2003 SUZUKI AERIO — Problems, Recalls & Safety Data

STARTED THE CAR TO WARM IT UP, AND SMOKE CAME OUT OF DASH BOARD, MAKING GLASS WHERE SPEEDOMETER IS SMOKEY AND IT STILL IS. SMELT LIKE WIRE BURNING AND SHUT IT OFF IMMEDIATELY. WHEN CHECKED ON, A WIRE INSULATION HAD BURNT OFF CAUSING THE SMOKE AND SMELL. AFTER REPLACING THE WIRE COATING, IT WAS FINE FOR A WHILE, THEN COMING BACK FROM A TRIP TO AUGUSTA THE SPEEDOMETER NUMBER GOT DIMMER, BUT I DID NOT SMELL ANY SMOKE. SO NOT SURE WHAT THE DEFECT IS, JUST KNOW THIS CAN'T BE RIGHT. *TR

TL* THE CONTACT OWNS A 2003 SUZUKI AERIO SX WAGON. THE CONTACT STATED THAT THE MANUAL TRANSMISSION DISLODGED FROM THE FIFTH GEAR WHILE DRIVING 55 MPH. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE CONTACT WAS INFORMED THAT THE TRANSMISSION NEEDED TO BE REPAIRED. THE VEHICLE WAS THEN TAKEN TO AN INDEPENDENT REPAIR SHOP AND THE FIFTH GEAR OF THE TRANSMISSION WAS REPAIRED. THE CONTACT WAS ALSO INFORMED THAT THE FIFTH GEAR WAS EXTERNALLY HOUSED, CAUSING THE FAILURE. THE REMAINING GEARS WERE ALL INTERNALLY HOUSED AND OPERATED AS NORMAL. THE FAILURE RECURRED APPROXIMATELY ONE WEEK LATER. THE VEHICLE WAS TAKEN BACK TO THE REPAIR SHOP AND REPAIRS WERE AGAIN PERFORMED. THE FAILURE HAD SINCE CONTINUOUSLY RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 82,000.

TL*THE CONTACT OWNS A 2003 SUZUKI AERIO SX. THE CONTACT STATED THAT THE DOOR HANDLE BROKE WHILE ATTEMPTING TO OPEN IT. THE DEALER AND MANUFACTURER WERE NOTIFIED OF THE DEFECT. THE DOOR HANDLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 10,586 AND THE CURRENT MILEAGE WAS 11,000.

I HAVE HAD PROBLEMS WITH MY CAR FOR ALMOST 2 MONTHS AND IT SEEMS IT NEVER ENDS. SERIOUS POWER STEERING PROBLEMS WHICH CAUSES A LOT OF INCONVENIENCES FOR A SINGLE MOTHER LIKE ME, TAKEN TO SOME SHOPS, MONEY WASTED ON NOTHING BECAUSE IT SEEMS THIS IS ONE OF THE WEAKEST AND WORST PROBLEMS A SUZUKI AERIO 2003 COULD HAVE. CHECKED ON THE INTERNET AND ALL OF THEM HAVE THE SAME PROBLEM ! *LN

THE REASON IS THAT I BOUGHT ONE USED GOOD YEAR TIRE BUT I JUST RUN ON HIGH WAY FOR FEW MILES ONLY IT WAS SERIOUSLY FLAT ON LAST SATURDAY (MAY 9, 2009). I DID NOT KNOW WHY AN INFERIOR TIRE WOULD BE SOLD IN THE STORE, WHEN I PURCHASED IT SEEMS VERY GOOD LIKE A NEW GOOD YEAR TIRE, AND I WAS NOTICED I NEED TO PAY FOR REPLACE IT. I NOTICED THE INSIDE OF THE TIRE SOMETHING WAS MELTED---A FLIMSY PIECE OF MATERIAL. COULD YOUR OFFICE INVESTIGATE THOSE PROBLEMS, BECAUSE IF THOSE TIRES WERE EQUIPPED TO THE FRONT OF THE CARS WOULD CAUSE SERIOUS PROBLEMS ON THE HIGH WAY?. COULD YOU INVESTIGATE WHY THEY HAVE/SELL THOSE INFERIOR TIRES? THE USED TIRE STORE INFORMATION: AFFORDABLE TIRE & WHEELS; 12099 BALLAIRE BLVD, HOUSTON, TX 77072. *TR WENLUO ZHANG