2003 SUZUKI GRAND VITARA Electrical System Problems

SOMETIMES IT WANT START AT ALL

TL*THE CONTACT OWNS A 2003 SUZUKI GRAND VITARA. THE CONTACT EXPERIENCED DIFFICULTY STARTING THE VEHICLE. HE DISCOVERED THAT THE BATTERY CABLE WAS GROUNDING OUT AGAINST THE BODY OF THE VEHICLE, WHICH CAUSED THE FAILURE. THE CONTACT STATED THAT THE VEHICLE IS UNSAFE DUE TO THE CURRENT RECALLS ON THE VEHICLE, ALTHOUGH HE HAS NOT EXPERIENCED ANY OF THE FAILURES NOTED IN THE RECALLS. THE FAILURE MILEAGE WAS 70,000.

DT*: THE CONTACT STATED WHILE DRIVING UNDER ANY CONDITIONS OR SPEED, THE BRAKE LIGHTS FAIL DUE TO A BLOWN FUSE. AFTERWARDS WHEN THE VEHICLE IS STOPPED, IT US UNABLE TO BE PLACED INTO THE PARK POSITION UNTIL THE FUSE HAS BEEN REPLACED. THE VEHICLE WAS TAKEN TO DEALER FOR INSPECTION. IT WAS DETERMINED THE ELECTRICAL SYSTEM WAS THE PROBLEM HOWEVER IT IS UNKNOWN WHAT REPAIRS WILL CORRECT THE PROBLEM.

8/14/03 - 2003 SUZUKI GRAND VITARA, [XXX], PURCHASED AT SUZUKI OF DES MOINES, PO BOX 13377, DES MOINES IA 50310, 515-270-5800. 1/13/04 - RECEIVED RECALL LETTER REGARDING ACCELERATOR CABLE CASING CAP. 1/17/04 - HAD CAR REPAIRED. 9/9/04 - HEADLIGHTS ON AT END OF DAY WHEN LEAVING WORK AND BATTERY DEAD. JUMP-STARTED CAR AND TOOK TO DEALER; NOTICE SMELL OF SOMETHING BURNING. 9/21/04 - CAR FINALLY FIXED. INVOICE STATES: DRL LIGHTS STAY ON PULLED INSIDE AND FOUND LIGHT DO NOT TURN OFF BUT MARKER LIGHTS NOT ON ALSO NOTICED BCM FLASHING CLOCK HOOKED UP TECH 2 AND FOUND CODE P1121 LOOKED UP CODE IN BOOK AND RUN TEST HAD TO REMOVE BCM FROM DASH TO INSPECT ECT WIRING RUN TEST AND BCM APPEARS TO BE OK BUT FOUND WIRE NOT GIVING PROPER READING DISCONNECT RELAY AND LIGHT STILL ON DISCONNECT HIGH BEAM RELAY AND LIGHTS GO OFF CHECKED AND FOUND HIGH/LOW...

WHILE DRIVING, THE DRIVER WAS ABLE TO AIR COMING INSIDE OF THE VEHICLE WHEN THE ALL WINDOWS WERE CLOSED. ALSO, THE HEADLIGHTS WILL CAME ON AND WENT OFF BY THEMSELVES. THIS IS A HAZARD TO THE DRIVER'S VISIBILITY AT NIGHT. THIS WAS A CONTINUOUS PROBLEM. *JB