2021 RAM 1500 Fuelpropulsion System Problems

I was suddenly unable to fill the fuel tank of my truck on the way back from a 4 hour road trip in freezing conditions. I was able to get just enough fuel into my vehicle to make it back due to it occurring during a fuel up on the last hour of the drive. However, if this had happened earlier in the drive, I could have been stranded with my family in freezing conditions. There were no warnings and it hadn't been happening prior, other than a half dozen times randomly over the past 2 years where the fuel station nozzle clicked off a few times prematurely. But never to the extent of not being able to fill the tank. It was brought to a dealership and is currently having the fuel tank replaced due to a bad valve inside of it.

Change in acceleration since purchasing truck. Discovered recently the fuel pump was causing the problem. Also the air bag light comes on and warning of a safety issue.

I was driving on the highway going the speed limit and the car suddenly slowed to 35 and all sorts of lights (check engine light and others) came on and messages went across the screen about the throttle control and stability control. This is the 4th time this has happened to me. Each time I bring it to the dealer and am told "its a known computer glitch" or that there is a fix but it continues to happen again. Suddenly losing power and speed has caused other drivers to slam on breaks, swerve, etc. In order to reset the car I have to pull over on the highway to restart it. This is putting my safety and the safety of others at risk.

My vehicle is currently at the service department of a dealership by my, Covert CDJR Bee Cave, due to two codes that recently set: P0EA7 and P026E. Mopar/Stellantis issues a TSB for this issue. Number 07-003-22. This is a known and documented issued but if your vehicle is outside the original 36 month, 36k mile warranty they will not cover it. This issue is not from wear and tear it is a defect and flaw in the original design. I have requested good will coverage and up to this point have been denied.

Failed fuel pump Needs a new fuel pump at 34000 miles. Vehicle currently at the dealership service department I saw there were previous recalls on these vehicles and their fuel pumps I should not have to replace a fuel pump at this mileage, ever

Driving to work and my truck lost all electrical power. All display lights turned on and hazard light signal started blinking but the hazard lights were not actually on. I then lost all electrical power; power steering, hazard lights would not turn on, all dash lights and display lights, head lights at first and then the battery died a couple minutes after that started. I could not put the truck into neutral so I could push it to the shoulder of the highway. I had to put it in Neutral manually with the pull tab under the steering wheel. My Ram 1500 5.7L hemi etorque was towed to Andy Mohr Chrysler Jeep Ram. The service shop told me that the motor generator unit is on back order and it could take a month or 2 months for the part to come in.

After having the Fuel Pump replaced, it was revealed that there are wires above the fuel tank that have melted and are causing a fuel leak into different elements of the under carriage of the truck. The manufacturer is not willing to honor the recall and replace these parts (even though they are connected to the fuel system) so by their own logic this must be considered a separate issue. It is concerning that there is electrical melting occurring and causing a fuel leak right next to the effected area

Recall Statement – Fuel Overflow and Injury Incident Involving 2021 Dodge Ram 1500 I am reporting a recurring and hazardous issue with the fuel system on my 2021 Dodge Ram 1500. March 30, 2025: While refueling at a local gas station, the tank overflowed by approximately 3 gallons once it reached full capacity. I initially believed the problem was due to a faulty pump and notified a station attendant to clean the spill. May 2, 2025: At a different gas station, while refueling the same vehicle, a small amount of fuel again overflowed unexpectedly. This raised concerns, as it occurred under different fueling conditions. May 25, 2025: While refueling at the same station used on May 2nd, approximately 5 gallons of gasoline overflowed from the tank. As I attempted to remove the nozzle, I slipped on the spilled fuel and fell onto the concrete, injuring my right leg. At this...

On 3/6/25 at 0520 hours, I 95 northbound in Stafford, VA. at mile marker 141 in left travel lane at approximately 75 mph the truck suddenly lost power slowing significantly. We pulled over onto the left shoulder as the truck slowed and stopped. The truck required shutting off the ignition and restarting the vehicle for it to operable. We had vehicles behind us slamming on brakes and quickly changing lanes in order to avoid hitting us. This truck has been checked by a dodge dealership for previous complaints of this occurring at lower speeds. Dodge dealership told us, there are no codes, no recalls ( only on V8) , we can note it in file but there is nothing else we can do. This is unacceptable and almost got us into a serious accident. There is something wrong with the etorque.

