2013 RAM 3500 Fuelpropulsion System Problems

THE DEF GAUGE DOES NOT SHOW THE CORRECT AMOUNT OF DEF FLUID THAT IS ACTUALLY IN THE TANK, IT IS ALWAYS SHOWING FULL.

THE ISSUE OF THE "DEAD PEDAL" NEEDS TO BE FIXED. THIS HAS LEFT ME STRANDED IN THE MIDDLE OF AN INTERSECTION ON SEVERAL OCCASIONS. THIS HAS LEFT ME ON THE SIDE OF THE ROAD HAULING A 40" FIFTH WHEEL TRAILER AND NOW TODAY AT LUNCH I STOP AT A DRIVE THROUGH AND HAD TO PARK MY TRUCK THERE AS I HAVE A DEAD PEDAL. YOU GIVE IT GAS AND NOTHING HAPPENS. GOOGLE IT, ITS A HUGE ISSUE AND COULD VERY EASILY COST SOMEONE THERE LIFE.

ON DEC. 15, 2014 I RECEIVED A RECALL ON MY 2013 DODGE RAM 2500 DIESEL. THE RECALL WAS FOR A INLINE FUEL HEATER THAT MAY CATCH FIRE, IT HAD NO APPARENT FIX, NO PARTS, NO INSTRUCTIONS AND NO TIMELINE AS TO WHEN IT WOULD OR COULD BE FIXED. I CALLED THE DEALERSHIP AND SPOKE TO THE SERVICE MANAGER ABOUT MY CONCERNS, HE TOLD ME THAT IT WAS A REMOTE POSSIBILITY NEXT TO NONE, THAT THE VEHICLE WOULD CATCH FIRE. I ASKED HIM IF I COULD PARK IT INSIDE AND HE SAID YES, AND THAT THE RECALL WAS JUST BEING SENT OUT AS A PRECAUTION. ON THE EVENING OF JAN 28TH 2015 AT APPROXIMATELY 0:920 PM SMOKE DETECTORS ALERTED MY DOG AND HE WOKE ME UP. I WOKE MY WIFE UP YELLING (FIRE) I PANICKED I TOOK IN A DEEP BREATH COVERED MY MOUTH WITH MY FOREARM, OPENED THE PERSONAL ENTRY...

THE NEW DODGE RAM EQUIPPED WITH CUMMINS DIESEL EXPERIENCE A DEAD PEDAL, OR PEDAL DELAY WHEN PRESSING THE GAS PEDAL 3/4 TO FULL THROTTLE. THIS POSES A SERIOUS RISK WHEN NEEDING TO GET OUT OF THE WAY, OR MOVE THE VEHICLE UNDER EMERGENCY CIRCUMSTANCES. THIS HAPPENS UNDER ALL CONDITIONS: STOPPED, ROLLING, UNDER ACCELERATION ETC. IF YOU PUSH THE PEDAL TOO FAR THE TRUCK WILL NOT RESPOND TO OPERATOR COMMANDS AND WILL TAKE 1.5-2 SECONDS TO START PICKING UP SPEED. THIS IS A SERIOUSLY DANGEROUS SITUATION AND SOMEONE IS GOING TO GET KILLED OR SERIOUSLY INJURED. THERE IS NOT EXCUSE FOR A VEHICLE NOT RESPONDING TO DRIVER INPUT. MANUFACTURE CLAIMS "TURBO LAG", THIS IS SIMPLY NOT TRUE. YOU CAN BUILD TURBO BOOST, MONITORED ON THE VEHICLE GAUGE, THEN PRESS THE PEDAL TO THE FLOOR, THE TRUCK WILL NOT RESPOND FOR 1.5 TO 2 SECONDS. PLEASE LOOK AT FURTHER INFORMATION ON THE...

