2002 MINI COOPER Power Trainmanual Transmission Problems

I ALWAYS MAINTAINED MY 2002 MINI COOPER AND AT 80K MILES THE TRANSMISSION BLEW UP JUST BEFORE I WAS TO ENTER A VERY BUSY FREEWAY IN LOS ANGELES, DOWNTOWN AREA. THERE WAS PLENTY OF OIL IN THE TRANSMISSION. I WAS TOLD IT WAS NOT A FAULT OF MY CARE AFTER THE MECHANIC LOOKED AT IT UPON TOW IN. IT JUST STOPPED FAST AND SHORT WITH A HUGE JERK FORWARD AND EXPLOSIVE NOISE. THE MECHANIC SAID IT BLEW IN BIG CHUNKS. I COULDN'T MOVE IT FROM TRAFFIC IN NEUTRAL AND HAD IT TOWED TO THE SHOP. 80K IS EARLY FOR SOMETHING LIKE THIS AND I SEE MANY PEOPLE ARE REPORTING THIS HAPPENED WITH EVEN LESS MILEAGE, 34K, 48K ...NO REPLACEMENTS AND SO MANY FAILURES LIKE THIS? MINI TURNS THEIR HEADS; WOULD NOT REPLACE OR EVEN TALK TO ME. PREVIOUSLY TOO THE POWER STEERING PUMP ALSO JUST STOPPED AND NO MOVEMENT ON...

SUDDEN FAILURE OF THE MANUAL 5 SPEED TRANSMISSION CAUSING CAR TO COME TO A SUDDEN STOP IN AN INTERSECTION, ENDANGERING THE DRIVER AND BLOCKING TRAFFIC. SOMETHING INTERNAL FAILS IN THE TRANSMISSION, CAR COMES TO T SUDDEN STOP, CANT BE PUSHED AS THE WHEELS LOCK UP AND MUST BE TOWED FROM THE ROAD. APPEARS TO BE A COMMON PROBLEM ON MESSAGE BOARDS ON THE WEB. TRANSMISSION MUST BE REPLACED. *TR

TRANSMISSION BEARINGS FAILURE AFTER 82,000 MILES. NO BEARINGS KIT REPLACEMENT OFFERED. *TR

PURCHASED A USED 2002 MINI COOPER ABOUT 3 1/2 YRS AGO W/ ABOUT 12K MILES. AT AROUND 15-17K MILES THE TRANSMISSION BASICALLY EXPLODED WHILE I WAS ON THE HIGHWAY. I WAS TOLD THAT THERE WAS A CRACK IN THE TRANSMISSION. MINI REPLACED IT WITH I'M GUESSING A REBUILT TRANSMISSION. AT THE TIME OF THE REPAIR I ASKED THEM IF THEY WERE PUTTING IN A NEW CLUTCH AND THEY SAID NO, WHICH I FOUND STRANGE. NOW AT 60K MILES THE CLUTCH IS BASICALLY DONE. WHEN THE CAR IS COLD IT SHIFTS PRETTY NORMALLY, BUT AFTER 15-25 MINUTES OF DRIVING THE FIRST TWO GEARS BECOME HARD TO ENGAGE AND THEY SLIP. THIS IS NOT MY FIRST FIVE SPEED AND I'M SHOCKED THAT THIS CLUTCH IS DONE AFTER SUCH LITTLE MILEAGE. SHOULD THEY HAVE REPLACED THE CLUTCH WHEN THEY REPLACED THE TRANSMISSION? I'M NOT A MECHANIC BUT TO LOSE A CLUTCH AT 60K...

CLUTCH AND CABLES FAIL AT 100 000KM. RATTLING NOISE AT START UP. VERY LOUD HUMMING NOISE COMING FROM THE STEERING. TRANSMISSION GONE AT 103 000KM. *TR

THE WARRANTY ON MY 2002 MINI COOPER RAN OUT AT 50K MILES. AT 53K MILES THE TRANSMISSION FAILED AND HAD TO BE REPLACED WITH A REBUILT TRANSMISSION FROM MINI. THE TOTAL COST OF THE REPAIR WAS $4,200. I HAVE BEEN IN CONTACT WITH MANY OTHER PEOPLE WHO ARE SUFFERING THE SAME FATE BECAUSE MINI WILL NOT TAKE RESPONSIBILITY FOR THEIR FAULTY TRANSMISSIONS. *TR

TRANSMISSION BLEW AT 34 THOUSAND MILES. *TR

I HAVE A 2002 MINI COOPER WITH 52K MILES, THE TRANSMISSION HAS WENT OUT TWICE IN THE PAST 2 YEARS THE FIRST TIME AT 31K MILES. THE CLUTCH HAS ALSO WENT OUT AS WELL AS THE SUNROOF MOTOR, LEFT FRONT BRAKE CALIPER, WINDSHIELD WIPER MOTOR WITH A HOST OF SENSORS, GAUGES ETC... PARTS ARE IMPOSSIBLE TO GET AND SERVICE ON A 24K CAR (WHEN NEW) IS AS MUCH AS MY 70K BMW 7 SERIES.*CN

I PURCHASED A PRE-OWNED MINI COOPER WITH 34,000 MILES ON IT. 5-SPEED TRANSMISSION. SHORTLY AFTER PURCHASE, I NOTICED A "STUDDER/HESITATION" ON TAKE OFF FROM A DEAD STOP IN FIRST GEAR. THIS HAPPENED ABOUT A DOZEN TIMES. I TOOK IT TO MY MECHANIC TO DEMONSTRATE THE PROBLEM. ON THE TEST DRIVE, THE CAR MADE A LOUD GRINDING NOISE AND ALL GEARS FAILED. THE CLUTCH AND GEAR SHIFT FELT NORMAL, BUT NO GEAR WOULD ENGAGE. THE CAR WAS ROLLING BACKWARDS DOWN A HILL INTO ONCOMING TRAFFIC. IT WAS TOWED TO THE LOCAL MINI DEALERSHIP WHERE IT WAS DETERMINED THAT THE TRANSMISSION HAD FAILED. AT THAT POINT THE CAR HAD 35,000 MILES ON IT. BECAUSE IT WAS 4 MONTHS OUT OF WARRANTY, MINI REFUSED TO PAY FOR THE REPAIR. I FOUND NUMEROUS ACCOUNTS OF THE MIDLAND TRANSMISSIONS BEING REPLACED UNDER WARRANTY. I WAS INFORMED THAT MY CAR RECEIVED THE NEWER GETRAG TRANSMISSION BECAUSE...

2002 MINI COOPER CLUTCH AND TRANSMISSION FAILURE AT 68,000 MILES. NM

CAR STALLS RANDOMLY WHEN COMMING TO A STOP. THIS HAPPENS ON ON MANUEL TRANSMISSION. WHEN DEPRESSING THE CLUTCH IT REVS DOWN AND IDOLS LOW AND STALLS WHEN APPROAHING A STOP. AFTER AN INITAL STALL POWER IS REDUCED AND IS SLUGGISH WHEN THE GAS IS DEPRESSED.*AK