2015 MERCEDES-BENZ C200 — Problems, Recalls & Safety Data

I have been informed by my dealer's service unit that the rear subframe of my car (2015 Mercedes C class) is rusted with holes. My understanding is that this can affect the integrity of the structure and cause problems while driving. According to your website [XXX] ) , this should be covered under a warranty extension. However, Mercedes says that my car is not, and to fill out this form if I believe it should be. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

1. What component or system failed or malfunctioned? The low-pressure fuel feed line (Part No. 274-070-35-00) and its associated clamps connected to the high-pressure fuel pump. Availability: State: The defective hose is currently on the vehicle and is available for inspection. If the repair proceeds, I request the dealership to retain the failed part for my inspection. 2. How was your safety or the safety of others put at risk? The failure resulted in raw fuel leaking directly into the engine compartment. This creates an immediate and severe fire hazard, as gasoline is being released near high-temperature engine components. Furthermore, the strong odor of gasoline entered the cabin through the HVAC vents, exposing passengers to toxic fuel vapors while the vehicle was in operation. 3. Has the problem been reproduced or confirmed? Yes. The defect was confirmed by Mercedes-Benz of Orange Park (Dealer Code: 64111). The technician performed a 'cold start' inspection and verified fuel leaking from the low-pressure line to the high-pressure pump. > Note: My service advisor's admitted: Yes sir we will do the hose. 4. Has it been inspected by the manufacturer, police, insurance, or others? Answer: The vehicle has been inspected and the failure documented by an authorized Mercedes-Benz dealership technician. It has not yet been inspected by insurance or police as no fire has occurred yet; however, the dealership has identified the part as defective. 5. Were there any warning lamps or other symptoms prior to failure? There were no warning lamps or dashboard messages. The primary symptom was a pungent smell of raw gasoline inside and outside the vehicle, specifically during cold starts. These symptoms first appeared recently [January 3rd, 2026] and became persistent as ambient temperatures dropped.

Strong gas odor coming from vent when heat and AC is on. Odor was causing dizziness and had to drive with window open or vent off. When opening the hood gas odor was also present. Brought to the mechanic and found fuel lines leaking. Went online and found out this is a very coming problem. I had to spend $657. to repair. Mechanic stated Mercedes issued a service bulletin but not a recall.

Purchased this car in September 2024 for our [XXX] son. Upon inspection at our local Mercedes Dealership on December 1, 2025, we were informed that the rear subframe should be immediately replaced as there is a rusted hole in the subframe, "compromising the structural integrity of the rear of the vehicle." We were informed that the prior bulletin issued for 2010-2014 C-Class models did not include our 2015 C-Class. We were quoted over $5200 to repair the subframe. There were no warning messages, lights problems that were noted, prior to inspection. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I took my car for service and they found a rusted rear subframe, with a small hole in it. I was informed that the car was not safe for my annual trip from NJ to FL (about 1000 miles). I was also told that this defect was a recall for cars through 2014. My car is a 2015 and I have the same defective part - which is supposed to be manufactured with rustproof material. I am requesting that this car be recalled and the part replaced by the manufacturer.