1992 MACK DM — Problems, Recalls & Safety Data
N/A
Safety Rating
0
Owner Complaints
3
Recalls
0
Service Bulletins
0
Investigations
Overview of the 1992 MACK DM
The 1992 MACK DM has received a total of 0 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). There have been 3 recall campaigns affecting this vehicle, covering issues with VEHICLE SPEED CONTROL, TRAILER HITCHES, SERVICE BRAKES, AIR:SUPPLY:HOSES, LINES/PIPING, AND FITTINGS.
Recalls for the 1992 MACK DM
NHTSA has recorded 3 recalls for the 1992 MACK DM, potentially affecting up to 45,925 vehicles.
Recall 94V032000 — VEHICLE SPEED CONTROL
| 39,777 vehicles affected
Defect: FUEL INJECTION SYSTEM RECONFIGURATION TO COMPLY WITH ENGINE EMISSION STANDARDS CAUSE HIGHER ENGINE VIBRATION LEVELS WHICH LEAD TO EARLY WEAR AND COMPLETE FAILURE OF THE SECONDARY THROTTLE RETURN MECHANISM.
Consequence: IN THE EVENT THE PRIMARY THROTTLE RETURN FAILS, FAILURE OF THE SECONDARY THROTTLE RETURN SYSTEM WOULD NOT PROVIDE PROTECTION AGAINST LOSS OF THROTTLE CONTROL.
Remedy: A NEW PRODUCTION SECONDARY THROTTLE RETURN SYSTEM CONFIGURATION WILL BE INSTALLED.
View full details →Recall 93V024000 — TRAILER HITCHES
| 4,924 vehicles affected
Defect: THE CARRIER YOKE BOLTS WERE MANUFACTURED WITH WORN ROLLING THREAD DIES, CAUSING STRESS CONCENTRATIONS WHICH CAUSED CRACKS DURING THE QUENCHING PROCESS.
Consequence: THIS CONDITION CAN CAUSE BOLT FAILURE AND ALLOW THEDRIVELINE TO SEPARATE FROM THE CARRIER ASSEMBLY.
Remedy: REPLACE THE CARRIER YOKE BOLTS.
View full details →Recall 95E003010 — SERVICE BRAKES, AIR:SUPPLY:HOSES, LINES/PIPING, AND FITTINGS
| 1,224 vehicles affected
Defect: AIR SYSTEM BLOCKAGE IN THE AIR DRYER OCCURS DEGRADING THE MOISTURE REMOVING CAPABILITIES OF THE DRYER WHEN THE VEHICLE IS OPERATED IN A COLD ENVIRONMENT AND MOISTURE ACCUMULATES AND FREEZES IN THE AIR DRYER OR IN THE LINE BETWEEN THE DRYER AND THE AIR SYSTEM RESERVOIR. THE AIR DRYER CAN BECOME OVERPRESSURIZED CAUSING THE AIR DRYER CARTRIDGE TO SEPARATE FROM...
Consequence: IF THE AIR DRYER SEPARATES FROM THE BASE, THE CARTRIDGE CAN SEPARATE SUFFICIENTLY ENOUGH TO CAUSE PERSONAL INJURY OR PROPERTY DAMAGE.
Remedy: DEALERS WILL EQUIP AIR SYSTEMS WITH A PRESSURE RELIEF VALVE TO BE LOCATED BETWEEN THE COMPRESSOR AND THE AIR DRYER. THIS PRESSURE RELIEF VALVE IS INTENDED TO VENT IF EXCESSIVE PRESSURE DEVELOPS IN THE AIR DRYER.
View full details →Owner Complaints for the 1992 MACK DM
No complaints have been filed with NHTSA for the 1992 MACK DM.
Safety Rating for the 1992 MACK DM
NHTSA has not yet tested the 1992 MACK DM in its New Car Assessment Program.
Technical Service Bulletins for the 1992 MACK DM
No technical service bulletins have been reported for this vehicle.
NHTSA Investigations for the 1992 MACK DM
There are no NHTSA defect investigations on record for this vehicle.
Other Model Years of the MACK DM
- 1987 MACK DM — 0 complaints
- 1988 MACK DM — 0 complaints
- 1989 MACK DM — 0 complaints
- 1990 MACK DM — 0 complaints
- 1991 MACK DM — 0 complaints
- 1992 MACK DM (current)
- 1993 MACK DM — 0 complaints
- 1994 MACK DM — 0 complaints
- 1995 MACK DM — 0 complaints
Other MACK Models
- MACK MACK — 35 total complaints
- MACK ANTHEM (AN) — 12 total complaints
- MACK CXU612 — 12 total complaints
- MACK CX613 — 10 total complaints
- MACK GRANITE (GR) — 10 total complaints
- MACK CH600 — 9 total complaints
- MACK GU — 9 total complaints
- MACK RD — 8 total complaints