2022 NISSAN LEAF Fuelpropulsion System Problems

My Nissan Leaf 2022 Electric Vehicle(VIN: [XXX] ) is subject to Safety Recall 25V-655 (Manufacturer Recall Number R25C8) dated September 30, 2025. As per the recall notice, the vehicle suffers from 'excessive lithium deposits within battery cells' which can cause 'rapid heating of the battery' and result in a battery fire. The manufacturer has officially instructed me NOT to use Level 3 Quick Charging (CHAdeMO) until a remedy is completed. This restriction substantially impairs the use and value of the vehicle, as it eliminates the ability to use the car for long-distance travel, which is its primary intended purpose. It has been over 3 months since this recall was issued, and the status remains 'Remedy not yet available.' The manufacturer has failed to provide a timely repair for this fire risk. I am currently driving a vehicle that is a known fire hazard and has restricted utility. I request an...

This is related to NHTSA recall 25V-655: I am no longer able to DC fast charge my vehicle due to the recall related to charging and battery instability. This prevents me from using the car in the way that it was intended. I cannot drive more than 80 miles from my home in any direction. Less if I drive on the highway. This is not an acceptable situation for a vehicle. If a gas vehicle could not be refueled as it was designed, the vehicle would be replaced by the manufacturer. I have filed a request for buy back but the manufacturer has stated that there were not enough recalls built up on my vehicle to warrant a replacement or any compensation.

Nissan has informed Leaf owners that we cannot use DCFC to charge the car, there is a danger of fire from an overheating battery. This poorly designed battery management system severely limits the distance one can travel in the car. It has become an expensive short commute vehicle! Nissan offered to "repurchase" my car. The offer had over $27K deductions for milage and repayment of my $10k lien I would have to pay Nissan $2,800 for them to take the car back! Nissan should take full responsibility for the known recall and poor engineering.

The high-voltage battery on my 2022 Nissan Leaf is subject to Recall 25V655. The recall notice states that the battery cells can develop excessive lithium deposits, which increases electrical resistance and can cause rapid battery heating during Level 3 fast charging. Nissan instructs owners not to use Level 3 charging at all until a “remedy” is available. The issue is that the remedy described by Nissan is not an actual repair of the battery defect. Nissan states it will install software that monitors for “state-of-charge fluctuation” and, if detected, will prevent the vehicle from restarting or recharging in order to avoid a thermal incident. This means the defect inside the battery cells is still present, and the car may disable itself if the defect begins to appear. The recall materials also state there is no warning before overheating occurs. This creates multiple safety concerns: • The underlying battery defect remains...

I own a 2022 Nissan LEAF (VIN [XXX] ) that is subject to a Nissan safety recall advising owners not to use DC fast charging due to risk of battery overheating and fire. DC fast charging is a core function of an electric vehicle. Nissan’s instruction to avoid fast charging effectively removes this capability. In addition, some public charging networks have restricted or blocked Nissan LEAF fast charging, further limiting safe operation. Nissan has not provided a permanent repair. A proposed software update does not address the underlying physical battery risk and does not restore full charging functionality. As a result, the vehicle cannot be used as intended, and owners are left with reduced charging capability and increased safety uncertainty. I believe this defect presents an ongoing safety risk and warrants regulatory review. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

There has been a recall on my vehicle for months now, and previously there was a recall on other nissan leafs for over a year at this point before they branched out to include my vehicle. In the contract I signed to purchase my vehicle, I was stated to have access to tier 3 charging. I am unable to do that currently, and I do not live close to a tier 2 charger, so I am forced to use my tier 3 charging. They say not to do that, so I am left with a vehicle that I am unable to use, and have been for months. I iniated a buyback, but they declined it.

The vehicle is affected by manufacturer recall R25C8 (NHTSA 25V-655), which identifies a risk of battery overheating and potential fire during fast charging. The recall instructs owners not to use Level 3 (DC fast) charging because the vehicle’s battery system may enter a failsafe mode or experience thermal issues under high-load charging. This significantly restricts normal operation of the vehicle, especially for longer-distance travel, and raises concerns about battery safety during charging. The issue is ongoing, and no permanent remedy is currently available. The restriction on fast charging reduces the vehicle’s intended functionality and creates uncertainty about the safety of the high-voltage battery system. No collision or fire has occurred, but the condition remains unresolved. The vehicle remains available for inspection upon request.

The high-voltage battery on my 2022 Nissan Leaf is subject to Recall 25V655. The recall notice states that the battery cells can develop excessive lithium deposits, which increases electrical resistance and can cause rapid battery heating during Level 3 fast charging. Nissan instructs owners not to use Level 3 charging at all until a “remedy” is available. EVGO, one of the major lv3 chargers refuses service from customers with Leafs as well at this time, forcing me to rent a vehicle for long distance family trips this holiday season. The issue is that the remedy described by Nissan is not an actual repair of the battery defect. Nissan states it will install software that monitors for “state-of-charge fluctuation” and, if detected, will prevent the vehicle from restarting or recharging in order to avoid a thermal incident. This means the defect inside the battery cells is still present, and the car...

“2022 Nissan Leaf with 63,000 miles. Vehicle loses propulsion, unable to accelerate above 40 mph, and goes into turtle mode. Dealer opened the high-voltage battery and found multiple swollen modules. Nissan refuses to replace swollen modules and will only replace one cell despite EV system failure. Vehicle is unsafe to drive.”

The latest recall, NHTSA Recall 25v-655 for which there is no fix, has rendered my vehicle useless for any round-trip of more than approximately 130 miles from home. This is the same issue for which there was a recall for 2019/2020 LEAFs and after a year there was no known fix from the manufacturer.

High-voltage traction battery / propulsion system repeatedly malfunctions. First incident – Aug 2023 (~91,000 mi). Vehicle displayed “EV System No Power” with DTC P31E7. After parking, the car would not restart; I was stranded > 2 hours on a surface road until towed. Nissan dealer (Napleton St Louis) replaced a battery module under warranty and cited Nissan TSB NTB23-024 (bent retention plate in 62 kWh pack). Vehicle returned to service. Second incident – Apr 2024 (~128,000 mi). Same symptoms re-appeared: dashboard showed 200 mi remaining, but under moderate acceleration the range meter plunged to ~80 mi within seconds, but releasing the accelerator the range would go back up, but plunge again once accelerating again. the car gets less then the then half what the dash claims on a full charge, leaving me to not know what the full range truly is. Two dealerships have said I'm having the same issue...

in reduced traction environments vehicle will accelerate a full throttle without driver input to accelerator pedal. The issue is repeatable. though it seems to happen under multiple conditions. Vehicles acceleration is often opposite of the direction selected on shifter. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

On my 2022 Leaf I use the epedal system, which is supposed to operate as a one-pedal driving, meaning when you the car is in epedal mode, you can drive the car with one pedal. When you press the accelerator the car will move forward and when you let go of accelerator the car will come to a stop. However, sometimes the car does NOT come to a stop and it will coast as if the epedal is not engaged. This happens regardless of the batteries SOC (state of charge), weather, angle of the road, temperature, or road condition. When epedal is engaged and you lift off the accelerator, the car should always come to a stop, and it doesn't. This is dangerous because there have been many times where I have ran a stop sign or almost hit the car in front of me because I've had to slam...