTERMITTENTLY DIE FOR A FEW SECONDS, AND EITHER RESUME NORMALLY IF IN TRANSIT OR DIE IF IT WAS STATIONARY. WHEN THE ENGINE DIED ALL ELECTRICAL FUNCTIONS CEASED EVEN IF THE KEY WAS IN ACCESS MODE. TURNING THE KEY SEVERAL TIMES FROM OFF TO ACCESS WOULD RESUME THE ELECTRICAL FUNCTIONS. AFTER FINDING A BULLETIN BOARD THREAD ON THE MOTORCYCLE'S SYMPTOMS, THIS LEAD ME TO THE GREEN CONNECTOR"FAILURE. I DISASSEMBLED THE MOTORCYCLE AND LOCATED THE CONNECTOR. SURE ENOUGH, THE CONNECTOR WAS FRIED . REMOVED THE DAMAGED CONNECTOR AND REPLACED THEM WITH SPADE TERMINALS. SO FAR, THE MOTORCYCLE WORKED FINE.*AK CHECK THIS URL FOR MORE INFORMATION AND PHOTOS. MY POSTS ARE TOWARDS THE BOTTOM UNDER THE NAME "RXSX": HTTP://WWW.SV-PORTAL.COM/FORUMS/SHOWTHREAD.PHP?T=20730&PAGE=17

AS PER THE ADVICE OF ANOTHER PERSON, I CHECKED THE IGNITION ELECTRICAL HARNESS. IT WAS BURNT AND READY TO FAIL. SINCE THIS IS A MOTORCYCLE AN IGNITION FAILURE COULD BE DEADLY. LOSS OF POWER IN A TURN WOULD CAUSE A MOTORCYCLE TO CRASH. THE WIRING WAS REPAIRED BY BYPASSING THE HARNESS. THERE ARE NUMEROUS PEOPLE I HAVE BEEN IN CONTACT WITH THAT HAVE EXPERIENCED THE SAME PROBLEM. THERE SHOULD BE A RECALL ON THE WIRING HARNESS, INCLUDING FULL REPLACEMENT OF THE WIRING. *NM

THERE IS A FAULTY WIRING HARNESS ON THE IGNITION OF MY 2003 SUZUKI SV1000S MOTORCYCLE. A FEW FRIENDS FOUND THIS PROBLEM AND ONE CRASHED THE BIKE BECAUSE OF THIS PROBLEM. I SIMPLY INSPECTED MY BIKE AFTER HEARING ABOUT THIS PROBLEM AND FOUND THAT THIS WAS THE CASE IN MY IGNITION. THE HARNESS CANNOT SUSTAIN THE CURRENT LOAD AND MELTS, CAUSING THE MOTORCYCLE TO SHUT DOWN. THIS SHOULD BE A RECALL BY SUZUKI TO PREVENT ANY MORE DANGEROUS SITUATIONS. FIRE IS A POSSIBILITY OR CRASHING DUE TO TOTAL LOSS OF ENGINE POWER. *NM

IGNITION CUTOUT ON MY 2003 SUZUKI SV1000S MOTORCYCLE LEFT ME STRANDED. MY BIKE HAD TO BE TOWED AT CONSIDERABLE EXPENSE. THE DEALER REPORTS THAT I NEED A NEW IGNITION AND ELECTRICAL CONNECTOR. SIMILAR INCIDENTS HAVE BEEN REPORTED (HTTP://WWW.SV1000.ZYNS.COM/FORUMS/SHOWTHREAD.PHP?T=8174&PAGE=2&HIGHLIGHT=IGNITION+CUTOUT), YET SUZUKI FAILS TO COVER REPLACEMENT COSTS. *NM