TL* THE CONTACT OWNS A 2013 DODGE RAM 3500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 14V635000 (ENGINE AND ENGINE COOLING, FUEL SYSTEM, DIESEL) AND 15V541000 (STEERING); HOWEVER, THE PARTS TO DO THE REPAIRS WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIRS. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

MY VEHICLE IS IN THE SHOP FOR A 5TH TIME FOR THE SAME ISSUE OF THE ENGINE LIGHT COMES ON, MESSAGE SAID ERROR WITH DEF SYSTEM , CALL DEALER. THEN MESSAGE CAME UP AND SAID IN 200 MILES TRUCK WILL SHUT DOWN TO ONLY 5 MPH. THE DEALERSHIP AND NOW WARRANTY IS REFUSING TO FIX IT AGAIN BASING THEIR CASE ON "CONTAMINATED DEF" FLUID AS THE CAUSE. I WAS TOLD THIS IS AN ISSUE ON THESE TRUCKS AND TO FIX WOULD BE $1700 OUT OF POCKET EVEN THOUGH IT IS STILL UNDER WARRANTY. ONCE THE DEF WAS CALLED "CONTAMINATED", EVERYONE STARTING CALLING ME ASKING FOR $ TO REPAIR THE SYSTEM SAYING IT WAS MY FAULT THE FLUID GOT CONTAMINATED. DISTANCE DRIVEN FROM DEF ERROR CODE 3 REPAIR AT THE DEALER TO DEF ERROR CODE 4, LESS THAN 100 MILES AND NO DEF FLUID WAS ADDED SINCE IT LEFT THE DEALER....

WHILE DRIVING ON THE HIGHWAY THE TRUCK STARTING SHAKING VIOLENTLY, THE SPEED WAS REDUCED THE SHAKE CEASED BUT THE FRONT DRIVER SIDE TIRE CAME OFF. WHEN TAKEN IN A DODGE DEALERSHIP TO INQUIRE ABOUT REPAIR,WAS TOLD THEY COULD NOT REPAIR IT. THIS VEHICLE HAS LOST POWER WHEN DRIVING ON THE INTERSTATE HIGHWAY DUE TO FAULTY FUEL SYSTEM.

TRUCK LOSES POWER WHEN ACCELERATING FROM A DEAD STOP. AS THE ACCELERATOR IS DEPRESSED OR FEATHERED, THE ENGINE LOSES ALL POWER FOR 2-3 SECONDS LEAVING THE DRIVER HELPLESS. IF I ALLOW THE ACCELERATOR TO RETURN TO IDLE POSITION AND THEN DEPRESS THE ACCELERATOR AGAIN, THE ENGINE REGAINS POWER AND THE VEHICLE ACCELERATES. THIS IS A VERY UNSAFE SITUATION AS I WAS TOWING A 12K POUND TRAILER AND WAS ATTEMPTING TO PULL ONTO THE HIGHWAY. WHEN THE VEHICLE LOST POWER, I WAS IN JEOPARDY OF BEING HIT BY ONCOMING TRAFFIC. THIS ISSUE HAS OCCURRED SEVERAL TIMES. I TOOK THE VEHICLE TO THE DEALER BUT THEY WERE NOT ABLE TO DUPLICATE THE FAULT. I EXPLAINED THAT THIS ISSUE HAPPENED WHILE THE VEHICLE WAS UNDER A LOAD. THE DEALER NEVER PLACED THE VEHICLE UNDER A LOAD DURING THEIR TESTING.

I WAS ON PA TURNPIKE ATTEMPING TO MERGE FROM A SERVICE PLAZA, WHEN AN OPENING IN TRAFFIC WAS AVAILABLE I APPLIED POWER TO MERGE INTO LINE . AS I DID THIS MY TRUCK DID NOT RESPOND !! I WAS PULLING A 36' FIFTH WHEEL TRAILER AT THE TIME AND MY MERGE INTO TRAFFIC BECAME VERY PERILIOUS! AFTER WHAT SEEMED LIKE A VERY LONG DELAY ( AND SOME BRAKING BY OTHER MOTORISTS ) MY VEHICLE FINALLY STARTED TO ACCELERATE. ONCE THE MOTOR RESPONDED I HAD PLENTY OF POWER TO ACHIVE SPEED WITH TRAFFIC . I HAVE TOLD DEALER ABOUT DEAD PEDAL AND WAS TOLD " NEVER HEARD OF IT " THIS HAS HAPPENED TO ME MORE THAT ONCE! *JS

