2004 MINI COOPER Steering Problems

POWER STEERING WHEEL GOES ON AND OFF. WHEN I TURN THE WHEEL I CAN FEEL IT GO FROM HEAVY RESISTANCE TO REGULAR IN SECONDS, WHICH HAS BEEN MORE THAN ONCE IN A DAY. IF THERE IS A CAR COMING FROM THE OPPOSITE DIRECTION, IT COULD EASILY CRASHED INTO MY SIDE. DUE TO THIS SUDDENLY WHEEL MALFUNCTION, I HAD TO SLOW DOWN BECAUSE I WAS AT THE CORNER OF THE ROAD, TRYING TO TURN. THIS IS SO DANGEROUS, AND IT WILL ONLY TAKE SECONDS TO KILL PEOPLE IN THIS SITUATION. I DID RESEARCH ONLINE AND FOUND OUT THIS IS A PRETTY COMMON ISSUE FOR THE MINI COOPER. *TR

2004 MINI COOPER, COUPE HAS INTERMITTENT POWER STEERING, WHICH BEGAN SUDDENLY ON A CIRCULAR FREEWAY ON RAMP AT ABOUT 40MPH, DURING WHICH I NEARLY LOST CONTROL OF THE CAR. THE FAILURE SEEMS TO BE TRIGGERED BY U TURNS (ROUND-ABOUT, SPIRAL RAMPS, MANEUVERING OUT OF A SMALL PARKING SPACE.) I HAVE HAD THE POWER STEERING PUMP INVESTIGATED AS THE CAUSE AND IT IS WORKING NORMALLY. I BELIEVE IT IS A PROBLEM WITH EITHER THE COMPUTER OR STEERING ASSEMBLY. IT IS POSSIBLE TO DRIVE THE CAR WITH THE FAILED POWER STEERING, BUT QUITE DISCONCERTING WHEN IT FAILS IN THE MIDDLE OF A TURN. I AM STILL DRIVING THE CAR - BUT CAREFULLY. UPDATE - WHILE DRIVING THE CAR THIS MORNING, THE POWER STEERING SUDDENLY FAILED ON A CURVE AT 50 MPH. I MOMENTARILY LOST CONTROL, BUT REGAINED IT WITHOUT ACCIDENT. THE POWER STEERING BECAME FUNCTIONAL AGAIN WITHIN ABOUT 100 YARDS OF DRIVING....

TL*THE CONTACT OWNS 2004 MINI COOPER. WHILE THE CONTACT WAS DRIVING APPROXIMATELY BETWEEN 25 TO 30 MPH, THERE WAS A SLIGHT LOSS OF POWER STEERING WITHOUT WARNING. THE FAILURE WAS A CONTINUOUS OCCURRENCE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 70,441 UPDATED 02/01/11*LJ THE POWER STEERING PUMP HAD TO BE REPLACED. 03.22.11

THE POWER STEERING IN MY 2004 MINI COOPER BEGAN MALFUNCTIONING LAST YEAR. THIS MAKES IT DIFFICULT TO STEER AND CONTROL THE VEHICLE. IT MALFUNCTIONS EVERY TIME I DRIVE THE CAR, THE PUMP STOPS WORKING A FEW MINUTES OR IMMEDIATELY AFTER I START THE ENGINE. I HAVE NOT HAD AN ACCIDENT DUE TO THE MALFUNCTION, BUT ONE COULD BE POSSIBLE, IF I WERE TO HAVE TO MAKE A SHARP TURN AT A MOMENT'S NOTICE. SINCE THIS PART IS A DEALER ONLY PART, IT IS EXTREMELY EXPENSIVE AND I HAVE NOT BEEN ABLE TO AFFORD IT SINCE I WAS LAID OFF LAST YEAR. HELP! *TR

TEMPORARY LOSS OF POWER STEERING. HAPPENS PROBABLY ONCE OR TWICE A MONTH. I HAVE BEEN TOLD BY THE DEALER THAT I HAVE A POWER STEERING LEAK - BUT NOT BAD ENOUGH TO CAUSE A PROBLEM. I HAVE NEVER LOST A QUANTITY OF FLUID THAT REQUIRED REFILLING. CAR HAS APPROXIMATELY 70K MILES - SEEMS ODD TO HAVE A POWER STEERING LEAK AT THAT MILEAGE. LEAK FIRST SHOWED UP AT ABOUT 50K MILES. *TR

