1991 MERCURY COUGAR Engine And Engine Coolingengine Problems

THIS IS THE SECOND TIME IT HAS HAD A BLOWN HEAD GASKET. IT IS NOT FIXED YET BECAUSE I CAN'T AFFORD IT. *NM

VEHICLE WAS ACTING SLUGGISH AND WHITE MOKE CAME FORM TAILPIPE. VEHICLE WAS GOING 35MPH AND OVERHEATED, CAUSING DRIVER TO PULL OVER. CONSUMER INDICATED THAT CONTINUING TO DRIVE WILL CAUSE HEAD TO WARP. DEALER WAS NOTIFIED. *AK *TT

CONSUMER COMPLAINS OF HEAD GASKET FAILURE. *JG

CONSUMER COMPLAINS OF HEAD GASKET FAILURE. *JG

WHILE DRIVING 15-20 MPH VEHICLE BEGAN TO OVERHEAT, CONSUMER PULLED INTO SERVICE STATION TO HAVE VEHICLE INSPECTED, THE SERVICE MECHANIC STATED THAT THE HEAD GASKETS HAD BLOWN. DEALER HAS YET TO BE CONTATCED. PLEASE PROVIDE FURTHER DETAILS. *AK

HEADLIGHTS GO OFF WHILE DRIVING, BRAKES CONTINUE TO MAKE NOISE, KEY SWITCH PROB. RECALL REPAIR, HEATER BLOWS COLD, CAR DIED AFTER EXCEL. RESTARTED AND DROVE 50 FT. DIED AGAIN AND KNOW IN SHOP & BEEN TOLD GASKETS OR BUSTED HEAD. I LOVE THIS CAR AND HAVE TAKEN EXTRA CARE, ENGINE AND CAR KEEP SPOTLESS, CAR IS NEVER LEFT OUTSIDE. ALL TOOK PLACE WITHIN 1 MO. IS IT ALL TIED TOGETHER WITH ONE THING? *AK

WHEN CONSUMER TOOK VEHICLE TO DEALER FOR CHECK UP,TECHNICIAN FOUND THAT ENGINE HAD A BLOWN HEAD GASKET WICH HAPPENED WITHOUT A WARNING. *AK

ENGINE HEAD GAKSET NEEDED TO BE REPAIRED AT 60,000 MILES. THE FORD DEALER "SHAVED" THE GASKET. THE HEAD GASKET IS NOW SHOT AT 98,000 MILES. I HAVE CONTACTED FORD VIA THE INTERNET AND PHONE BUT HAVE HAD NO SUCCESS. FORD HAS ADMITTED TO A DEFECT IN THIS SAME ENGINE IN THE 1994-95 TAURUSES, SABLES, CONTINENTALS, COUGARS, THUNDERBIRDS, MUSTANGS AND WINDSTARS AND OFFERED REIMBURSEMENT AND/OR MONEY TOWARDS A NEW VEHICLE (SEE APRIL 26, 2000 EDITION OF DETROIT NEWS AUTO SECTION - WWW.DETNEWS.COM). *AK

THE HEAD GASKET WENT BAD EVEN AFTER ROUTINE REGULAR MAINTENANCE AND ONLY 80,000 MILES ON THE VEHICLE. ACCORDING TO A LOCAL DEALERSHIP AND SEVERAL MECHANICS THIS IS EXTREMELY COMMON. I WAS FORTUNATE BECAUSE THE HEADS AND BLOCK WERE NOT CRACKED UNLIKE THE MAJORITY OF THE ONES THAT ARE SERVICED. IT SEEMS THAT IF THE 3.8 LITER HAS THIS PROBLEM THEN MAYBE THERE IS A DESIGN FLAW OR QUALITY PROBLEM WITH THE GASKET. THE OTHER PROBLEM IS WHEN HAVING THIS FIXED, THE STEERING PUMP FRONT GASKET USUALLY BREAKS WHEN THE BELT IS REMOVED, THIS SHOULD NOT HAPPEN. IF I HAD KNOWN ABOUT THIS DESIGN FLAW IN THIS ENGINE I WOULD HAVE NEVER PURCHASED THIS OR ANY FORD VEHICLES WITH A 3.8 LITER ENGINE. ALSO WHY DON'T THE SEAT BELTS LOCK? *AK

VEHICLE EXPERIENCED HEAD GASKET FAILURE, RECALL ON OTHER MODELS HOWEVER COUGAR WAS NOT INCLUDED EVEN THOUGH SAME ENGINE AS RECALL MODELS, DENIED RECALL REPAIR (98M01). MJS

VEHICLE EXPERIENCED HEAD GASKET FAILURE, RECALL ON OTHER MODELS HOWEVER COUGAR WAS NOT INCLUDED EVEN THOUGH SAME ENGINE AS RECALL MODELS, DENIED RECALL REPAIR (98M01). MJS

VEHICLE EXPERIENCED HEAD GASKET FAILURE, RECALL ON OTHER MODELS HOWEVER COUGAR WAS NOT INCLUDED EVEN THOUGH SAME ENGINE AS RECALL MODELS, DENIED RECALL REPAIR (98M01). MJS

BOTH HEAD GASKETS BLOWN; HOWEVER, COMPLAINTS RE; FAULTY TEMPERATURE GUAGE SUBMITTED TO DEALER SINCE 10/15/1993. REPAIR COST: $1390.92 (INCL. TAX).

MOUNTS HAVE FAILED, SIMILAR TO 87 & 92 FORD TAURUS MODELS. IS THERE A RECALL ON THE 91 COUGAR FOR THIS SAME PROBLEM?...STRANGE COINCIDENCE. THANKS

WHEN STARTING THE VEHICLE IT MADE A PUFFING SOUND AND CUT OFF, AFTER RESTARTING AND DRIVING ABOUT ONE BLOCK, THE ENGINE SUDDENDLY DIED. THE ENGINE HEAD GASKET WAS REPLACED BY MECHANIC. *AK