2002 NISSAN XTERRA Electrical Systemwiring Problems

TL* THE CONTACT OWNS A 2002 NISSAN XTERRA. WHILE DRIVING 50 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE WIRES UNDERNEATH THE STEERING COLUMN WERE BURNT. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 204,391.

VEHICLE: 2002 NISSAN XTERRA SE TAIL LIGHTS, FRONT SIDE MARKER LIGHTS, DASH PANEL ILLUMINATION FAILED DUE TO WIRE CHAFING BEHIND DRIVER'S SIDE FRONT MARKER LIGHT. THE BACK OF THE BULB SOCKET FOR THE FRONT SIDE MARKER LIGHT PINCHES IT'S CONNECTION WIRE AGAINST THE HEAD OF A 10MM SCREW LOCATED IMMEDIATELY BEHIND THE BULB SOCKET. THERE IS NOT ENOUGH CLEARANCE BETWEEN THE BULB SOCKET AND THE CHASSIS SCREW. THE SIDE MARKER LIGHT IS MOUNTED IN THE TOP EDGE OF THE FRONT BUMPER WHERE IT WRAPS AROUND THE SIDE OF THE VEHICLE. THE BUMPER MOVES UP AND DOWN WHEN THE ROAD SURFACE IS NOT SMOOTH, WHICH CAUSES THE WIRE TO BE RUBBED AGAINST THE HEAD OF THE CHASSIS SCREW, WHICH WEARS THE INSULATION FROM THE WIRE AND RESULTS IN AN ELECTRICAL SHORT BETWEEN THE DAMAGED WIRE AND THE FRAME OF THE VEHICLE. THE FRONT SIDE MARKER LIGHTS SHARE THE FUSE WHICH ALSO...

THE DASHBOARD LIGHTS, HEADLIGHTS ALL WENT OFF AT NIGHT WHILE THE VEHICLE WAS BEING DRIVEN. THE CONSUMER PULLED OFF THE ROAD, REPLACED A FUSE AND CONTINUED ON. ONE WEEKS LATER, THE FUSE BLEW AGAIN. THE DEALER FOUND THE RIGHT FRONT WIRING HARNESS MARKER WAS RUBBING AGAINST THE FRAME AND IT HAD SHORTED OUT. *NM *BF *NM

ALL PARKING LIGHTS, SIDE MARKER LIGHTS, AND INSTRUCMENT LIGHTS STOP WORKING. THE "TAIL LAMP" FUSE IN THE ENGINE COMPARTMENT IS BLOWN. *AK

I HAVE SERIOUS ELECTRICAL MALFUNCTION WITH MY 2002 NISSAN XTERRA. THE ELECTRICAL SHORT CAUSES MY AMP TO BLOW AND STEREO TO DIE. I HAVE BROUGHT MY TRUCK IN OVER 7 TIMES (*CURRENTLY IN DEALERSHIP'S SERV DEPT FOR EXACT SAME PROBLEM) AND MY TRUCK HAS BEEN "OUT OF SERVICE" FOR 23 DAYS (*CURRENTLY IN DEALERSHIP'S SERV DEPT AS WE SPEAK) SINCE THE PROBLEM ORIGINALLY OCCURRED.THERE HAS NEVER BEEN A PROBLEM FOUND W/IN MY ELECTRICAL SYSTEM OR STEREO, ONLY AMPS AND FUSES REPLACED (7 TIMES AND COUNTING).*AK

I PURCHASED A BRAND NEW 2002 NISSAN XTERRA VEHICLE IN NOVEMBER 2001. THE VEHICLE WAS PURCHASED AT THE PACIFIC NISSAN DEALERSHIP IN SAN DIEGO, CALIFORNIA. MY WIFE AND CHILDREN WENT ON AN OUTING ON EASTER SUNDAY. WHILE AT LUNCH, 5-15 MINUTES GO BUY AND A PERSON INQUIRES ABOUT A PARKED XTERRA ON FIRE. TO MY WIFE'S HORROR IT WAS OUR XTERRA WITH THE WIDOWS UP AND FLAMES/SMOKE COMING FROM THE DASH/STEERING COLUMN AREA. MY INSURANCE AND THE FIRE MARSHAL DETERMINED THE FIRE APPEARED TO BE AN ELECTRICAL SHORT/ARCHING AND NO OTHER APPARENT SOURCES OF IGNITION WERE PRESENT. THE VEHICLE WAS DETERMINED TO BE A TOTAL LOSS. I HAD THE VEHICLE TOWED TO PACIFIC NISSAN WHERE I PURCHASED IT AND HAVE MAINTAINED THEIR RECOMMENDED ROUTINE SERVICE. THE SERVICE MANAGEMENT QUESTIONED WHY THE VEHICLE WAS BROUGHT OVER TO THE SERVICE DEPARTMENT AND NOT TO THEIR BODY SHOP. I EXPLAINED THE BODY SHOP...