WHILE DRIVING MY 2004 MINI COOPER, THE POWER STEERING ASSISTANCE SUDDENLY DISAPPEARED. THE LOSS OF POWER STEERING MADE THE VEHICLE DIFFICULT TO STEER/CONTROL AT SLOW SPEEDS. THE PROBLEM WAS SOLVED BY REPLACING THE POWER STEERING PUMP. *TR

TEMPORARY LOSS OF STEERING. *TR

I HAVE A 2004 MINI COOPER AND I TOO HAVE HAD MY POWER STEERING FAIL ON CURVES WHILE DRIVING THIS HAPPENS A LOT WHEN I TURN THE WHEEL ON SHARP CURVES AND PARK. IT COSTS ABOUT 850 DOLLARS TO REPLACE THE POWER STEERING PUMP AT THE DEALER AND I AM UNEMPLOYED AT THE MOMENT AND CANNOT AFFORD THIS COST. *TR

DEAR NHTSA, OUR COMPLAINT MATCHES THE NHTSA INVESTIGATION BEING CONDUCTED REGARDING THE INTERMITTENT POWER-LOSS OF THE POWER STEERING PUMP OF THE 2004-5 MINI COOPER WE OWN A 2004 MINI COOPER. OUR POWER STEERING LOSS BEGAN FEB '10 AND DESCRIBED AS UNEXPECTED AND INTERMITTENTLY-OCCURRING TOTAL LOSS-OF-ASSIST TO STEERING. THIS WAS RECTIFIED BY A PURCHASE OF A NEW POWER STEERING PUMP FROM MINI COOPER (ELMSFORD, NY) AND PURCHASE OF LABOR (INSTALLATION) FROM STRAUB AUTO REPAIR (HASTINGS ON HUDSON, NY) DURING THAT MONTH. *TR

I OWN A 2004 MINI COOPER. I STARTED THE CAR LAST WEEK AND THE POWER STEERING PUMP WAS MAKING A VERY HIGH PITCHED SQUEALING NOISE. I DECIDED TO DRIVE ANOTHER CAR THAT DAY BECAUSE I DID NOT HAVE ENOUGH TIME TO BRING IT TO A MECHANIC. THE NEXT DAY I STARTED THE CAR AND THE PUMP CAME UP TO SPEED VERY SLOWLY AND THEN STOPPED MAKING NOISE ALTOGETHER. THE POWER STEERING NO LONGER WORKS. I DON'T THINK I CAN SAFELY DRIVE IT TO THE MECHANIC AND THE CAR HAS SAT IN THE DRIVEWAY SINCE. THE CAR IS OUT OF ITS WARRANTY PERIOD SO I WOULD BE LOOKING AT THE EXPENSE OF TOWING AND PARTS AND LABOR BEFORE I CAN USE IT AGAIN. I JUST SAW THE REPORT ON CNBC AND WAS WONDERING IF THIS IS A COMMON PROBLEM BEFORE I CONTACT A GARAGE. THANK YOU. *TR

2004 MINI COOPER. POWER STEERING PUMP FAILED AT HIGH SPEED WHILE DRIVING ON WINDY ROAD AT NIGHT. WAS ABLE TO OVER CORRECT AND SLOW VEHICLE SAFELY. HAD IT BEEN MY DAUGHTER DRIVING SHE MAY HAVE CRASHED. PUMP FAILED WITHOUT WARNING AND NO ENGINE LIGHTS. AFTER LOOKING INTO THIS ISSUE IT SEEMS THAT A LOT OF SIMILAR INCIDENTS HAVE OCCURRED WITH NEW MODEL CARS WITH LESS THAN 50K MILES. SHOULD BE A RECALL TO BMW FOR THIS!!!! *TR

CAR IS VERY NOISY ON COLD STARTS WHEN TURNING THE STEERING WHEEL. STEERING WOULD JUDDER WHEN BEING TURNED. WHEEL WILL FEEL HEAVY AND STUCK AT TIMES. POWER STEERING RESERVOIR WAS EMPTY WITH NO SIGNS OF LEAKS. POWER STEERING FLUID FLOODED INTO STEERING RACK DUE TO FAILED SEAL. STEERING RACK NEEDED REPLACEMENT. *TR

