2005 SUBARU BAJA Fuelpropulsion System Problems

THE VEHICLE IS LEAKING FUEL. WHEN TANK IS FULL THE PRESENCE OF THE FUMES ARE OVERWHELMING. OTHER 2005 BAJA'S HAVE BEEN REPAIRED UNDER A RECALL, BUT MINE HAS NOT BEEN FIXED. I CAN'T PARK IN A GARAGE DUE TO LIFE THREATENING REASONS AND IT COULD IGNITE RIGHT NOW. PLEASE HELP ME.

FUEL SMELL WHEN STARTING VEHICLE FOR SEVERAL MONTHS REPORTED TO DEALERSHIP AND SERVICE REFUSED TO DO CHECK FOR CAUSE, THOUGH THEY WERE PAID TO.

IT IS A COMMONLY KNOWN PROBLEM WITH SUBARUS OF THIS ERA THAT THE HIGH PRESSURE RUBBER FUEL LINES UNDERNEATH THE INTAKE MANIFOLD WILL BEGIN TO LOSE THEIR ELASTICITY AS THEY AGE AND LEAK PROFUSELY WHEN THE TEMPERATURE DROPS BELOW 30 DEGREES FAHRENHEIT. MECHANICS KNOW THIS AND IT IS DISCUSSED EXTENSIVELY ON THE SUBARU FORUMS. THIS HAPPENED TO MY 2005 SUBARU BAJA WHEN I WAS TRAVELING IN THE MOUNTAINS. WHEN I STARTED THE VEHICLE IN THE MORNING, FUEL WOULD BEGIN PUDDLING ON THE TOP OF THE ENGINE. IT WAS VERY NOTICEABLE DUE TO THE FUEL VAPORS PRODUCED. AS THE ENGINE WARMED THE RUBBER WOULD SWELL AND STOP THE LEAK AFTER A GOOD 30 MINUTES OR LONGER DEPENDING ON THE OUTSIDE TEMPERATURE. I HAD TO TRAVEL WITH A FIRE EXTINGUISHER AT THE READY AND COULD NOT KEEP ANY VENTS OPEN IN THE CABIN. IT WAS EXTREMELY DANGEROUS AND COULD NOT BE REMEDIED...

TL* THE CONTACT OWNS A 2005 SUBARU BAJA. AFTER STARTING THE VEHICLE, A STRONG FUEL ODOR ENTERED THE VEHICLE. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE FAILURE WAS UNDETERMINED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09277000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

STRONG GASOLINE SMELL IN PASSENGER COMPARTMENT, DEALER CAN NOT LOCATE PROBLEM,PROBLEM PERSISTS. AFRAID CAR WILL CATCH ON FIRE

IT'S BEEN COLD IN MA LIKE PAST WINTERS AND THIS IS THE FIRST TIME THIS HAPPENED SINCE OWNING MY BAJA FOR 10 YEARS NOW, WHICH I BOUGHT NEW. I NOTICED THAT WHEN I FIRST START UP MY CAR WITH THE HEAT VENTS OPEN TO WARM IT INSIDE, THE CAR FILLS WITH STRONG FUEL/GAS FUMES. I TOOK MY CAR TO BE SERVICED AT A SUBARU DEALER AND THEY CHECKED ALL THE FUEL LINES; TIGHTENED THEM, BUT COULD NOT FIND WHAT IS CAUSING THIS PROBLEM. SO NOW I RECIRCULATE THE CABIN AIR AND DON'T DRAW IN FRESH AIR TO TRY TO KEEP THE FUMES OUT. IT STILL CONTINUES TO EMIT FUMES WHEN IT'S COLD OUT, BUT IT NEVER HAPPENED IN THE PAST...10 YEARS OF COLD WINTERS AND NOW THERE'S A PROBLEM WITH GAS FUMES? SOMETHING IS VERY WRONG AND I DO FEAR A FIRE. *TR