2000 SAAB 9-5 — Problems, Recalls & Safety Data

COMPLAINT ABOUT AUTOMOBILE PAINT.I PURCHASED CAR RECENTLY AND THE HOOD AND TOP ON CAR IS FLAKY AND FADED.THE COLOR DESCRIPTION IS GRAY.I AM WONDERING IF THIS IS A PROBLEM WITH CARS THAT WERE MADE IN THE YEAR 2000.THE HOOD AND TOP WOULD HAVE TO BE PAINTED.IT DOESN'T LOOK LIKE TREE SAP OR ANY FOREIGN SUBSTANCE AFFECTED THE PAINT.IT LOOKS LIKE THE PAINT JUST BROKE DOWN.

DRIVING SLOWLY IN HEAVY TRAFFIC, I NOTICED A LOSS OF POWER WHEN I ATTEMPTED TO MERGE WITH FREEWAY TRAFFIC. THE GAS GAUGE NEEDLE WAS DROPPING QUICKER THAN NORMAL, AND THE GASOLINE FUMES BECAME APPARENT AFTER CRACKING A WINDOW. THE ENGINE STALLED FOR THE THIRD AND LAST TIME AS I EXITED THE FREEWAY. UPON INSPECTION, I COULD SEE THAT THE FUEL 'LINE OUT' FROM THE PUMP UNDER THE BACK SEAT HAD COME OUT, FORCING FUEL OUT ONTO THE ROAD, JUST IN FRONT OF MY RIGHT REAR WHEEL. I WAS ABLE TO PUSH IT BACK IN AS THE RETAINING CLIP WAS NOT BROKEN. WITH AIR IN THE LINE, IT TOOK A WHILE TO START UP AND GET TO A NEARBY GAS STATION. DOUBLE ZIP-TIES WHEN I GOT HOME. CALLED MY SAAB GUY WHO SAID THERE HAD BEEN A RECALL, AND I NEED TO GET THEIR LATE FIX BRACKET. IT WILL NEVER COME OUT AGAIN OF ITS OWN ACCORD, AND I'M THANKFUL THAT I DIDN'T HAVE TO GET IT TOWED - THIS TIME.

DRIVING IN HEAVY TRAFFIC AFTER LEAVING WORK, I NOTICED NO LOSS OF POWER UNTIL I ATTEMPTED TO MERGE WITH FREEWAY TRAFFIC. SOON ENOUGH, THOUGH I DID NOTICE THAT THE GAS GAUGE NEEDLE WAS DROPPING QUICKER THAN NORMAL, AND THE GASOLINE FUMES BECAME APPARENT AFTER CRACKING THE WINDOWS. THE ENGINE STALLED FOR THE THIRD AND LAST TIME JUST AS I ESCAPED OFF THE FREEWAY. UPON INSPECTION, I COULD SEE THAT THE FUEL LINE OUT FROM THE PUMP UNDER THE BACK SEAT HAD COME OUT, FORCING ALL (OF THAT OH-SO-PRECIOUS) FUEL OUT ONTO THE ROAD, JUST IN FRONT OF MY RIGHT REAR WHEEL. I PUSHED IT BACK IN (FUEL TANK 'ROADS?), AS THE RETAINING CLIP WAS NOT BROKEN. NOW WITH SOME AIR IN THE LINE, IT TOOK A WHILE TO SUCK ENOUGH FUMES TO START UP AND GET TO A NEARBY GAS STATION. SMOOTH AS SILK AFTER A DOSE OF FUEL. DOUBLE ZIP-TIES WHEN I GOT HOME. CALLED MY SAAB GUY WHO SAID THERE HAD BEEN A RECALL, AND I NEED TO GET THEIR 'AFTER FIX' BRACKET. IT WILL NEVER COME OUT AGAIN, AND I'M GRATEFUL I DIDN'T HAVE TO GET TOWED THIS TIME.

DIRECT IGNITION CASSETTE FAILURE...THIS CAUSES THE CAR TO SPUTTER LIKE THE ENGINE IS GOING TO DIE AND BURNS THE ELECTRICAL INSIDE OF THE DIRECT IGNITION CASSETTE. WE HAD THE CAR HOOKED UP TO THE MACHINE AND TESTED AND GOT A MISFIRE CODE (P0325) AND ONCE THE CHECK ENGINE WAS CLEARED IT WORKED AGAIN FOR A FEW MINUTES. THE CAR WILL THEN STOP OPERATING, THE ENGINE STAYS RUNNING BUT WHEN YOU TRY TO ACCELERATE THE CAR DOES NOT MOVE, GOES INTO LIMP MODE. THIS HAPPENED TO ME ON THE FREEWAY THIS MORNING AND THANKFULLY I COULD COAST TO THE SIDE OF THE ROAD. SAABSERVICES.COM SHOWS THAT A RECALL WAS ISSUED ON THIS MAKE AND MODEL BUT THE SERIAL NUMBERS ON MINE FALL OUT OF THE RANGE OF THE SERIAL NUMBERS THE RECALL COVERS. *TR

TL*THE CONTACT OWNS A 2000 SAAB 9-5. THE CONTACT WAS DRIVING APPROXIMATELY 30 MPH WHEN THE TEMPERATURE GAUGE INDICATED THAT THE VEHICLE WAS OVERHEATING. THE VEHICLE WAS SAFELY DRIVEN TO THE SIDE OF THE ROAD AND THE ENGINE WAS SHUT OFF. AFTER WAITING FOR THE ENGINE TO COOL, THE CONTACT DISPENSED OIL INTO THE RESERVOIR. THE VEHICLE RESUMED AND THE TEMPERATURE GAUGE INCREASED RAPIDLY TO THE HOT LEVEL READING. THE ENGINE BEGAN TO OVERHEAT AND THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THERE WAS A RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 05V399000 (ELECTRICAL SYSTEM: IGNITION: MODULE) HOWEVER, THE DEALER ADVISED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN THE RECALL CAMPAIGN. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 134,000.