Recall NHTSA 22V-767 pertained to a potential faulty high pressure fuel pump. The recall notice states: "FCA US will repair your vehicle [2] free of charge (parts and labor). To do this, your dealer will replace the HPFP, inspect and, if necessary, replace additional fuel system component." When I took the vehicle in for repair, the dealer replaced the fuel pump and also told me that there was a problem with the fuel pressure sensor that could cause the vehicle to stall at highway speeds. The said that only the fuel pump was covered by the recall, yet the recall notice also clearly states "additional fuel system components." Should the dealer be covering the fuel pressure sensor also given that it is a fuel system component that could cause the vehicle to stall at highway speeds?

Gas filler line (exterior of car to gas tank) exhibits blowback when filling gas tank resulting in backup of gasoline /fuel often spilling on to pavement and clothing/shoes. This is a personal safety and environmental impact item. Multiple instances reported in on line forums and verbally acknowledged as a frequent problem in RAM 1500 vehicles. No lights/warnings were noted. Problem started at greater than 65000 miles. Problem is not intermittent.

When attempting to refuel the vehicle with gasoline, the refueling nozzle automatically stops after just 1 or 2 seconds of fueling at the full flow rate. Even at somewhat slower rates, something happens to cause the refueling nozzle to shut off ("click off") the fuel flow. Operating the refueling nozzle at a very slow rate is the only way to get fuel into the vehicle. This takes a very long time. Pulling the nozzle partially out of the filler neck can help increase the flow rate, but then gasoline unexpectedly splashes/spills out of the filler neck and can splash on the person refueling as well as down the side of the vehicle and onto the ground. This situation is a fire hazard and an environmental hazard.

Big oil leak on 3.0 Eco-Diesel front lower timing chain cover Dealer been trying to repair leak for over 2 years. Keepes leaking more and more. Yesterday driving smoke and oil fumes were coming inside the vehicle. You could smell burning oil. This vehicle is a major fire hazard and unsafe to drive. It's also hazardous to the environment and salmon streams. I see from the internet lots of other owners are having this same problem

I was driving on the highway when my vehicle suddenly lost power and simultaneously the service throttle control and service electronic stability control messages came up as well as the check engine light came on. This also happened last November and the dealer said they fixed the issue (high pressure fuel pump) but it has now happened again. I was concerned for my safety as well as my passengers and others as we did not have adequate power to get up a hill. And the sudden slowing nearly caused an accident.

I have tried at three dealerships to get this recall repaired over the last two years. Everyone tells me they cannot get the parts including a replacement fuel pump. Each dealer has stated that it needs to be replaced. I drive this vehicle everyday at apparently my own risk. The state of Ohio sent a letter requiring repair of this safety recall. Any assistance in this matter would be greatly appreciated. With an open safety recall I am unable to trade or sell the vehicle.

We purchased a new 2021 Dodge Ram in November of 2021 from Desert 215 Superstore in Las Vegas, NV. Nine months later the truck stalled while driving. The dealership kept the truck while they repaired the fuel pump. They had our truck for seven months while they attempted to repair it. The dealership couldn't figure out how to repair the underlying cause of the faulty fuel pump--therefore they replaced the powertrain, transmission, and engine. Approximately, one year later on [XXX], 2024, the truck stalled while crossing a busy intersection--my husband had our two young sons in the car which could have resulted in a serious accident but thankfully did not. We received a recall notice again last night about the fuel pump along with two other notices. Therefore it was not repaired correctly the first time. I looked up the vehicle information online and there are several class action lawsuits...

My truck has 72k miles for the second time now it shuts down during highway driving with the sign in dashboard electronic throtle control, after first time I took it to dealer and they claimed it was repaired, this is putting my and my family's life in danger. Based on my research it appears a known and ongoing issue with Stelanis/Chrysler.

Fuel tank valves have failed.

