1999 PONTIAC SUNFIRE Electrical System Problems

TL* THE CONTACT OWNS A 1999 PONTIAC SUNFIRE. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE VEHICLE DECELERATED. THE CONTACT WAS ABLE TO SAFELY MANEUVER TO THE SHOULDER AND SHUT THE VEHICLE OFF. THE VEHICLE WOULD NOT RESTART. THE VEHICLE WAS THEN TOWED TO A DEALER FOR DIAGNOSIS. THE DEALER STATED THAT THEY HAD TO REPLACE THE IGNITION SWITCH. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 04V036000 (ELECTRICAL SYSTEM). THE FAILURE AND THE CURRENT MILEAGES WERE 86,000.

THE INSTRUMENTAL PANEL ON MY 1999 PONTIAC SUNFIRE RECENTLY STARTED FUNCTIONING ERRATICALLY I.E. GAUGES (GAS GAUGE, TEMPERATURE GAUGE, SPEEDOMETER) WOULD START FLUCTUATING WILDLY. LOCAL PONTIAC DEALERSHIP HAS DIAGNOSED THE VEHICLE AS HAVING A DEFECTIVE (OR BURNED OUT) INSTRUMENTAL PANEL CLUSTER. I WAS TOLD THAT THIS COMPONENT WAS NOT COVERED UNDER ANY TYPE OF LIFETIME WARRANTY AND THAT THE REPAIRS WOULD COST $472.31. IN RESEARCHING THIS PROBLEM ON THE INTERNET, IT APPEARS TO BE SYSTEMIC AMONG LATE 1990 TO EARLY 2000 PONTIAC VEHICLES. FROM A SAFETY STANDPOINT, IT IS A DANGEROUS CIRCUMSTANCE TO BE DRIVING 70-75 MPH ON THE HIGHWAY AND TO HAVE YOUR INSTRUMENT PANEL START MALFUNCTIONING. PONTIAC SHOULD BE FORCED TO RECALL THESE DEFECTIVE INSTRUMENT PANEL CLUSTERS AND REPAIR THEM AT NO CHARGE. *KB

DURING NORMAL OPERATION OF A 1999 PONTIAC SUNFIRE, 4DR, 2.2 LITER ENGINE, AUTOMATIC TRANSMISSION. THE WIRING HARNESS AT THE DRIVERS DOOR FRAME, AT THE CONNECTION OF THE UNDERDASH HARNESS AND THE REAR OF VEHICLE HARNESS SHORTED, CAUSING THE INSULATION TO CATCH FIRE. THIS SITUATION SHORTED OTHER CIRCUITS IN THE HARNESS CAUSING BRAKING PROBLEMS WITH THE ANTI-LOCK SYSTEM. VEHICLE WAS ABLE TO BE STOPPED SAFELY, AND THE DRIVER, WITH GOOD SAMARITAN ASSISTANCE WAS ABLE TO EXTINGUISH THE FIRE. FIRE RENDERED THE HOOD LATCH INOPERATIVE. THIS PREVENTED THE DRIVER FROM DISCONNECTING THE BATTERY GROUND CABLE, TO PREVENT FURTHER DAMAGE AND/OR FIRE. *TR

I HAD A 1999 PONTIAC SUNFIRE. IT WAS PARKED OUTSIDE OF RESIDENCE WHEN IT CAUGHT ON FIRE. THIS WAS A FEW YEARS AGO APPROXIMATELY AROUND JULY OF 2006. PONTIAC DID NOT ACCEPT FAULT. THEY SAID THE FIRE DESTROYED ANY EVIDENCE OF A DEFECT. *TR

THE AIR CONDITIONING COMPRESSOR PUMP (A/C PUMP) COMES INTO CONTACT WITH THE (1999) OEM LOWER RADIATOR HOSE (HOSE), DENTING THE HOSE AND WEARING A HOLE IN THE HOSE OVER TIME. THIS CONDITION IS WORSE WHEN FRONT STRUTS AND/OR ENGINE MOUNTS BECOME WORN. INITIAL LEAK OF COOLENT IS ONLY DETECTABLE BY LOW FLUID LEVEL OVER EXTENDED PERIOD OF TIME (APPORXIMATELY 6 MONTHS TO A YEAR): NO WETNESS ON THE HOSE OR POOLING OF COOLENT FLUID UNDER THE VEHICLE IS DETECTABLE PRIOR TO A LARGER HOLE BEING WORN INTO THE HOSE. PRIOR TO LARGER HOLE BEING WORN INTO HOSE, COOLENT LOSS IS IN VAPOR FORM, BUT NOT IN A SUFFICIENT AMOUNT TO BE SEEN. ONCE THE HOLE IN THE HOSE BECOMES LARGE ENOUGH TO BE DETECTED BY FLUID POOLING UNDER THE VEHICLE, THE COOLENT FLUID WILL COME IN CONTACT WITH THE POWERTRAIN CONTROL MODULE (PCM) AND CAUSE FAILURE OF THE PCM. THE...

MILEAGE FLASHES ON AND OFF LIKE THERE IS A SHORT AND AIR BAG LIGHT STAYS ON THE WHOLE TIME THE CAR IS RUNNING AND WHILE DRIVING.:( CLUNKING IN FRONT END POSSIBLY BY TIRES? LIKE THE SHOCKS OR WHATEVER

1999 PONTIAC SUNFIRE BURST INTO FLAMES IMMEDIATELY FOLLOWING LOUD CLUNK IN ENGINE WHILE DRIVING ON EXPRESSWAY. VEHICLE IS TOTALED. SPARK PLUG FELL TO GROUND AS FIRE STARTED. *NLM