DRIVING ON THE HIGHWAY AND THE POWER STEERING FAILED FOR NO APPARENT REASON. CAR HAD JUST BEEN INSPECTED AND THERE WERE NO OTHER MECHANICAL OR ROAD HAZARD ISSUES BUT I ALMOST COLLIDED WITH A VEHICLE BECAUSE THE STEERING WHEEL FROZE. IN ACTUALITY, IT REQUIRED A GREAT DEAL OF STRENGTH--UNEXPECTEDLY SO IT FELT FROZEN. *TR

1. AN HOUR INTO A HIGHWAY DRIVE, ALL THE ELECTRICAL FAILED. ALL LIGHTS, GAUGES, RADIO, ETC. ALL BUT THE POWER STEERING RETURNED IN A MOMENT, LESS THAN A SECOND. 2. THE POWER STEERING DOES NOT WORK. 3. POWER STEERING PUMP INTERNAL ELECTRONICS AREA SHOWS SIGNIFICANT SCORCHING AND MELTING. PUMP WAS REPLACED BUT POWER STEERING SYSTEM STILL INOPERABLE. THE OLD PUMP IS AVAILABLE. *TR

2004 MINI COOPER. CONSUMER STATES WHILE DRIVING POWER STEERING MALFUNCTIONED. *TGW

TL* THE CONTACT OWNS A 2004 MINI COOPER. WHILE DRIVING AT APPROXIMATELY 35 MPH, THE CONTACT NOTICED STEERING BECAME EXTREMELY DIFFICULT. AFTER THE INITIAL FAILURE, THE STEERING PROBLEMS BECAME INTERMITTENT. THE VEHICLE IDENTIFICATION NUMBER WAS UNAVAILABLE AT THE TIME OF THE COMPLAINT. THE CURRENT MILEAGE WAS APPROXIMATELY 78,000. THE FAILURE MILEAGE WAS APPROXIMATELY 65,000.

POWER STEERING SUDDENLY CUT OUT DURING NORMAL DRIVING CONDITIONS IN DOWNTOWN SAN FRANCISCO, MAKING IT VERY DIFFICULT TO STEER. DRIVER WAS ABLE TO BRING THE CAR TO A STOP SAFELY, BUT THIS FAILURE COULD HAVE CAUSED AN ACCIDENT HAD IT OCCURRED ON A CURVING ROAD. THE POWER STEERING PUMP WAS DETERMINED TO HAVE FAILED, AND WAS REPLACED BY THE CONSUMER, FOR A REPAIR COST OF CLOSE TO $700. THE POWER STEERING PUMP IS NOT SUPPOSED TO FAIL THIS EARLY IN THE LIFETIME OF A VEHICLE.

2004 MINI COOPER- 50K MILES- POWER STEERING FAN / MOTOR FAILURE LEADING TO ELECTRICAL SYSTEM MALFUNCTION, HEAT/FIRE DAMAGE RESULTING IN INABILITY TO TURN OFF ENGINE. *TR

TL*THE CONTACT OWNS A 2004 MINI COOPER. WHILE DRIVING 15-20 MPH, THE POWER STEERING SUDDENLY FAILED. THE CONTACT HAD TO PULL THE VEHICLE OVER. A DIAGNOSTIC HAS NOT BEEN PERFORMED TO DETERMINE THE CAUSE OF THE FAILURE. THE FAILURE MILEAGE WAS 37,640.

POWER STEERING FAILED SOON AFTER STARTING. THE CAR HAD BEEN OUTSIDE ON A COLD DAY, BUT NOT UNUSUAL (~20 DEGREES F). IT FUNCTIONED AGAIN WHEN RE-STARTED. *TR