We purchased this Ram Rebel on 03/26/ 2022 from El Cajon Ford. At the time, we checked and there were no recalls associated with it so we went ahead with the purchase. However, in Oct 2022, we were notified of a recall associated with the truck's fuel system. We promptly contacted the dealership who said the recall parts were on back order. Every few months for the next year we called to inquire about the status of the parts concerned for our safety in the vehicle. Each time we called, we were told there was nothing they could do because the parts were back ordered. On November 11, 2023 we were driving home from a friend's house and the truck stalled in the middle of a busy road (Scripps Poway Parkway) jeopardizing our safety and causing emotional distress. We were able to get the truck to the side of the...

Around 12/4/2023 I took my 2021 Ram ecodiesel in for a recall on the high pressure fuel pump (z96 recall). It was the first time this dealership had done one of these recalls. After 2 days of working on it , I got it back. 2 weeks later, 12/20/23 I auto started my truck with the factory auto starter. Once I got into the truck, and attempted to turn it on, it set off alarms, asked for anti theft code, and the dash lights were all on saying I had all sorts of issues. I called RAM and was told I needed to tow it to the nearest dealership, which I did on the same day 12/20/23. After almost a month at the dealership and no information, I drove my wife's car and went to talk to them. They told me they believe it is a bad fuse box and...

My RAM truck stalled about 2 months ago. When towed it to the dealer they diagnosed a high pressure fuel pump failure which was due to an open recall. I had attempted to take care of the recall multiple times but I was told that the part was not available yet. Now that it caused a bigger issue with the truck, it has been over 2 months and the truck is just sitting on the dealer. It has been impossible to get a rental car while the truck is waiting for repair. This should not happen. The truck is 2 years old. It was obviously due to a faulty factory part. If I could get a loaner vehicle for the duration of the repair this situation would be more tolerable. Instead, countless phone calls and emails and still no loaner vehicle. I will never buy Chrysler again in my life...

I have a safety recall dated Oct 13, 2022 that is still not repaired. I have tried multiple dealers and the manufacturer and I still can not get an answer on if they are going to do the repair. I feel like they are hoping I will just go away and they will not have to make the repair.

On 11/23/23 my check engine light came on suddenly with the code P020E upon reviewing information online I determined there was a recall on my truck for the HPFP (Manufacturer Recall NumberZ96 NHTSA Recall Number22V-767). The following day the check engine light went away but I took the vehicle to a dealer in Florence South Carolina (Legacy Chrysler Jeep Dodge RAM) to have the vehicle inspected before driving. They refused to look at the vehicle and told me they wouldn't look if the light was not on. They told me to drive with the vehicle. I was traveling for the holidays and continued home. When approaching home (Plymouth, MA) the check engine light along with two errors to service the electronic stability control and to service the electronic throttle control came on. I immediately stopped driving and then took the vehicle to the local dealer when they opened on Monday...

Manufacturer failed to complete repair on recall for HPFP and airbag in a timely manner with no timeline or remedy available.

After 4 days of ownership with less than 15,000 miles on it the truck died in intersection. No warning lights came on. Truck would not restart and is currently at the dealership.

Manufacturer Recall NumberZ96 / NHTSA Recall Number22V-767 A solution has not been yet provided by the manufacture. This has a safety risk and I am concerned as to why owners are not updated regularly on having a solution by now. The focus of a solution should be monitored by the NHTSA so we all benefit. This is an unacceptable timeline for a vehicle we paid a lot of money for as the safety risk is high. I would like to receive regular updates on this recall and work being done to a proposed solution.

as i turned on rt 29 getting up to speed my truck completely shut down in the middle of morning rush hour traffic

#3 & #5 fuel injector failing while driving, separate instances, 2 months apart, causing severe loss of power and inability to control speed

I was driving the vehicle about five miles-per-hour and came to a stop sign, then came to a full stop. I then proceeded to make a right turn and was driving straight for about one-quarter of a mile at a speed of about five to ten miles-per-hour. Next, I slowed the vehicle down and made a right turn. The vehicle then completely stalled and turned completely off. The engine stopped, all of the meters on the dashboard turned completely off and the entire car and all electronics were completely off without warning. It was a random shutdown, there were no warning lights and no engine warning light or anything. Immediately after the vehicle turned off, I put my foot on the brake, then I had to put the vehicle in park, and then I had to restart the vehicle by pushing the "start engine" button. My safety, the passengers safety,...

