1997 PLYMOUTH GRAND VOYAGER Electrical System Problems

TAKATA RECALL,SERPENTINE BELT HAS SHREDDED AT LEAST SIX TIMES AND JUST CAME OFF THREE TIMES ,TENSIONER REPLACED THREE TIMES,IDLER PULLEY TWICE,WHEN BELT SHREDS WIRES SEVER AND VAN STOPS ABRUPTLY,WINDSHIELD WIPERS STOP ABRUPTLY HESITATING BEFORE RESUMING,SWAY BAR LINKS NEED REPLACED,O2SENSORS CHECK ENGINE LIGHT TO COME ON,CV AXLES FAILING REPLACED RIGHT TWICE,HUB ASSEMBLY AND BRAKE CALIPERS MISS ALIGNED,ENGINE MOUNTS FAILED AND NEEDED,REPLACED,AIRBAG AND ABS LIGHTS ON DASHBOARD PANEL FUSE BLOWING,TAILLIGHTS POSSIBLE SHORT CAUSING BRAKE LIGHT TO FAIL,BATTERY NEEDING TO BE DISCONNECTED. TO SAVE BATTERY FROM DYEING DUE TO BRAKE LIGHTS STAYING ON CONSTANTLY, TRANSMISSION JERKING AND HESITATING IN REVERSE AND FIRST GEAR,PASSENGER SIDE WINDOW NOT OPERATING POSSIBLE PROBLEM,BACK WINDOWS OPEN BUT WILL NOT ALWAYS SHUT,HORN NOT WORKING,REPLACED FUEL PUMP DUE TO GAS LEAK,WHEN BRAKING VAN LURCHES FORWARD,FRONT END SHAKES, TIE BAR ENDS REPLACED,HEATER BLOWS COLD ON PASSENGER SIDE AND NOT COOLING,MOST PROBLEMS OCCURRED WHILE DRIVING,REPLACED STOP BRAKE SWITCH, BRAKE LIGHT DRIVERS SIDE...

WHEN I TURN ON MY CAR AFTER 3 TO 5 SECOND IT WOULD TURN OFF AND WHEN I AM DRIVING WHEN IT REACHES ABOUT 15 TO 25 THE CHECK ENGINE LIGHT WILL TURN ON AND CAR TURNS OFF AND STEERING WHEEL DOS NOT WORK AND THE BRAKES DOS NOT WORK, BUT THE ELECTRICITY IS STILL WORKS , THE STEREO WOULD STILL BE ON. *TR

SO FAR THIS VEHICLE HAS BEEN A LEMON. I HAVE REPLACED EVERYTHING ON IT, FROM FUEL PUMP, SENSORS, STEERING COLUMN, BELT TENSIONER AND PULLEY, ALTERNATOR, WIPER SWITCH THAT SEEMS TO HAVE A MIND OF ITS OWN EVEN THO I REPLACED A NEW SWITCH. NOW MORE ELECTRICAL PROBLEMS. THE INSTRUMENT CLUSTER IS NOW MESSED UP. ABS LIGHT AND CHECK ENGINE LIGHT KEEP COMING ON ALL MY GAUGES GO FLAT. LIGHTS GO DIM. THEN SUDDENLY LIGHTS WILL FLASH AND THEY WILL ALL COME BACK ON. THEN GO OFF AGAIN. NOW, NOT ONLY DO THEY GO FLAT BUT NOW I HAVE A SHIFTING PROBLEM. THE VEHICLE WILL NOT SHIFT. IT SEEMS TO BE STUCK IN 2ND GEAR. I REPLACED THE WHOLE BRAKING SYSTEM. EGR VALVE, CAM SENSOR, CRUISE CONTROL, THE BODY. THE GAS PEDAL USE TO ACCELERATE ON ITS OWN. THAT WAS A LITTLE SCARY GOIN DOWN THE ROAD NOT KNOWING WHEN IT...

SERPENTINE BELT FALLS OFF ALL THE TIME IT PULLS INWARD TOWARD THE ENGINE SLIGHTLY ANY WHEN IT GETS JUST A LITTLE WET IT SLIPS OFF. THE TENSIONER PULLEY LOOKS LIKE IT NEEDED TO BE COCKED UPWARD JUST THE SLIGHTEST LITTLE BIT AND THEN IT DON'T MOVE GATES AFTERMARKET PRODUCT WORKS PERFECT FOR ALL WHO USE IT CHYRSLER SHOULD BE THE ONES PAYING TO HAVE THIS PART REPLACED NOT US THIS IS WAY TO COMMON OF A PROBLEM . *TR

TL*THE CONTACT OWNS A 1997 PLYMOUTH GRAND VOYAGER. THE CONTACT STATED THE ENTIRE INSTRUMENT PANEL INTERMITTENTLY FAILED AND ALL OF THE GAUGES DROPPED TO 0. THE VEHICLE ALSO INTERMITTENTLY STALLED. THE FAILURE OCCURRED WHILE AT A STOP SIGN AND WHILE DRIVING AT VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP WHERE THE CONTACT WAS ADVISED TO REPLACE THE INSTRUMENT CLUSTER. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 162,000 AND THE CURRENT MILEAGE WAS 164,000.

