2001 SUBARU OUTBACK Fuel System Gasoline Problems

2001 SUBARU OUTBACK LIMITED. WHEN COLD WEATHER ARRIVES, VERY STRONG SMELL OF GASOLINE IN THE PASSENGER COMPARTMENT. MUST OPEN WINDOWS TO LET IT VENT. CONTINUES THROUGH COLD WEATHER YEAR AFTER YEAR. *TR

CAR SMELLS LIKE FUEL WHEN IDLING ON A COLD DAY. RUBBER FUEL LINES AND FUEL FILTER WERE LOOSE AND AFTER TIGHTENING THEM FUEL SMELL TEMPORARILY STOPPED. SMELL HAS RETURNED AND AFTER CALLING SUBARU DEALERSHIP THEY ACKNOWLEDGED THE ISSUE WAS RELATED TO RUBBER FUEL LINES THAT NEEDED REPLACING. THIS IS A COMMON PROBLEM WITH SUBARU'S AND NEEDS TO BE ADDRESSED BY SUBARU. DEALERSHIP IS ASKING OVER $300 TO REPLACE FOUR RUBBER FUEL LINES LOCATED UNDER THE MANIFOLD AND THIS IS AT LEAST EVERY YEAR IT HAS TO BE DONE THAT'S SOUNDS LIKE A RECALL ISSUE TO ME I TIGTHEN THE SCREWS A FEW TIME AND SOMEHOW WHEN IT'S COLD WEATHER IT TEND TO GET LOOSE AND VAPOR COMES OUT VERY DANGEROUS I CHECK THIS ISSUE ONLINE USING GOOGLE SEARCH AND NOTICE THIS IS A KNOWN ISSUES AND GOES BACK MANY YEARS THERE SHOULD BE A RECALL JUST LIKE THE 2002 IT...

I PURCHASED A 2001 SUBARU OUTBACK WHEN THE TEMPERATURE OUTSIDE IS BELOW FREEZING AROUND 28 DEGREES OR LOWER, THERE IS A STRONG ODOR OF GASOLINE INSIDE THE PASSENGER AREA. I MADE AN APPOINTMENT WITH A SUBARU DEALER FOR JANUARY 5TH, HOWEVER I RESEARCHED ONLINE AND FOUND THIS PROBLEM IS COMMON WITH NO CLEAR FIX. I DON'T WANT TO TAKE IT TO THE DEALER IF THIS PROBLEM ISN'T GOING TO BE FIXED. WHAT REMEDY HAS SUBARU OFFERED FOR THIS PROBLEM? *KB

2001 SUBARU LEGACY OUTBACK. FUEL VAPOR SMELL IN CABIN WHEN TEMPERATURES FALL BELOW FREEZING. THIS HAS BEEN A PERSISTENT PROBLEM FOR THE THREE WINTERS WE HAVE OWNED THE CAR. THIS FALL I FOUND SEVERAL COMMENTS ONLINE WHICH PROMPTED ME TO TIGHTEN THE HOSE CLAMPS ON FUEL LINES RUNNING TO/FROM THE ENGINE COMPARTMENT FUEL FILTER. THIS SEEMED TO HELP UNTIL THE LAST 2-3 DAYS WHEN WE EXPERIENCED PROLONGED TEMPERATURES OF 0 TO -15F. NOW THE SMELL IS BACK AND THE LOCAL SUBARU DEALER SUGGESTS THE PROBLEM OFTEN INVOLVES FUEL HOSES BENEATH THE INTAKE MANIFOLD, WHICH THEY ESTIMATE $370 TO REPAIR. BASED ON NUMEROUS COMPLAINTS AND COMMENTS I HAVE FOUND ONLINE, SOME DATING BACK TO 2003, I AM SHOCKED THAT SUBARU HAS BEEN AWARE OF THIS PROBLEM FOR SO LONG AND FAILED TO ISSUE A RECALL. GASOLINE VAPOR IS A SIGNIFICANT HEALTH HAZARD. NOT ONLY IS IT A CARCINOGEN AND KNOWN TO...

