2006 MINI COOPER S Fuelpropulsion System Problems

THERE IS A CONSTANT FUEL / GASOLINE SMELL IN MY CAR AND OUTSIDE THE VEHICLE. NO VISIBLE LEAKS. THE SMELL IS CONSTANT.

TL* THE CONTACT OWNS A 2006 MINI COOPER S. WHILE DRIVING 65 MPH, THE FUEL SENSOR GAUGE MALFUNCTIONED. THE CONTACT STATED THAT THE VEHICLE RAN OUT OF FUEL, BUT THE GAUGE INDICATED THAT THERE WAS 74 MILES LEFT IN THE FUEL TANK. TEMPE MINI, LOCATED AT 7855 SOUTH TEST DRIVE, TEMPE, ARIZONA 85284, WAS MADE AWARE OF THE FAILURE AND STATED THAT THE FUEL PUMP, FUEL HOUSING, AND FUEL SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 127,000. THE VIN WAS NOT AVAILABLE.

BLUE BLACK SMOKE FROM FRONT GRILL OF WARM (20 MILES) DRIVEN CAR. CAR WAS OFF AND PARKED IN HIGHWAY 40 MCDONALDS RESTAURANT PARKING LOT NEXT TO A 10,000 GALLON HEATING FUEL TANK. PARKER FUEL COMPANY EMPLOYEES PUT OUT THE FIRE IN THE ENGINE COMPARTMENT JUST BELOW THE ENGINE. NOTE THE BATTERY WAS DISCONNECTED IMMEDIATELY BEFORE OPENING THE BONNET/HOOD AT WHICH TIME THE SMOKE AND VISIBLE FLAME WAS EXTINGUISHED 5 TIMES VIA 1 SMALL (DEPLETED) AND 3 TIMES ENDING VIA A 2ND LARGER PARKER FUEL COMPANY UNIT. HOWARD COUNTY FIRE AND POLICE VEHICLES ARRIVED AFTER FIRE HAD ENDED. CAR SEEMED NORMAL OVER 20 MILE PORTION OF TRIP ON HIGHWAY 70 + 40 @ 70 + 55 MPH SPEEDS. FLAME COULD BE VIEWED ORIGINATING UNDER ENGINE WHEN LOOKING DOWNWARD IN SPACE BETWEEN ENGINE AND FIREWALL BELOW EXHAUST MANIFOLD. NOT SURE IF FIRE WAS FROM POWER STEERING PUMP DRIVE (ELECTRIC MOTOR), POWER STEERING...

AS I TURN ON THE ENGINE, BATTERY LIGHT CAME ON, 5 SECONDS LATER, ENGINE STARTED TO SMOKE. I TURNED OFF THE ENGINE. ENGINE WON'T TURN BACK ON AND LOST ALL POWER, STEERING WHEEL WON'T TURN. BEFORE THIS INCIDENT, GEAR WOULD SHIFT UP AND DOWN ON IT'S OWN WHILE I'M DRIVING. VERY DANGEROUS! *TR