We lease a 2021 Ram. For the past year our truck will randomly stall when making a turn and pushing the gas. It shuts off, puts the vehicle in park, and engages the emergency brake when pulling out into traffic. We have brought it in to the dealership we got it from, letting them know that this is a huge safety concern especially if pulling out into busy traffic which is something we have to do on a daily basis. They said since they cannot replicate the issue there is nothing to fix. Our truck continues to stall and we use it not only for transport of our family but for hauling horse trailers - making it even more dangerous. We need a resolution as this puts us at risk and is very stressful, changing how we drive because we are afraid to pull out in certain situations.

When filling the vehicle gas pours out of the fuel fill tube and onto the pavement. It is almost to the point where I am unable to fill the vehicle with fuel. In order to put gas in you have to basically goes as slow as possible taking up to 20 plus minutes to fill. Dangerous to have gas spilled on the gas station cement that could catch fire and cause explosions'. Dealership informed me of several complaints with this issue. The vehicle has not been inspected by anyone as this vehicle is now out of warranty by 8k miles and could cost up to $1200.00 to fix. There are no warning signals for this issue

My 2021 Ram 1500 eco diesel had roughly 20,500 miles on it. On January 17th I was driving in my neighborhood and the car completely stalled and all electrical systems shut down. I was able to drift to the side of the road, called roadside service and had it towed to the dealership. After inspecting the vehicle it was confirmed the problem stemmed from the unresolved recall issue. They repaired my vehicle at no cost but the recall parts are still not available and there is no timeline as to when they will be available. Therefore the parts they put back in my car can fail again. I received my vehicle back on January 25th. I feel this vehicle is completely unsafe. I expressed my concerns to Chrysler and they reviewed the situation for a possible buyback program but then denied it. After experiencing the complete shutdown of my vehicle...

When fueling at the gas station the nozzle will not continuously flow. Even manually pressing the trigger to release the fuel from the hose it constantly clicks off after a few seconds. Adjusting the nozzle has no effect and fueling takes an extensive amount of time having to put small amounts over and over

I was at service station to get gas, and the nozzle clicks off no matter what speed I try, even though my tank shows being 1/2 full. Gas also runs out getting on my hand, the truck, and the ground. This is my first report of the problem, but it has occurred several times over the past two months. I had wondered if it could have been the nozzle malfunctioning, but I pulled up to the next pump and encountered the same issue. Had we been on a trip and unable to add fuel we could have been stranded. Had we been on an Interstate and got stuck in traffic for an extended time, we could suffer the consequence of running out of fuel. The result could be tragic had the overflowing gas found an ignition source. Finally, the presence and smell of gasoline on me and my clothing is...

Was making a slow 10-15mph right hand turn out of my neighborhood and the truck stalled. Power was still on, park brake came on while in motion. Had to shift back to park to restart. Once restarted, no caution or warning lights on the dash.

I bought my truck brand new with 500 miles on it Oct. 14th 21. I made it to around 70k when the truck would stutter and hesitate to drive. Took it to dealership and said No codes, nothing wrong after 2 days of "checking it". Brought it back at 76k and truck would hardly drive, but yet said they couldn't figure it out and sent me on my way. Was driving home at 85k and truck stalled going 75mph while on a 2 lane highway. The truck rolled to about 30 mph and completely died and locked up steering wheel and activated the E brake as I was almost safely off the road. After trying time and time again, I finally got the truck to start and off the road. Called dealership and was told they wouldn't tow it as it was out of warranty at this point. So I...

Engine fuel pump failed and sent metal shavings throughout the fuel system.

On 8/18/22, I pulled out from a stop sign and as I was moving over to my desired traffic lane, my vehicle shut down, we heard one ding from the dash board, no warnings appeared. I was on a major roadway (north decatur ave at the 215 North Beltway) and was fortunate to be able to move to the far righthand lane. Since there was a sidewalk I wasn't able to get my vehicle out of the roadway. I notified the State Police, activate emergency flashers and we exited vehicle because traffic was traveling through the area at a pretty good speed (45 mph zone). Notified Ram roadside and requested tow to dealership. Attempted several times to restart truck, the starter would only spin but would not fire (sounded like no fuel but I had 1/2 a tank). State Trooper pulled in behind us and activate emergency lights to protect...