I HAVE A 2001 SUBARU OUTBACK STATION WAGON. ON VERY COLD DAYS, THERE IS A STRONG SMELL OF FUEL THAT PERVADES THE PASSENGER CABIN. WE HAD TO DRIVE WITH WINDOWS OPEN EVEN WHEN 20-DEGREES OUTSIDE OR EXPOSE MY 3YR SON TO THE GAGGING FUMES. THIS PROBLEM IS A KNOWN ISSUE (THERE ARE LITERALLY 1000'S OF POSTS ON SUBARU OWNERS WEB BOARDS) BUT MY LOCAL MECHANIC WAS INITIALLY NOT ABLE TO FIND THE PROBLEM. SUBARU OF AMERICA HAS NOT ISSUED A TECHNICAL SERVICE BULLETIN TO MAKE OWNERS AWARE OF THIS COMMON FAILURE IN SUBARU FUEL LINES. ONCE WE FOUND EXPLANATORY MATERIAL ON THE WEB, WE HAD THE LOCAL MECHANIC REPLACE THE FUEL LINES FOR ABOUT $300. GIVEN HOW COMMON THE PROBLEM IS AND HOW POTENTIALLY DANGEROUS A FUEL LINE LEAK IN THE ENGINE COMPARTMENT COULD BE, THE NHTSA SHOULD FORCE SUBARU TO ADDRESS THIS PROBLEM. IN ADDITION TO THE IMMEDIATE DANGER,...

UNDERHOOD FUEL HOSES ARE ALLOWING LEAKAGE AT LOW TEMPERATURES. *TR

2001 SUBARU OUTBACK, 4 CYL. STRONG GAS SMELL WHEN OUTSIDE AIR/HEATER IS ON AND TEMPERATURE IS AROUND FREEZING OR BELOW. IT HAS HAPPENED LAST 3 YRS AND FUMES CAN BE AVOIDED BY CHANGING TO RECIRCULATING AIR. DEALER AND OTHER MECHANIC COULD NOT FIND PROBLEM. *TR

I OWN A 2001 SUBARU OUTBACK, THAT WHEN THE WEATHER GETS COLD, SOMEWHERE AT AND BELOW 30 DEGREES, I GET A GAS ODOR IN AND OUTSIDE THE CAR. I HAVE RESEARCHED THIS ON THE INTERNET AND FOUND THAT THIS IS AN *EXTREMELY* COMMON PROBLEM WITH THE CAR'S GAS LINES AND THAT SUBARU IS ONLY ACKNOWLEDGING THE ISSUE ON 2002 AND NEWER MODELS. HAVE YOU RESEARCHED THIS ISSUE BEFORE AND CAN YOU TELL ME WHY NO RECALL ON 2001S WAS EVER DONE? THANK YOU. *TR

TL*THE CONTACT OWNS A 2001 SUBARU OUTBACK. WHILED DRIVING APPROXIMATELY 50 MPH, THE CONTACT SMELLED AN ODOR INSIDE THE VEHICLE. ALL THE PASSENGERS COMPLAINED OF A HEADACHE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO REPAIRED A LEAKING FUSE HOSE. THE FAILURE OCCURRED AGAIN AND WAS NO LONGER DRIVABLE. THE VEHICLE HAD NOT BEEN REPAIRED AGAIN. THE FAILURE MILEAGE WAS APPROXIMATELY 113,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 120,000.

2001 SUBARU OUTBACK HAS STRONG GASOLINE SMELL INSIDE CABIN UPON STARTING ENGINE. OUTSIDE TEMPERATURE IS ABOVE 80- DEGREES...NOT COLD. SMELL DISSIPATES AS CAR RUNS AFTER ABOUT 3 MINUTES. *TR

