2004 SAAB 9-5 Electrical System Problems

I purchased my 2004 Saab 9-5 in 2023. I was under the impression that everything was running and that drivability was proper. When I attempted to drive the automobile it would start, idle 7 minutes and stall. It would not start again for about 35 minutes. I tried to use it, and this behavior continued. Often, in traffic it would stall while I was moving at low speed, and moderate speed: Without warning, it cuts out and won't start for 40 minutes. I have spent money with my mechanic, over $1,000. I personally bought many parts: MAF sensor, fuel pump relay, fuel filter, and fuel pump. I replaced the Coolant Sensor. After all this the vehicle still stalls 5 minutes after warmup. If it drives to warm up, it stalls and won't restart for 40 minutes. After I replaced the Crankshaft Position Sensor, (CPS), it has never restarted. I bought...

I HAVE OWNED A 2004 SAAB 9-5 SPORT COMBI WAGON SINCE 2006. TWICE, OVER THE LAST SEVERAL YEARS (2011, 2014), MY HUSBAND AND I HAVE BEEN ON THE HIGHWAY AND HAD AN IGNITION SWITCH INCIDENT WHERE HE WAS THE DRIVER AND I WAS THE PASSENGER. IN BOTH INCIDENTS, I TURNED AROUND TO TALK TO MY DAUGHTER (2011) AND THEN DAUGHTERS (2014) AND INADVERTENTLY BUMPED THE KEY IN THE IGNITION WITH MY KNEE. THE IGNITION SWITCH IS LOCATED IN THE CENTER OF THE CAR BY THE CONSOLE. IT ONLY TOOK A SLIGHT TAP OF MY KNEE AND MY CAR SHUT OFF WHILE GOING AT SPEEDS OF 75-80 MPH ON THE HIGHWAY. FORTUNATELY, BOTH TIMES MY HUSBAND WAS ABLE TO PUT THE CAR INTO NEUTRAL AND GET THE CAR OFF TO THE SIDE OF THE ROAD. *TR

TL* THE CONTACT OWNS A 2004 SABB 9-5. THE CONTACT STATED THAT WHILE DRIVING 75 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AND TOOK IT TO THE DEALER FOR INSPECTION OF THE FAILURE WHERE THE TECHNICIAN REPLACED THE IGNITION MODULE. THE CONTACT WAS MADE AWARE OF A MANUFACTURER'S RECALL FOR THE IGNITION SWITCH BUT WAS ADVISED THAT THE VEHICLE WAS NOT INCLUDED. THE MANUFACTURER WAS CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 64,000. UPDATED 10/23/2014*LJ THE CONSUMER STATED THE CHECK ENGINE AND NO AUTOMATIC WARNING LIGHTS WOULD ILLUMINATE ON FREQUENTLY. UPDATED 8/10/2015*JS

TL* THE CONTACT OWNS A 2004 SAAB 9-5. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS FOUND THAT THE CRANK SHAFT POSITION SENSOR, FUEL PUMP, AND THE TWICE UNIT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 51,108.

TL* THE CONTACT OWNS 2004 SAAB 9-5. THE CONTACT STATED THAT SHE WAS TRAVELING 55 MPH WITH HER PURSE ON THE PASSENGER'S SIDE SEAT. THE CONTACT PROCEEDED TO EXIT THE HIGHWAY WHEN THE WATER BOTTLE THAT WAS IN HER PURSE TOPPLED OVER AND STRUCK THE IGNITION SWITCH, CAUSING THE VEHICLE TO STALL. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION OR REPAIRS. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 95,000. *TR

TL* THE CONTACT OWNS A 2004 SAAB 9-5. THE CONTACT STATED THAT WHEN DRIVING ON THE HIGHWAY, THE VEHICLE WOULD SUDDENLY SHUT DOWN COMPLETELY. THE ENGINE AND ELECTRICAL SYSTEMS WOULD TURN OFF COMPLETELY. THE FAILURE OCCURRED SEVERAL TIMES. THE VEHICLE WAS ABLE TO BE IMMEDIATELY RESTARTED WHEN THE FAILURE OCCURRED. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC WHO STATED THAT THE IGNITION SWITCH WAS MOST LIKELY THE CAUSE FOR FAILURE. THE VEHICLE HAD NOT BEEN REPAIRED. THE CONTACT CALLED THE MANUFACTURER WHO OFFERED NO ASSISTANCE. THE CURRENT MILEAGE WAS APPROXIMATELY 74,00. THE FAILURE MILEAGE WAS APPROXIMATELY 60,000. UPDATED 12/30/10 *BF UPDATED 01/10/11*JB UPDATED 3/31/14*CN

PURCHASED THE CAR USED 5/23/08 WITH 42,700 MILES FROM SAAB DEALERSHIP. WITHIN A MONTH THE HEADLIGHTS WORKED RANDOMLY, CHECK ENGINE LIGHT WOULD COME ON RANDOMLY. CALLED THE DEALERSHIP AND WAS TOLD THAT IT WOULDN'T HURT ANYTHING AND SHOULD IT BECOME MORE FREQUENT, BRING THE CAR IN. 8/18 TOOK THE CAR IN TO DEALERSHIP WHEN THE LIGHT WAS COMING ON MORE FREQUENTLY. HEADLIGHT RELAY REPLACED, ENGINE LIGHT WAS DUE TO A DIRECT IGNITION CASSETTE FAILURE. SAAB DEALERSHIP ORDERED THE PART WHICH WAS ON NATIONAL BACK ORDER, PART CAME IN 10/9. VEHICLE WAS TAKEN IN 10/6 DUE TO STEAM COMING FROM UNDER THE HOOD, TEMPERATURE GAUGE NEVER MOVED ABOVE THE MIDDLE. BYPASS VALVE REPLACED ($450 PARTS/LABOR). VEHICLE HAS APPROX. 48,500 MILES AND IS OUT OF MANUFACTURER WARRANTY AND REPAIR IS NOT COVERED UNDER DEALERSHIPS LIMITED WARRANTY. AFTER AN INTERNET SEARCH FOR INFORMATION RELATING TO THE DI CASSETTE FAILURE I FOUND THAT THERE...

MY WIFE WAS DRIVING OUR 2004 SAAB 9-5 WAGON AT OR AROUND 35 MPH WHEN THE CAR, SUDDENLY AND WITHOUT WARNING, LOST ITS ELECTRICAL POWER. SHE WAS UNABLE TO STEER, BRAKE OR CONTROL THE VEHICLE IN ANYWAY. ALL OF THE LIGHTS WERE ILLUMINATED ON THE DRIVER'S PANEL. LUCKILY, THERE WAS NO ON-COMING TRAFFIC OR ANY VEHICLE FOLLOWING BEHIND HER BECAUSE SHE WAS APPROACHING A CURVE IN THE ROAD AT THE TIME THE CAR FAILED. SHE COASTED STRAIGHT AHEAD, THROUGH THE CURVE, TO A STOP. SHE TURNED THE CAR OFF, THEN RESTARTED THE CAR. WE CALLED THE DEALERSHIP THE NEXT DAY, AND RETURNED THE CAR A COUPLE OF DAYS LATER. WE NOTIFIED SAAB USA THAT WE NO LONGER FELT SAFE IN OUR VEHICLE AND HAVE LOST FAITH IN THE LINE AS A WHOLE. THIS INCIDENT WAS NOT THE FIRST ONE. WE EXPERIENCED THIS SAME ELECTRICAL POWER LOSS TWICE PREVIOUSLY IN OUR...