On 8/13 while driving at low speed through a residential neighborhood my 2021 RAM 1500 suddenly display a warning message and switched from drive into park while the vehicle was still moving. Wheels and steering locked causing me to loose control of the vehicle while it proceeded to skip until it came to a stop in the middle of the road. Luckily I did not hit anything or anyone. Would not restart and had to have it towed to local RAM dealer (J-Star Anaheim CA). They diagnosed a failed fuel pump which resulted in metal in the fuel system, but could not explain why transmission went from drive to park while vehicle was moving. If this failure had occurred while driving at freeway speed the results would have been catastrophic. Vehicle is still at J-Star being repaired. I am fearful of using it even after the fuel system is fixed....

Fuel is pouring out of the lines onto the engine. Not just a leak, but flowing out. This could cause my engine to catch fire.

I made a right hand turn from a stop sign onto an active roadway when my truck’s engine shut off. The truck rolled to a stop and the dial shifter automatically changed to park and engaged the e-brake. No warning lights were triggered in the dash. Research suggests this is an apparent problem with the 5.7l e-torque engine, however, no information is available from FCA/Ram

While driving at slower speeds, the truck unexpectedly stalled and emergency brake engaged. The car behind us had to slam on their brakes due to the unexpected stop. There were no prior warning lights, messages, or symptoms prior to the failure.

Truck randomly shuts down and the engine light goes on and a warning about a throttle body issue,

Vehicle randomly stalls while driving. Occasionally will also deploy emergency brake when it stalls

April 12, 2022 multiple warning lights ( check engine, electronic throttle, etc. ) appeared, screen warning to get to dealer to service. April 13, 2022 visited local dealer, earliest to service April 20, 2022. April 16, 2022 limp mode, restarted vehicle, restored normal operation with warning lights still showing. April 18, 2022, dealer serviced and stated fixed. April 19, 2022, warning lights and limp mode while driving on highway at 70 MPH. Managed to get to side of road in traffic, waited for break, turned around home. April 20, 2022 vehicle to dealer to repair. Still there as of April 28, 2022. "Star Case" opened. All diagnostics failed to locate problem, now trying various inspections / repairs per FCA technical. Dealer advises they have another similar vehicle ( 2021 Jeep Gladiator Eco Diesel ) with exact same situation so this is not one odd vehicle. Further extent of affected vehicles...

The start/stop system will turn frequently display an error stating the "auto start/stop system in not available" When coming to a traffic stop, the engine will turn off and will not restart for 2-3 minutes while sitting in traffic

Truck stops running, fuel shuts off but power stays on.

While driving my truck at approximately 70MPH on the highway, the truck shut down. I was able to pull off the side of the road and dashboard showed the message of Electronic Throttle Control and the engine light turned on. This is the third report I have filed regarding this truck shutting down while driving and the 7th time this truck has randomly shut down on me since purchasing in July 2021. This has been on the dealership 2 separate times and is going in tomorrow for a third time for this issue, I no longer feel safe driving this truck and feel this incident should be address as soon as possible,

I was driving on the highway when all of sudden my truck shut down, I coasted to the emergency lane and was unable to restart my truck, I waiting about 10 minutes, restarted my truck and had to keep pumping the throttle to keep it running to get to my destination. I was able to have an OBD reader connected to my truck at a dealership and there were 3 codes stored all relating to fuel. This happened to me in twice in November of 2021 and again twice on January 7th of this year. I also received another code at the dealership on January 8th regarding another recall. These combined total of 4 shut downs have put me and my family in extreme danger, this brand new truck is unreliable and we are hesitant to drive it.

While driving to the highway out of my neighborhood my truck lost all power, I was able to pull over to the side, read the message, “electronic throttle control”, wait a few minutes and restart my truck and continue on my way, I had lost complete acceleration and my truck shut down, I had no throttle power, again later that night returning home my truck again shut down and showed the message “electronic throttle control”, again I was able to pull off the side of the highway, wait and attempt to restart which I was able to do after about 10 minutes, again I lost complete acceleration again I had no throttle power but was able to put on my emergency flashers and coast to the side of the road, this is the 4th time this has happened to us and the second time our new truck has been in...