2025 RIVIAN R1S Exterior Lighting Problems

I am submitting this complaint regarding repeated ineffective repair attempts by Rivian Automotive, Inc. at its Costa Mesa Service Center on my 2025 Rivian R1S Adventure. During multiple service visits at Rivian’s Costa Mesa Service Center (January 29, June 18, July 16, and October 11, 2025), Rivian repeatedly failed to diagnose or correct the same issues affecting my 2025 Rivian R1S Adventure. • Drive Cam / Diagnostics Error: Rivian’s diagnostics incorrectly reported my drive storage as 119 GB when I have a 2 TB SSD (the maximum recommended). After five hours of testing, they failed to identify the issue. The in-car viewer still shows only partial clips, even though the full recordings are visible on a computer. • A/C Vibration and Noise: Despite Rivian tightening and insulating the A/C components, the vibration persists and is noticeable on the passenger side. This issue did not exist in the 1st generation R1S...

During an early season wet snow storm within minutes of driving the lights had become covered with snow and deflected the light in such a way that created a very unsafe driving environment. There was zero snow on the road because of it not being cold enough to stick but the deflection of the light and limited light on the road it was nearly impossible to see the road markings and lines to stay in the lane and created a very unsafe environment around me requiring me to drive significantly lower to try to stay on the road which could have caused an accident with other drivers who were not driving as slowly. There are a significant amount of reports of incidents like this across multiple forum platforms (ie: reddit) where drivers of the Rivian have indicated a drive that was very unsafe and something they had never experienced before....

Regarding the Safety Recall mentioned below, I reached out to Rivian Service Center. They are not giving me an ETA to fix this and no alternate is given. Is there anyways NHTSA help me by making Rivian Automotive LLC take responsibility and address the issue sooner than later ? They dont have a fix for below safety recall and no ETA on when they can fix it. Its really disappointing to see the lack of accountability. Appreciate your help in this matter. best regards [XXX] Jun 13,2025 Manufacturer Recall NumberFSAM-1693 NHTSA Recall Number25V-387 Recall StatusRecall Incomplete, remedy not yet available Summary Rivian Automotive, LLC has decided that certain model year 2025 Rivian R1S and R1T vehicles fail to conform to Federal Motor Vehicle Safety Standard (FMVSS) 108 and Technical Standards Document (TSD) 108 - “Lamps, reflective devices, and assoc. equipment.” Safety Risk Diminished front turn signal lamp performance may cause...

vehicle failed to signal on left hand turn

The contact owns a 2025 Rivian R1S. The contact stated received notification of NHTSA Campaign Number: 25V085000 (EXTERIOR LIGHTING). The local dealer was contacted; however, the contact was informed that parts were not yet available. The vehicle was not repaired. The manufacturer was contacted about the parts not being available. The contact stated that occasionally, during colder weather, the headlights failed to function properly. The approximate failure mileage was 10,000.

Hazard light switch stopped functioning one day. It is completely unusable and is a safety issue. Rivian cannot provide an ETA to fix the issue.

Driver side high beam lights are out or malfunction. No warning on dashboard except for "Adaptive High Beam not working." When the high beam assistance is set to Off, and I turn on the high beam manually, there are no warnings about the high beam malfunction whatsoever.