WHILE DRIVING ON THE FREEWAY MY POWER STEERING PUMP DIED I COULD HARDLY CHANGE LANES ON THE FREEWAY, IT FELT LIKE MY STEERING WHEEL HAD LOCKED, TURNING IN ANY ANGLE WAS VERY HARD WORST THAN DRIVING A TRUCK, I KEPT A FIRM GRIP WITH ONE HAND WHILE TRYING TO CONTROL THE GEARS, MY ARMS, BACK, AND HAND IS STILL HURTING, HAD NO WARNING SIGNALS, IT WHEEL JUST LOCKED UP AND WAS VERY HARD TO MANAGED I WASNT ABLE TO HANDLE THE CAR DID NOT FEEL SAFE, DID NOT HAVE FULL CONTROL OF HANDLING THE STEERING THIS IS SERIOUS PROTENTIAL ACCIDENT WAITING TO HAPPEN I CALLED THE DEALER AND WAS TOLD THAT THERE WERE RECALLS BUT NOT FOR MY VIN 2004. MY MINI IS NOW IN THE REPAIR SHOP TO HAVE THE PUMP REPLACE AND THE FAN. THIS IS A DEADLY ISSUE AND MINI SHOULD RECALL AND PAY FOR THIS PROBLEM...

APPROXIMATELY ONE MONTH AGO I WAS ON ORTEGA HIGHWAY IN SOUTHERN CALIFORNIA WITH MY CHILD IN THE BACK SEAT. AS I WAS MANEUVERING THE MINI ALONG THE CURVY ROAD THE POWER STEERING WENT OUT. FORTUNATELY I HAD GOTTEN THROUGH THE WORST OF THE HAIR PINS AND WAS GOING SLOWER THAN THE SPEED LIMIT ETC. SUDDENLY THE STEERING BEGAN TO WORK AGAIN. MY HUSBAND WAS INFORMED BY A MECHANIC THAT IT WAS THE POWER STEERING FAN. WE HAD IT REPLACED AND IT SEEMED OKAY. ON NOVEMBER 26TH I HAD MY CHILDREN IN THE CAR GOING TO MY SISTERS I WENT TO MAKE A LEFT HAND TURN AND THE CAR DIDN'T WANT TO TURN. THE POWER STEERING FAILED AGAIN. I WAS FORTUNATE ONCE AGAIN AS THERE WAS NO ON COMING TRAFFIC BECAUSE IF THERE WAS I WOULD HAVE HAD A HEAD-ON COLLISION. THERE ARE NO WARNING LIGHTS FOR THIS ISSUE AND I...

I BOUGHT A USED 2004 MINI COOPER LAST YEAR. UNDER CERTAIN CONDITIONS ON A CURVY ROAD THE POWER STEERING PUMP WOULD GET VERY HARD TO TURN THE WHEEL, ESPECIALLY IN A SHARP CURVE. WITH NO DEALERSHIPS WITHIN 150 MILES I PUT UP WITH IT. NOW IT STAYS ON ALL THE TIME AND CANNOT BE DISCONNECTED WITHOUT TAKING THE BATTERY CABLE OFF THE BATTERY. IT RUINED 2 BATTERIES BEFORE I REALIZED IT WAS STAYING ON 24 HOURS A DAY. I BOUGHT THE REPAIR BOOK AND WIRING DIAGRAM CD'S TO FIND IT IS STRAIGHT WIRED FROM BATTERY TO INSIDE THE PUMP WHICH GLOWS BRIGHT RED AFTER RUNNING A FEW HOURS. IF I HAD ANY TYPE OF OIL LEAK, IT WOULD CATCH ON FIRE. I CONTACTED A REPAIR CENTER IN ATLANTA GA AND THEY CAN CHANGE IT OUT FOR ABOUT $1000+ FOR THE POWER STEERING PUMP AND THE OPEN FACED FAN THAT CAUSED...

POWER STEERING WENT OUT IN EARLY 2008. LUCKILY THE CAR WAS PARKED WHEN THAT HAPPENED OR ELSE IT WOULD HAVE BEEN A DISASTER SINCE MINI STEERING WHEEL IS ALREADY HEAVIER THAN OTHER CARS. HAD IT FIXED (REPLACED) AT THE DEALERSHIP AND HAD TO PAY AROUND $1000 SINCE THE WARRANTY EXPIRED. IT'S UNACCEPTABLE THAT THE STEERING POWER PUMP DIED THIS EARLY ONLY AFTER 4 YEARS. IT'S A RIPOFF FOR THE CONSUMERS. SOMETHING MUST BE DONE ABOUT THIS. A FEW MONTHS LATER, THE STEERING COLUMN AND THE LOWER SHAFT STARTED TO HAVE ISSUES AS WELL. THEY STARTED TO MAKE CREAKING NOISES. TOOK THE CAR TO THE DEALERSHIP AND THEY QUOTED AT ALMOST $1000 TO REPLACE THE PARTS. THE STEERING COLUMN AND POWER PUMP SHOULD NOT HAVE TO BE REPLACED AFTER ONLY FOUR YEARS! *TR

