1998 SUBARU IMPREZA Engine And Engine Coolingengine Problems

98 SUBARU IMPREZA 2.5RS. I HAD THE HEAD GASKETS REPLACED UNDER WARRANTY THE FIRST TIME . AROUND A YEAR AFTER THAT,THE CAR OVER HEATED AGAIN. I HAD IT TOWED TO A AUTO REPAIR SHOP THAT I WORKED AT AND HAD THEM TEST THE CAR TO SEE THE PROBLEM. IT WAS A BLOWN HEAD GASKET AGAIN. THEY DETERMINED THIS BY TESTING FOR ANY EMISSIONS IN THE COOLANT. THERE WAS ALSO A LARGE AMOUNT OF SLUDGE BUILD UP IN THE COOLANT RESERVOIR(OIL)AS WELL. SUBARU WOULD NOT WARRANTY THERE ORIGINAL WORK SO THE CAR SAT FOR A BIT BEFORE I COULD AFFORD TO HAVE IT FIXED. WHEN I SAVED UP SOME MONEY FOR THE REPAIR, I BROUGHT IT TO THE SUBARU DEALER TO HAVE THEM DO THE WORK ON IT. I WAS EXTREMELY UPSET WITH THE WORK THEY DID BUT GOT THE CAR BACK WITH A FUNCTIONAL ENGINE. NOT MORE THAN A YEAR...

HEAD GASKET FAILURE ENGINE OVERHEATED ON 16 HOUR TRIP.. TOOK TO SUBARU DEALERSHIP, THEY PUT IN A NEW "STARTER BOLT" STATED IT WAS A BAD GROUND?? ON RETURN HOME CAR OVER HEATED AGAIN.. WAS REPAIRED BY SUBARU, TECH SAID IT WAS COMMON. 2ND HEAD GASKET FAILURE, TWO MONTHS LATER, OIL IN ANTIFREEZE... DRIVING 55-65 MPH FOR 10 MIN IN 75-80F WEATHER, NOT UNDER HARD ACCELERATION. FEAR THAT IT WILL HAPPEN AGAIN. CURRENT RECALL ON 99-01 MODELS FOR "COOLANT ADDITIVE". POOR HEAD GASKET DESIGN IS LEADING TO FAILURE... SEEMS TO BE COMMON PROBLEM ON 98'S (2.5RS DOHC EJ25 PHASE 1) *JB

THE ENGINE KEPT OVERHEATING AND AIR WOULD APPEAR IN THE RADIATOR. ANTIFREEZE WOULD BE PUSHED OUT OF RADIATOR AND THE HEATER WOULD BLOW COLD AIR. THE CAR HAD TO BE SHUT OFF REPEATEDLY AND ALLOWED TO COOL DOWN AND THE ANTIFREEZE REPLACED. A CHECK OF THE COOLING SYSTEM DETECTED NO LEAKS. WE WERE TOOK THE CAR TO A NUMBER OF GARAGES UNTIL FINALLY ONE GARAGE TOLD US THAT THE ENGINE BLOCK WAS MOST LIKELY CRACKED AND THE ENGINE NEEDED TO BE REPLACED AT A COST OF $3600. ACCORDING TO THE GARAGE, THEY HAVE REPLACED A NUMBER OF ENGINES FOR THIS PARTICULAR MODEL, SPECIFICALLY ONE WITH THE DOHC.*AK

1998 SUBARU IMPREZA 53,000 MILES AND THE AUTO TECH AT SUBARU SAYS I HAVE A PISTON SLAP, $2500.00 TO PULL ENGINE AND CHECK THIS OUT. I HAVE CHANGED OIL EVERY 3,000 MILES BROUGHT IT IN FOR THE 30,000 MILEAGE OVER ALL CHECK UP - WHAT IS UP WITH THIS MOTOR? *JB

ENGINE STALLS WHEN TRYING TO TAKE OFF AFTER STOPPING AT TRAFFIC LIGHT. THERE IS ALSO A RAPPING NOISE IN ENGINE UNTIL ITS BEEN RUNNING AWHILE. *JB

THE FLYWHEEL IS INOPERATIVE.*JB

CONSUMER HAD TAKEN VEHICLE TO DEALER DUE TO A STRONG FUEL SMELL AND BURNING OIL COMING FROM ENGINE. DEALER REPLACED TRANSMISSION TRANSFER CASE/ REPAIRED AN OIL LEAK, AND REPLACED PISTON GASKETS.SOMETIMES CONSUMER HAD TRIED TO START ENGINE, BUT IT WOULD NOT HAPPEN AT ALL. PLEASE PROVIDE MORE INFORMATION. *AK