THE INSTRUMENT PANEL STARTED GOING OFF AND ON. WHEN IT WOULD GO OFF THE ABS LIGHT WOULD COME ON AND THEN THE ENGINE SERVICE LIGHT WOULD COME ON, DURING THIS TIME EVERY THING WENT OUT. THE SPEEDOMETER, ODOMETER, GAS AND TEMPERATURE GAUGES WENT OUT. I WOULD HIT THE DASH AND IT WOULD WORK CORRECTLY. I FINALLY HAD TO REPLACE IT AND THAT ONE LASTED ABOUT A YEAR AND A HALF. SO KNOW I HAVE PUT ANOTHER ONE IN AND AT THIS TIME HAVING PROBLEMS GETTING IT TO FUNCTION. I SEE A LOT OF COMPLAINTS ON THE INTERNET, BUT NONE ON NHTSA WEBSITE. *TR

AIR CONDITIONING SYSTEM: EVAPORATOR WAS REPLACED 3 TIMES SO FAR, FIRST TIME BEING UNDER 3 YEAR WARRANTY. SERVICE ENGINE LIGHT STAYS ON ALL THE TIME NOW, EVEN AFTER BEING DIAGNOSED WITH "NO PROBLEMS" AND BEING RESET. LATELY, THE WINDOWS WON'T GO UP AND DOWN UNTIL THE CAR IS STOPPED AND RESTARTED. SAME THING WITH THE SPEEDOMETER AND THE TACHOMETER. THEY JUST "GO DEAD". *NM

DT*: THE CONTACT STATED SINCE THE VEHICLE WAS PURCHASED IN 2002 FROM AN INDEPENDENT DEALER, THE VEHICLE HAS BEEN HAVING ON GOING PROBLEMS WITH THE ELECTRICAL WIRING, ALTERNATOR, RADIATOR, THERMOSTAT, COOLING SYSTEM. DIAGNOSTIC TESTING IS NEEDED FOR GROSS POLLUTION. THE VEHICLE HAS FAILED UNDER FAIR WEATHER CONDITIONS THREE TIMES SINCE PURCHASE. EVENTS LEADING UP TO THE FAILURES OF THE FAN, RADIATOR AND TRANSMISSION OCCURRED WHEN VEHICLE STARTED TO RUN HOT, CAUSING TRANSMISSION TO BLOW OUT. SERVICE FOR THESE COMPONENTS WERE PERFORMED AT AN INDEPENDANT AUTO SHOP.

ENGINE AND AIR CONDITIONER WERE RUNNING. CONSUMER TURNED OFF ENGINE, BUT NOT AIR CONDITIONER. CONSUMER LATER TRIED TO START THE VEHICLE, BUT IT WOULD NOT START. THE CONSUMER HAD GOTTEN OUT, AND SAW FLAMES UNDER THE HOOD. THE WIRES UNDER FUSE BLOCK WERE BURNING. CONSUMER WAS ABLE TO PUT FIRE OUT. *AK DEALER REPAIRED BURNED WIRING AT PDC AND REPLACED TWO 40 AMP FUSES IN PDC. *SCC

WHILE DRIVING THE VEHICLE CAUGHT FIRE, IT APPEARED TO BE ELECTRICAL, CLAIM # 40-2269-222. NLM

CONSUMER STATES WHILE DRIVING, THE VEHICLE CAUGHT ON FIRE, IT APPEARED THAT FIRE WAS DUE TO AN ELECTRICAL PROBLEM (CLAIM # 40-2269-222). *YD

CONSUMER STATES WHILE DRIVING, THE VEHICLE CAUGHT ON FIRE, IT APPEARED THAT FIRE WAS DUE TO AN ELECTRICAL PROBLEM (CLAIM # 40-2269-222). *YD

WHILE DRIVING THE VEHICLE CAUGHT FIRE, IT APPEARED TO BE ELECTRICAL, CLAIM # 40-2269-222. NLM

VEILCLE HAS BEEN EXPERIENCING ONGOING PROBLEMS WITH ELETRCAL SYSTEM, WHICH INTURN, CAUSED PROBLEM WITH WINDSHIELD WIPER MOTOR,/OOR MOTOR, ENGINE CHECK LIGH/ODOMETER . ALSO, STEERING WHEEL WOUD LOCK UP INTERMITTENTLY. VEHICLE BEEN IN/OUT OF DEALER SHOP ON ELEVEN OCCASIONS, AND NO CORRECTIONS HAVE BEEN DONE. *AK