1994 MITSUBISHI MONTERO Engine And Engine Coolingengine Problems

I SPENT $ 6000 LAST YEAR ON A NEW HALF BLOCK ENGINE. LAST MONTH MY MITSUBISHI MONTERO STALLED. I WAS ABLE TO GET IT TO THE DEALERS, AND THEY FOUND THAT THE PLENUM NEEDED TO GET CHECKED. THEY DID THAT, BUT NOW THEY FOUND THAT THE BUTTERFLY VALVES ON THE PLENUM BROKE OFF ( WHICH WERE PLASTIC) AND WENT IN TO THE ENGINE. THIS DAMAGED BOTH HEADS AND THEY NEED TO BE REPLACED FOR A COST OF $ 4700. MY PROBLEM IS, MITSUBISHI KNOWS THIS IS A PROBLEM (WHICH IS APPARENT BECAUSE THEY HAVE MADE A REPLACEMENT PART TO FIX IT), BUT BECAUSE THE REPLACEMENT PLENUM IS SO EXPENSIVE THEY NEVER DID A RECALL TO FIX IT. *AK

I WAS DRIVING MY MITSUBISHI MONTERO 3.5L DOHC WHILE TRYING TO JOIN FREEWAY ON RAMP WHILE ACCELERATING TO REACH 60 MILES AN HOUR TO KEEP IN PACE WITH HIGHWAY TRAFFIC. THEN ALL OF A SUDDEN THE VEHICLE SPEEDOMETER STARTED TO DECLINE DESPITE ME STEPPING ON THE GAS. AT THE SAME TIME I LOST POWER STEERING AND I NEARLY DIED DUE TO A POSSIBLE HIGH SPEED ACCIDENT WHILE TRYING TO CORRECT THE SITUATION AND GET OFF THE ROAD AT ONCE. I MANAGED TO DRIVE THE CAR AT VERY LOW SPEED TO THE NEAREST MECHANIC, AND IT DIED RIGHT IN HIS FRONT YARD. UPON EXAMINING IT HE TOLD ME THE CRANK SHAFT BOLT BROKE AND THATS WHY I LOST CONTROL OF THE VEHICLE. I ALSO CHECKED OUT IN THE INTERNET AT THIS SPECIFIC SITE: WWW.MITSUBISHISUCKS.COM/CARS/COMPLAINTS/USA/MODELS/MONTERO/1994.HTML. *AK I DISCOVERED THAT MITSUBISHI MONTERO RANGING FROM THE LATE 80S TO AS LATE AS 2002 ALL...

I WAS DRIVING ALONG, WHEN MY AIRCONDITIONING AND POWER STEERING WENT OUT. BELIEVING IT WAS A BELT, I LOOKED UNDER THE HOOD TO FIND OUT THAT MY CRANKSHAFT BOLT HAD BROKEN CAUSING MY KEYWAY AND HARMONIC BALANCER TO FALL OFF. I CALLED THE LOCAL MITSUBISHI DEALER TO LOCATE THE PARTS, AND THEY NOTIFIED ME THAT THE CRANKSHAFT BOLT WAS DEFECTIVE AND A NHTSA RECALL WAS IN PLACE ON IT. THEY THEN TOLD ME THAT THE BOLT WOULD BE REPLACED AS WELL AS ANY SUBSEQUENT DAMAGE CAUSED BY THE BREAKING OF THE BOLT. THE DEALER HAS NOW CALLED ME BACK, AND SAID THAT THEY WERE HAVING TROUBLE REMOVING THE BROKEN BOLT FROM THE CRANKSHAFT AND HAD ALREADY SPENT TO MUCH TIME AND MONEY, AND SO THEREFORE WOULD NOT CONTINUE ANY WORK. IF I WANTED THE VEHICLE FIXED, IT WOULD BE ON MY DIME, THEY WERE NOT GOING TO HONOR THE SAFETY...

THE HARMONIC BALANCER HAS CAME APART TWICE. THE MECHANIC THAT I WAS HAS STATED THAT THIS IS DUE TO THE CRANKSHAFT BOLT COMING LOOSE. THIS PARTICULAR BOLT HAS BEEN RECALLED ON THE 3.5 L MONTERO ENGINES, BUT NOT THE 3.5 L ENGINES. *AK

POWER STEERING SUDDENLY FAILED WHILE MY WIFE WAS EXITING THE FREEWAY ALMOST CAUSING A SERIOUS ACCIDENT. A MECHANIC DETERMINED THAT THE CRANKSHAFT PULLEY FELL OFF. THERE IS A RECALL (CAMPAIGN ID # 00V311001) BUT MITSUBISHI STATES THAT MY MONTERO IS NOT INCLUDED IN THE RECALL FOR SOME UNKNOWN REASON, EVEN THOUGH MY VEHICLE EXPERIENCED THE SAME PROBLEM AS THE RECALL STATES.*AK

VEHICLE HAD BEEN HAVING SAME PROBLEM A S STATED IN RECALL 00 V 311 001 CONCERNING CRANKSHAFT/PULLEY BOLT.*AK

DEALER SAID THATPOSSIBLE CAUSE OF ENGINE FAILURE IS LOOSE WRIST PIN IN CRANKSHAFT ASSEMBLY AND THAT MITSUBISHI CORP. DOES NOT HAVE RECALL ON THIS AND NOT CONSIDERED AS FACTORY DEFECT. NEED NEW ENGINE BUT MITSUBISHI MADE THIS TYPE ONLY FOR 3 YEARS AND NONE AVAILABLE EVEN FOR USED OR REMANUFACTURED ENGINE. ACCORDING TO 2 USED/REMANUFACTURED ENGINE DEALERS (1 FROM MIDWEST AND 1 FROM BALTIMORE), FINDING A USED ENGINE IS VERY HARD BECAUSE SO MANY OWNERS WITH SAME PROBLEM ARE LOOKING FOR ONE. THE 3.5 LTR. DOUBLE OVERHEAD CAM ENGINE IS A PROBLEM ENGINE THAT IS WHY MITSUBISHI STOPPED PRODUCING IT AFTER ONLY 3 YEARS BECAUSE OF THE HEADACHES ON IT. IT HAS ALREADY BEEN A MONTH AND STILL NO ENGINE AVAILABLE EITHER USED OR REMANUFACTURED WITHIN THE US. ACCORDING TO AN ENGINE DEALER, THERE ARE 3 OF US WAITING FOR AN ENGINE IN MARYLAND. MITSUBISHI SHOULD BE HELD ACCOUNTABLE FOR...