2005 MAZDA MAZDA3 Fuel System Gasoline Problems

The contact owns a 2005 Mazda Mazda3. The contact stated that after refueling the vehicle, there was an abnormally strong fuel odor coming from the vehicle. The contact stated that while the vehicle was parked, other individuals informed the contact that there was a strong fuel odor coming from the vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or a dealer. Additionally, the contact stated that the air bag warning light was illuminated. An independent mechanic diagnosed the vehicle and determined that the clock spring was faulty. The vehicle was not repaired. The dealer and the manufacturer were not contacted. The failure mileage was approximately 220,000.

PLAGUE WITH FUEL SYSTEM PROBLEM. 1ST TIME CHECK ENGINE CAME ON, WHEN CAR REACHED 44,000 MILES. I TOOK IT TO DEALER, THEY RAN A DIAGNOSTIC, AND REPLACED THE O2 SENSOR. WARRANTY COVERED. 2ND TIME CHECK ENGINE CAME ON AT 51,000 MILES. DEALER REPLACED 2 OF THE FUEL INJECTORS. WHEN CAR REACH 85,000 MILES, ENGINE STARTED SPUTTERING WHEN I PRESSED GAS PEDAL, ENGINE JUST DIES ON THE STREET. THIS TIME DEALER SAID FUEL PUMP MIGHT BE BAD. SO WE GOT IT REPLACED FOR $800. WHEN CAR REACH 100,000 MILES I HAD FUEL LINE CLEANED FROM FUEL TANK TO THE FUEL INJECTORS, AND REPLACED SPARK PLUGS. AT 105,000 MILES CHECK ENGINE LIGHT CAME ON AGAIN. I TOOK CAR TO AUTOZONE PARTS AND HAD IT READ. THE CODE SAYS, P2004 (VARIABLE TUMBLE SHUTTER VALVE STUCK OPEN). THE NEXT DAY I WAS GOING TAKE IT TO A LOCAL AUTO REPAIR SHOP AND HAVE IT...

MY WIFE SONDRA WAS STOPPED IN OUR 2005 MAZDA3 WHEN SHE WAS STRUCK FROM BEHIND BY AN INDIVIDUAL DRIVING A 2001 MALIBU. THE VEHICLE WAS DOING APPROX. 30 MPH WHEN IT STUCK OUR CAR. OUR CAR WAS THEN PUSHED INTO THE VEHICLE STOPPED IN FRONT OF HER. MY WIFE WAS INJURED AND TRANSPORTED TO THE HOSPITAL, INJURIES WERE, 8 STITCHES TO THE BRIDGE OF THE NOSE, BACK AND NECK INJURIES, SHE IS UNDER GOING THERAPY AND IS WAITING FOR MORE TEST TO BE PERFORMED. THE REASON THAT I AM CONTACTING YOU IS BECAUSE OF SOME OF THE CONCERNS I HAVE ABOUT THE FOLLOWING SAFETY THAT FAILED. 1. THE DRIVERS SEATBACK BROKE DURING IMPACT. 2. THE AIRBAG DID NOT DEPLOY WHEN SHE STRUCK THE VEHICLE IN THE FRONT OF HER. 3. THE EMERGENCY SWITCH THAT SHUTS DOWN THE FUEL SYSTEM DID NOT ACTIVATE. OUR VEHICLE WAS TOTALLED FROM ALL THE DAMAGE,...

2005 MAZDA 3S WOULD NOT START. MECHANIC REPROGRAMMED THE MAIN RELAY AND REPLACED FUEL PUMP & GAUGE TWICE BUT PROBLEM PERSISTS. *KB THE FUEL PUMP AND GAUGE WERE REPLACED A SECOND TIME BUT THE VEHICLE STILL FAILED TO START OCCASIONALLY. THE VEHICLE WAS TAKEN BACK TO THE DEALER BUT THEY WERE UNABLE TO FIND THE CAUSE OF THE PROBLEM. MAZDA TECH SUPPORT WAS CALLED AND THE THEY SUGGESTED CHANGING THE FUEL CANISTER. IT WAS REPLACED ON JUNE 22, 2006. *NM