AT FIRST MY BATTERY DIED AFTER I CAME OUT OF WORK. I COULDN'T UNDERSTAND WHY SINCE I DIDN'T LEAVE ANYTHING ON. SO I GOT THE BATTERY REPLACED FOR $200. RECENTLY THE STEERING HAS BEEN CUTTING OUT WHILE DRIVING. IF YOU PULL OFF INTO A PARKING LOT AND TURN OFF THE CAR YOU CAN STILL HEAR THE COOLING FAN GOING. AFTER APPROX 30 MIN THE POWER STEERING WILL RETURN TO NORMAL UNTIL IT OVERHEATS AGAIN. SO MY BATTERY WAS BEING DRAINED BY THE POWER STEERING COOLING FAN. *TR

POWER WINDOW ON PASSENGER SIDE COMES DOWN ONLY SOMETIMES AND SOMETIMES IT DOESN'T WORK FOR WEEKS. STEERING IS MAKING NOISES. *TR

THE POWER STEERING PUMP ON MY 2004 MINI COOPER HAS FAILED. I BELIEVE THAT THIS FAILURE MADE THE CAR DANGEROUS TO DRIVE. THE CAR IS A LOW-MILEAGE VEHICLE (43,000 MILES AT 4 YEARS) AND I BELIEVE THIS COMPONENT HAS FAILED PREMATURELY. I AM A MEMBER OF SEVERAL MINI ENTHUSIAST COMMUNITIES AND AM AWARE THAT THIS IS A COMMON PROBLEM WITH THE MINI. WWW.MINI2.COM HAS REPORTS OF AROUND 1 IN 4 VEHICLES HAVING THIS PUMP FAIL PREMATURELY. I BELIEVE AN INVESTIGATION IS IMPORTANT DUE TO MEMBER REPORTS OF FIRES STARTING UNDER THE HOOD. THE PART WAS REPLACE AT A MINI DEALERSHIP. *TR

I HAD DRIVEN 2004 MINI FOR ABOUT 30 MINUTE, THEN PARKED IT IN DRIVEWAY. WITHIN 15 MINUTES I LOOKED OVER TO SEE SMOKE COMING FROM THE ENGINE. I OPENED THE COMPARTMENT AND GOT HELP. WE PUSHED IT INTO A NEARBY FIELD AND CALLED THE FIRE DEPT. IF IT HAD STAYED IN THE DRIVE, IT WOULD HAVE ALSO IGNITED 2 CARS, THE HOUSE AND A BOAT. WHO KNOW ABOUT PEOPLE AND ANIMALS. I ALMOST GOT RUN OVER TRYING TO STOP THE MINI AS IT WAS PUSHED. AFTER THE CAR WAS OUT, WE HAD IT TOWED TO INSKIP AUTO IN WARWICK RI. JEOF SAID AT FIRST IT WAS A POWER STEERING HOSE THAT BURST AND GOT ON THE HOT EXHAUST...IGNITING. AFTER LOOKING AT IT FURTHER AND WITH METLIFE INSURANCE AGENT, THEY THOUGHT IT WAS THE POWER STEERING FAN AND PUMP FAILURE. THIS OVERHEATED THE ELECTRICAL HARNESS, TO START THE ELECTRICAL FIRE. NEITHER...

I HAVE A 2004 MINI COOPER WITH ABOUT 61000 MILES, AND HAVE RECENTLY EXPERIENCED PROBLEMS WITH THE POWER STEERING. IT WAS A VERY SCARY SITUATION AS THE STEERING LOCKED AS I WAS DRIVING ON A LOS ANGELES FREEWAY AT A HIGH SPEED. THERE IS NO WARNING INDICATION, AND THERE IS DEFINITELY A POTENTIAL DANGER. *TR