1998 SUBARU LEGACY Engine And Engine Coolingenginegasoline Problems

WHILE DRIVING A TAPPING NOISE IS COMING FROM ENGINE. CONTACTED DEALER, AND DEALER CANNOT FIND CAUSE OF PROBLEM. *AK

ENGINE WAS DIED.

THE FR0NT MAIN SEAL FAILED REPAETEDLY (3 TIMES) RESULTING IN LEAKAGE. NLM

COMMENTS FROM THE DEALERS INVOICE: 671 MILES: CHECKED FOR OIL LEAK, FOUND FLUID LEAKING FROM POWER STEERING RACK. REMOVED AND REINSTALLED RACK ASSEMBLY.671 MILES: I COMPLAINED ABOUT SMELL IN VENTS. ADVISED IT WAS POWER STEERING FLUID LEAKING ONTO EXHAUST. 944MILES: OIL LEAKING FROM ENGINE DOWN ONTO EXHAUST. FOUND LEAK AT TOP OF ENGINE ON THE RIGHT SIDE NEAR REAR OIL GALLEY PLUG. DISASSEMBLE ENGINE COMPLETE DOWN TO SHORT BLOCK. REPLACE SHORT BLOCK AND ALL NECESSARY GASKETS AND SEALS. REASSEMBLE ENGINE. 944 MILES: I COMPLAINED ABOUT SMELL IN VENTS. THIS TIME TOLD IT WAS BURNING OIL GETTING INTO VENTS BEFORE ENGINE REPAIR.6195 MILES,03/27/98: COMPLAINED ABOUT SMELL IN VENTS. DASH ASSEMBLY DISASSEMBLED, CLEANED, REASSEMBLED. 7173 MILES: COMPLAINED ABOUT SMELL IN VENTS. WORKING WITH ZEXEL REP. ON A/C SYSTEM LOCATED LEAK AT EVAPORATOR COOLING UNIT. REMOVE AND REPLACE RECEIVER DRIER AND A/C COMPRESSOR. REASSEMBLE. 8009 MILES: I COMPLAINED THAT THE CHECK ENGINE LIGHT...

ENGINE PISTON NOISE CONTINUAL, CONSUMER HAS TAKEN VEHICLE IN TO DEALERSHIP ON SEVERAL OCCASSIONS, DEALERSHIP AND MANFACTURER STATE THAT THE ENGINE NOISE IS DUE TO THE NEW EFFICIENT DESIGN OF THE ENGINE. *JB

THE OBD SYSTEM INDICATES CHECK ENGINE. THE ENGINE LOOSES POWER AND THE CARS ACCELERATION BECOMES VERY WEAK. THE CAR IS TURNED OFF AND RESTARTED AND THE ENGINE WILL EITHER CONTINUE TO MALFUNCTION OR WILL RUN NORMALLY. THE DEALER REPLACED THE IDLE SPEED CONTROL ($600) BUT THE PROBLEM CONTINUES TO OCCUR. NOW SUBARU SAYS THAT THEY CANNOT FIND ANY MALFUNCTION. WHEN THE ENGINE MALFUNCTIONS WITHOUT WARNING IT IS DANGEROUS TO DRIVE THE CAR WHEN ACCELERATING ONTO A HIGHWAY OR IN HEAVY TRAFFIC. I CANNOT TRUST THIS CAR TO GET ME SAFELY TO MY DESTINATION.

THE CAR DEVELOPED A LEAK AT THE OIL FILTER (LEE MAXI FILTER) WHERE IT MEETS THE ENGINE. THE LEAK STARTED SMALL AND GREW STEADILY LARGER (10 EXTRA QUARTS OF OIL WERE NEEDED TO GO THE LAST 50 MILES). THIS OCCURRED TOWARD THE END OF MY TRIP, AFTER TRAVELING ABOUT 140 MILES. I KNOW THAT THERE HAD BEEN A RECALL PREVIOUSLY ON THE SUBARU BRAND FILTER (1998) FOR THIS VERY SAME PROBLEM AT THE END OF LAST YEAR, BUT I HAD THIS PROBLEM WITH A LEE BRAND FILTER, WHICH I HAD BUT ON 2100 MILES EARLIER. UP UNTIL THIS TIME, NO LOSS OF OIL HAD OCCURRED WITH THIS FILTER OR WITH PREVIOUS OIL CHANGES (I HAD JUST CHECKED THE OIL LEVEL A FEW DAYS EARLIER). I BELIEVE THAT THERE MAY BE A LARGER PROBLEM HERE, OTHER THAN THE SUBARU BRAND FILTER FROM THE RECALL. YOU SHOULD ALSO KNOW THAT THERE IS...

SUNROOF DRAINLINES WERE REPAIRED TWICE, DUE TO LEAKAGE, DEALER BELIEVES THAT THE WINDSHIELD INSTALLER CAUSED THEM TO BE DISCONNECTED. CV JOINT LEAKING DUE TO FREEZE PLUG IN THE CV JOINTS, REPLACE BUT LEAKS WORSE. INSTALLED A BATTERY HOLD DOWN, TOP DEFROSTER LINE REPAIRED TWICE, SMELL OF BURNING OIL.