CAR IS A SUBARU OUTBACK 2001. COMPLAINT IS STRONG FUEL SMELL AND VAPORS IN THE CAR CABIN WHEN OUTSIDE AIR TEMPERATURE FALLS BELOW 30 DEGREES OR SO. SMELL PERMEATES OUR CLOTHING TO THE EXTENT THAT WHEN WE LEAVE THE CAR AND ENCOUNTER PEOPLE, THEY COMMENT THAT WE SMELL LIKE GASOLINE. FUEL LINES HAVE BEEN CHECKED AS HAVE CLAMPS AND HOSES. NO RESOLUTION. WE MUST DRIVE BREATHING STRONG FUMES. OPENING WINDOWS DISSIPATES FUMES SOMEWHAT, BUT NOT COMPLETELY. PROBLEM IS WORSE WITH HEATER RUNNING, SO WE TURN IT OFF. ADDITIONAL CONCERN IS THAT WHEN DRIVING WITHOUT HEAT, THE FRONT WINDSHIELD DEFROSTER IS NOT OPERATIONAL, RESULTING IN THE WINDSHIELD BEING ICED OVER AND/OR COVERED WITH CONDENSATION. THIS CAUSES VISUAL IMPAIRMENT AND IS A DRIVING HAZARD. *TR

I OWN A 2001 SUBARU OUTBACK THAT WHEN THE WEATHER GETS COLD, SOMEWHERE AT AND BELOW 30 DEGREES, I GET A GAS SMELL IN AND OUTSIDE THE CAR. I HAVE RESEARCHED THIS ON THE INTERNET AND FIND THIS IS A COMMON PROBLEM WITH THE CAR'S GAS LINES AND THAT SUBARU IS ONLY ACKNOWLEDGING THE ISSUE ON 2002 AND NEWER MODELS. HAVE YOU RESEARCHED THIS ISSUE BEFORE AND CAN YOU TELL ME WHY NO RECALL ON 2001S WAS EVER DONE? THANK YOU. *TR

WE STRONGLY AGREE WITH THE COMPLAINT FILED 12/9/09 LISTED BELOW. WE ALSO HAVE A 2001 SUBARU OUTBACK AND HAVE HAD THE SUBARU DEALERSHIP CHECK OUT THIS PROBLEM SEVERAL TIMES. WE HAVE HAD FUEL HOSES REPLACED AND CLAMPS TIGHTENED AND REPLACED MANY TIMES AND THE PROBLEM REMAINS. OBVIOUSLY THE PROBLEM IS ELSEWHERE IN THE FUEL SYSTEM. WHILE EVERY WINTER FOR AT LEAST THE LAST 5-6 WINTER SEASONS OUR FAMILY SMELLS AND BREATHES IN GASOLINE FUMES AND HAVE TO OPEN WINDOWS TO AIR OUT THE CABIN FROM THE STRONG GASOLINE SMELL. WE ALSO REFRAIN FROM USING THE HEATING SYSTEM AT TIMES BECAUSE THE SMELL IS MUCH MORE NOTICEABLE WHEN WE RUN THE HEATER. WE HAVE ALSO FOUND COUNTLESS COMPLAINTS ONLINE REGARDING THIS SUBARU ISSUE. DOES A FIRE, DAMAGE, CRASH, INJURY OR DEATH HAVE TO OCCUR BEFORE SUBARU OR THE NHTSA WILL ADDRESS THIS PROBLEM? COMPONENT: FUEL SYSTEM, GASOLINE DETAILS: IN COLD WEATHER,...

IN COLD WEATHER, MY 2001 SUBARU OUTBACK HAS AN EXTREMELY STRONG SMELL OF GASOLINE. A QUICK SEARCH WILL REVEAL HUNDREDS OF COMPLAINTS ON THE SAME ISSUE. THERE HAS BEEN A TECHNICAL SERVICE BULLETIN ISSUED BY SUBARU ON THIS ISSUE--NHTSA ITEM # 616334, SERVICE BULLETIN # 010101. THE TSB RECOMMENDS AN "INSPECTION PROCEDURE FOR POSSIBLE REPLACEMENT OF 3 FUEL HOSES". HOWEVER, THE SUBARU DEALER INDICATES THE ISSUE CALLS FOR A REPLACEMENT OF THE ENTIRE FUEL RAIL--COSTING MORE THAN $400. I CANNOT BELIEVE THAT NEITHER THE NHTSA NOR SUBARU HAVE NOT CATEGORIZED A SYSTEMIC PROBLEM WITH LEAKING GASOLINE AS A SAFETY ISSUE. *TR