RANDOMLY, WHILE ATTEMPTING TO AVOID HAZARDS AND/OR COLLISIONS AND WHILE MERGING ONTO MOTORWAY, GAS PEDAL BECOMES UNRESPONSIVE FOR UP TO 5 SECONDS. THIS USUALLY HAPPENS FROM A DEAD STOP; HOWEVER, HAS OCCURRED WHILE TRAVELING AT HIGHWAY SPEEDS ALSO. *TR

ENGINE LIGHT CAME ON, MESSAGE SAID ERROR WITH DEF SYSTEM , CALL DEALER. THEN MESSAGE CAME UP AND SAID IN 200 MILES TRUCK WILL SHUT DOWN TO ONLY 5 MPH. TOOK IT TO DEALERSHIP AND WAS TOLD THIS IS AN ISSUE ON THESE TRUCKS. THEY COULD NOT GET A NEW PART FOR 2 WEEKS. I WAS 3RD ON LIST AND 5 MORE BEHIND ME. THEY'RE HAVING TO ORDER SO MANY THAT THEY'RE BACK LOGGED. THIS PROBLEM NEEDS FIXED FAST! SURELY, THEY WILL DO A RECALL. *TR

MY TRUCK HAS BEEN PLAGUED WITH A TERRIBLE DELAY IN THROTTLE RESPONSE. WHEN TRYING TO MERGE INTO TRAFFIC THERE IS A SEVERE DELAY BETWEEN IMPUTING THROTTLE AND THE TRUCK ACTUALLY ACCELERATING. IT'S ALMOST LIKE THE TRUCK TAKES 3-6 SECONDS TO REALIZE THROTTLE INPUT. THIS HAS BECOME VERY DANGEROUS WHEN ATTEMPTING TO MERGE OR TURN ACROSS TRAFFIC. I HAVE TAKEN MY TRUCK INTO THE DEALERSHIP BUT THERE IS NOTHING AVAILABLE TO RECTIFY THIS. I AM CLEARLY NOT ALONE ON THIS, MANY OF US HAVING BEEN HAVING LENGTHY DISCUSSIONS ON THE FORUMS IN HOPES OF A FIX. *TR

WHEN LETTING OFF THE GAS PEDAL AND THEN PRESSING AGAIN, (LIKE MERGING OR A ROLLING STOP) THERE IS A LAG OF 1-2 SECONDS. VERY DANGEROUS WHEN PULLING OUT IN TRAFFIC. RAM SAYS THAT IS NORMAL. THIS NEED TO BE INVESTIGATED. THANKS *TR

TL* THE CONTACT OWNS A 2013 DODGE RAM 3500. THE CONTACT STATED THAT THE ODOR OF DIESEL FUEL WAS PRESENT INSIDE THE VEHICLE. THE CONTACT INDICATED THAT THE ODOR WAS PRESENT WHEN THE WEATHER TEMPERATURE WAS BELOW 50 DEGREES. THE VEHICLE WAS TAKEN TO THE DEALER, WHO COULD NOT DIAGNOSE THE DEFECT. THE CONTACT ALSO INDICATED THAT WHILE DRIVING AND RELEASING THE THROTTLE, THE VEHICLE WOULD CONTINUE TO ACCELERATE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. ADDITIONALLY, THE TRANSMISSION BECAME STUCK IN 4TH GEAR AND THE VEHICLE WOULD NOT ACCELERATE OVER 5 MPH. THE VEHICLE WAS TAKEN TO THE DEALER BUT HE WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF ALL FAILURES. THE FAILURE MILEAGE WAS 6000.

TL* THE CONTACT OWNS A 2013 DODGE RAM 3500. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH, SHE SMELLED AN EXTREMELY STRONG ODOR OF DIESEL FUEL INSIDE OF THE VEHICLE INTERMITTENTLY. THE FAILURE RECURRED ONLY WHEN THE FRESH AIR CONTROL SETTING WAS ACTIVATED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER TWICE HOWEVER, THEY WERE UNABLE TO DUPLICATE THE PROBLEM. THE MANUFACTURER WAS NOTIFIED OF THE DETECT. THE APPROXIMATE FAILURE MILEAGE WAS 6,000.