2011 LEXUS ES Structurebody Problems

We purchased this vehicle in mid 2018. In October of 2018 Lexus issued a customer support process ZLZ which covered our vehicle for problems with the dashboard. At that time, we had no deterioration of our dashboard so we did not respond. The Lexus program expired in 2021. In the last two years, our dashboard has deteriorated quite substantially becoming sticky and more importantly, becoming very reflective. This condition is a serious safety issue for day and night driving as light reflects up on the windshield and obscures vision out of the windshield. We took the vehicle to Lexus San Diego in August of 2024 and they declined to address the repair as a defect and offered to replace the dashboard for approximately $3000. At that time I called the Lexus Corporate Dept and they said that it could fall under the support program again if they re-opened the program....

THE DASHBOARD IS MELTING WHICH RESULTS IN THE NOXIOUS CHEMICAL SMELL AND ADHESIVE COMPOUND THAT IS STICKY TO THE TOUCH.

TL* THE CONTACT OWNS A 2011 LEXUS ES. WHILE DRIVING APPROXIMATELY 65 MPH, THERE WAS A VIBRATION EMERGING FROM THE FRONTAL DRIVER AND PASSENGER SIDE FLOOR PANELS. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE WHEEL BEARINGS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 38,000. THE VIN WAS NOT AVAILABLE.

AT APPROXIMATELY 7:23 PM ON JULY 8, 2012, WHILE PARKING IN THE PARKING LOT OF OUR LOCAL CHURCH, THE VEHICLE SUDDENLY ACCELERATED ON ITS OWN. THE CAR WAS ALMOST AT A COMPLETE STOP, WHEN THIS SUDDEN UNCONTROLLED ACCELERATION OCCURRED. AT THAT TIME LOTS OF PEOPLE WERE EXITING THE CHURCH AND WALKING TOWARDS THE PARKING LOT TO GET INTO THEIR CARS, WHILE OTHERS WERE INSIDE AND OUTSIDE THEIR VEHICLES WAITING FOR THE NEXT SERVICE TO START. I WAS TERRIFIED SINCE AS HARD AS I PUSHED THE BRAKE PEDAL, MY CAR CONTINUED ACCELERATING ; IT RAN OVER THE CONCRETE PARKING BUMP, HIT AN ELECTRICAL INSTALLATION, AND CAME TO A COMPLETE STOP WHEN IT HIT A PARKED SUV ON THE OPPOSITE SIDE OF THE PARKING LOT. THE FRONT SECTION OF MY CAR WAS COMPLETELY DESTROYED TO THE POINT WHERE IT WAS NOT DRIVABLE. I TOWED THE VEHICLE TO MY HOUSE AND LATER TO...

AT APPROXIMATELY 6:30PM, WHILE MAKING A RIGHT HAND TURN INTO A FRIENDS DRIVEWAY, THE VEHICLE SUDDENLY ACCELERATED ON IT'S OWN, AND THE BRAKES WOULD NOT WORK. THE VEHICLE CONTINUED TO THE RIGHT AS IF LOCKED IN TO THE RIGHT HAND POSITION, HIT A TREE AND FINALLY CAME TO A STOP BY HITTING HIGH CONCRETE STEPS. THE VEHICLE WAS TOWED TO THE DEALERSHIP, AND LATER TO THE BODY SHOP AS THE VEHICLE WAS NOT DRIVABLE. DURING THE INTERIM, THE VEHICLE WAS INSPECTED BY TOYOTA. POST INVESTIGATION, THE LETTER RECENTLY RECEIVED FROM TOYOTA STATES "DURING THE LIMITED TEST DRIVE ACCELERATING AND BRAKING TESTS WERE CONDUCTED AND THE VEHICLE PERFORMED WITH NO ABNORMALITIES FOUND". THE VEHICLE WAS NOT DRIVABLE PER THE MECHANIC AT THE DEALERSHIP AND THE MECHANIC AT THE BODY SHOP, DUE TO THE SIGNIFICANT DAMAGE AND FLUID LEAKAGE. THIS LETTER FROM TOYOTA'S INVESTIGATION IS INCONGRUENT WITH THE FACTS AS I KNOW...