IN COLD WEATHER VERY STRONG FUEL ODOR IN PASSENGER COMPARTMENT. SMELL IS STRONG ENOUGH TO MAKE PASSENGERS FEEL ILL. THIS HAPPENS ALL THE TIME WHEN OUTSIDE TEMP GOES BELOW FREEZING. *TR

THERE IS FREQUENTLY A STRONG SMELL OF FUEL WITHIN THE VEHICLE COMPARTMENT WHEN THE CAR IS RUNNING, EITHER STANDING STILL OR OTHERWISE BEING DRIVEN. THERE WAS A THIRD PARTY SERVICE BULLETIN ISSUED (WXZ-83-FUEL HOSE EXPLAINING THE PROBLEM WHICH IS THAT CERTAIN AFFECTED VEHICLES MAY HAVE BEEN PRODUCED WITH UP TO 3 IMPROPERLY MANUFACTURED FUEL HOSES IN THE ENGINE COMPARTMENT. OVER TIME AND IN COLD WEATHER THE HOSES COULD LEAK CREATING THE POTENTIAL FOR A FIRE IN THE ENGINE COMPARTMENT. I FOUND OUT WHAT THE PROBLEM WAS ON THE INTERNET. SUBARU SAYS THERE WAS A RECALL FOR THIS BUT THAT MY VEHICLE WAS NOT ONE OF THE VEHICLES UNDER THE RECALL AND THAT I WOULD HAVE TO PAY FOR ANY REPAIRS - THEY SAID IT COULD BE THE FUEL RAIL ASSEMBLY THAT IS THE PROBLEM. THIS DOES NOT SEEM FAIR OR RIGHT. IF ITS A DEFECT (WITH SERIOUS SAFETY IMPLICATIONS) AND...

IN COLD WEATHER OUR CAR BEGAN EMITTING A VERY STRONG FUEL SMELL IN THE PASSENGER COMPARTMENT. OUR SUBARU DEALER DENIES THERE IS ANYTHING WRONG THAT WOULD WARRANT A SAFETY RECALL OR BULLETIN. THEY WILL NOT ACCEPT IT IS A DESIGN DEFECT WHEN CLEARLY THE FUEL LINES BEGIN TO LEAK IN COLD (SUB-FREEZING) TEMPERATURES. AS GASOLINE IS A SERIOUS CARCINOGEN AND EXPOSURE TO ITS FUMES CAUSES BRAIN DAMAGE, THIS SHOULD BE REGARDED AS AN EXTREMELY SERIOUS HEALTH ISSUE. *TR

1) UPON COLDER WEATHER STARTING AND DURING THE FIRST 30-40 MINUTES OF OPERATION OUR 2001 SUBARU OUTBACK GETS FUEL VAPORS IN THE PASSENGER COMPARTMENT. 2) FUEL SMELLS CAUSE USE TO ROLL WINDOWS DOWN TO KEEP BREATHABLE AIR AVAILABLE. FUEL VAPOR IS A CARCINOGEN, OF COURSE. OCCUPANTS COMPLAINED OF NAUSEA AND HEADACHES. 3) TOOK CAR TO PAUL BROS. SUBARU AND THEY TOLD US THIS WAS A COMMON COMPLAINT BUT NOTHING TO WORRY ABOUT. 4) SUBSEQUENTLY, LEARNED OF HUNDREDS OF LIKE COMPLAINTS AND A SUBARU SERVICE BULLETIN REGARDING LEAKY HOSES DUE TO LOOSE FUEL CLAMPS AND POOLING FUEL ON CREVICES ON THE ENGINE BLOCK. CONSIDERED NOT A "ENGINE/DRIVETRAIN ISSUE IN WARRANTY AND COST TO REPLACE HOSES HAS BEEN CHARGED TO OWNERS AT MORE THAN $600. PERSONS "INJURED" IS HARD TO DETERMINE DUE TO CHRONIC EXPOSURE OF FUMES IS AN UNCLEAR CONNECTION TO A SINGULAR INJURY. THIS SITUATION SHOULD BE ADDRESSED BY A...

STRONG SMELL OF FUEL IN PASSENGER COMPARTMENT DURING EXTREMELY COLD WEATHER. *NM