2005 ORION V — Problems, Recalls & Safety Data
N/A
Safety Rating
0
Owner Complaints
5
Recalls
0
Service Bulletins
0
Investigations
Overview of the 2005 ORION V
The 2005 ORION V has received a total of 0 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). There have been 5 recall campaigns affecting this vehicle, covering issues with ELECTRICAL SYSTEM, ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER, POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE).
Recalls for the 2005 ORION V
NHTSA has recorded 5 recalls for the 2005 ORION V, potentially affecting up to 4,973 vehicles.
Recall 13V476000 — ELECTRICAL SYSTEM
| 3,009 vehicles affected
Defect: Daimler Buses North America Ltd. (DBNA) is recalling certain model year 2003-2008 Orion V and model year 2002-2010 VII buses equipped with Sure Power equalizers and DC-DC Converters. The specific potting compound used in the equalizers and convertors for insulation was found to be capable of conducting electricity after being exposed to heat.
Consequence: Once electrically conductive, the material is capable of melting and burning, increasing the risk of a fire.
Remedy: DBNA will notify owners and Sure Power representatives will change out the equalizer and/or convertor, free of charge. The recall is expected to begin during November 2014. Owners may contact DBNA at 1-905-403-1111.
View full details →Recall 12V447000 — ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER
| 187 vehicles affected
Defect: Daimler Buses North America (DBNA) is recalling certain model year 2004-2008 Orion V and model year 2005-2006 Orion VII transit buses equipped with John Deere Compressed Natural Gas (CNG) turbocharged engines. The turbine or compressor wheel may fail, resulting in subsequent damage to the engine and/or an oil leak.
Consequence: Failure of the turbine or compressor wheel may result in smoke, fire, and stalling, increasing the risk of a crash.
Remedy: DBNA will notify owners. The remedy for this issue is still under development. The safety recall began on September 28, 2012. Owners may contact Daimler Buses North America at 1-800-882-8054.
View full details →Recall 10V015000 — POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE)
| 426 vehicles affected
Defect: DAIMLER BUSES IS RECALLING CERTAIN ORION TRANSIT BUSES EQUIPPED WITH THE MORSE REMOTE THROTTLE CONTROL. THE MORSE REMOTE THROTTLE CONTROL PANEL IS LOCATED IN THE ENGINE COMPARTMENT AND A SWITCH ON IT IS LABELED, "THROTTLE"; "OFF" OR "FRONT" AND "ON" OR "REAR" SELECTING THE ACTIVE ENGINE CONTROL STATION. IF A PERSON OPERATING THE ENGINE FROM THE "REAR" POSITION (AT THE...
Consequence: THE BUS COULD ACCELERATE AT A HIGHER RATE THAN ANTICIPATED INCREASING THE RISK OF A CRASH.
Remedy: DAIMLER WILL PROVIDE INSTRUCTIONS TO MODIFY THE WIRING TO THE MORSE THROTTLE CONTROL SWITCH. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 1, 2010. OWNERS MAY CONTACT DAIMLER BUSES AT 1-800-716-7466.
View full details →Recall 09V412000 — EQUIPMENT ADAPTIVE/MOBILITY
| 983 vehicles affected
Defect: DAIMLER BUSES IS RECALLING CERTAIN MODEL YEAR 2000 THROUGH 2008 ORION TRANSIT BUSES EQUIPPED WITH LIFT-U WHEELCHAIR LIFTS. THE LIFTS ARE EQUIPPED WITH A LOGIC BOARD ASSEMBLY FOR THE WHEELCHAIR LIFT CONTROL BOX, P/NOS. 373-0226 AND 373-0265. THE OUTBOARD RAMP BARRIER COULD FOLD IN TOWARD A LIFT PASSENGER AND PINCH, PRESS, OR CRUSH THE PASSENGER'S FEET.
Consequence: THE LIFT PASSENGER COULD BE SERIOUSLY INJURED.
Remedy: ORION WILL NOTIFY OWNERS AND THE REPAIRS WILL BE MADE BY LIFT-U FREE OF CHARGE. PLEASE SEE LIFT-U'S DEFECT REPORT 09E-051. THE SAFETY RECALL BEGAN ON OCTOBER 29, 2009. OWNERS MAY CONTACT LIFT-U AT 1-209-838-2400 OR ORION AT 1-800-716-7466.
View full details →Recall 09V413000 — INTERIOR LIGHTING
| 368 vehicles affected
Defect: DAIMLER BUSES OF NORTH AMERICA IS RECALLING CERTAIN MODEL YEAR 2002 THROUGH 2009 ORION TRANSIT BUSES EQUIPPED WITH LUMINATOR HORIZON LED SIDE DESTINATION SIGNS. THE CONNECTOR BOARD CAN CORRODE DUE TO AN ACCUMULATION OF MOISTURE UNDER THE CONNECTOR.
Consequence: A SHORT COULD OCCUR, POSSIBLY CAUSING SMOKE AND A FIRE.
Remedy: ORION WILL NOTIFY OWNERS AND THE BUSES WILL BE REPAIRED BY LUMINATOR FREE OF CHARGE. PLEASE SEE LUMINATOR'S DEFECT REPORT 09E-054. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2009. OWNERS MAY CONTACT LUMINATOR AT 1-972-516-3033 OR ORION AT...
View full details →Owner Complaints for the 2005 ORION V
No complaints have been filed with NHTSA for the 2005 ORION V.
Safety Rating for the 2005 ORION V
NHTSA has not yet tested the 2005 ORION V in its New Car Assessment Program.
Technical Service Bulletins for the 2005 ORION V
No technical service bulletins have been reported for this vehicle.
NHTSA Investigations for the 2005 ORION V
There are no NHTSA defect investigations on record for this vehicle.
Other Model Years of the ORION V
- 2000 ORION V — 1 complaint
- 2001 ORION V — 0 complaints
- 2002 ORION V — 2 complaints
- 2003 ORION V — 0 complaints
- 2004 ORION V — 0 complaints
- 2005 ORION V (current)
- 2006 ORION V — 0 complaints
- 2007 ORION V — 0 complaints
- 2008 ORION V — 0 complaints
Other ORION Models
- ORION VI — 5 total complaints
- ORION ORION — 3 total complaints
- ORION VII — 3 total complaints
- ORION I — 2 total complaints
- ORION II — 0 total complaints
- ORION ORION V — 0 total complaints
- ORION ORION VII — 0 total complaints
- ORION ORION VII LI-ION ESS — 0 total complaints