2022 KIA TELLURIDE Visibilitywiper Problems

The windshield cracked for no apparent reason. The crack was on the driver's side, about 16 inches long, starting near the top and curving around the driver's view to the middle of the windshield.

Infotainment screen is blank most of the time. Backup camera works intermittently. Dealer confirmed head unit failure and stated software updates cannot be performed. Quoted approximately $7,500 for full replacement. Issue has been occurring for over two years, beginning while vehicle was still relatively new. Creates unsafe reversing conditions due to unreliable federally required backup camera display. Dealer classified as infotainment module failure. No recall issued despite widespread owner reports of similar failures.

I had noticed a 1" wide crack had formed in the center of the windshield after first night of cold weather (~10°F). There was no prior damage to the windshield before the crack formed. I'm concerned that the crack will continue to spread as we progress into the winter in the upper Midwest, ultimately shattering while I'm driving.

Windshield cracked for no reason. Developed a crack from the edge to the center of the windshield about 2 ft long.

We are replacing a second windshield in less than 2 years. Small pebbles start a chip, and the window companies try to fill the chip, but it cracks anyway. In both instances, the crack spanned from one side toward the top and affected my line of sight. The glass companies say they fix a lot of these cars. I'm afraid to go through the car wash with the high speed dryers for fear that the windshields strength is compromised and something can happen. Kind of makes my car wash membership useless...... That's over $2000 for 2 windshields and even then I have no guarantee that it will last. I'm seriously thinking of selling it as soon as I get it fixed. I'll definitely check the newer models to see if they are still having a problem. Maybe they can do us a favor and at least manufacture a better quality...

My windshield had a light crack and it ran pretty easily. It should not have done this so quickly. The crack should have been isolated and given me time to get it repaired before I have to replace the whole windshield. I can feel the break. I wouldn't think with a laminated windshield that all US cars are required to have, that I could actually feel the sharpness of the broken glass.

I was driving my 2022 Kia Telluride and my windshield crack, on the road and the crackline still running across my windshield. I think is dangerous to drive, but I don't if Kia will replace or do I need to pay my self

My Wife was driving 37mph in town at 1:40pm on a 31* afternoon. When she hears an apparent "gunshot", it was not a gunshot. Her forward sunroof had exploded. She had the sunshade closed thankfully so she did not get hit with any glass. Her vehicle was not hit by anything. The glass looks like it was forced from the inside, blowing the glass outwards. We took her vehicle to our local dealership. They vacuumed up the glass shards, and then taped the remaining glass on both sides, and also covered the roof until repairs can be made. Dealership is filing for warranty, but awaiting approval.

Description of the Problem: I noticed a crack suddenly appearing on my car’s windshield without any external impact, such as a rock or debris. The crack seems to have formed spontaneously, starting from the bottom edge and growing through the center of the glass, and there are no visible signs of external damage or impact points. This raises concerns about the quality or structural integrity of the windshield. It started early in the morning at about 6 inches but now has more than 12 inches and two ramifications. The car was parked in front of our garage and there were no extreme temperature changes. Concerns: I am worried that the windshield may have a manufacturing defect or material issue that could compromise the safety of the vehicle. This could pose a risk if the crack spreads or the windshield fails under stress.

Windshield had a small chip and then spidered next day across entire windshield. Dealer said, “So sorry, but can’t help or repair.” The 2020 Telluride had a recall and they fixed my first one after repeated calls.

A small rock hit my windshield on my way to work but did not initially appear to cause damage. Upon arriving at work I made no notice of any visible cracks or damage. Went in to the office, worked 8 hours, proceeding to get in my Telluride, removed my sunshade and noticed about an 18" to 24" long crack in my winshield running right down the middle. It was mindblowing how bad the crack was after a day that was not extremely hot or cold.

While driving at low speed through neighborhood streets, the front sunroof exploded out of nowhere. Safety was put at risk because of tempered glass falling on driver and passengers. Luckily the shade was closed. Has not yet been inspected by anyone. No warnings of the failure. Kia said they would not cover under warranty.

Windshield cracked under normal driving conditions. The crack was not caused by a strike or impact of any kind.

Windshield crack developed from the lower left driver side, up and across to the middle of the glass right in the field of view of the driver. There was no chip, no strike of any kind. Simply pulled the car out of the garage where it is kept daily and went 1 mile to the mail box. The crack appeared on my return and is getting larger. Did my research and found out about the class action lawsuit. I've seen where it is very much a known issue. I will contact KIA customer care next and then the dealership.

My windshield has cracked spontaneously and now I have a crack that is the length of a quarter of the windshield.

About a year ago I was having issues with my windshield wiper fluid working. When I took my car in for repair they told me a rodent had chewed though it and needed to be replace. This was not going to be covered under warranty. About 2 months ago my engine light turned on. I took it to the dealership and they said rodents has chewed through my knock sensor wiring. This is also not covered under warranty. Replacement is going to cost about $900.00. While researching his on online seems like this is a big issues with thousands reporting the same thing. Kia North Austin knows this is a problem and works on many cars a day with these same issues. This needs to be looked into and the car companies need to take responsibility. I never had this issues with my Ford Explorer which I had for 10...

Our windshield spontaneously cracked despite striking nothing.

In preparation for winter driving operations that include clearing the windshield of snow and ice, "before entering the vehicle"; both windshield wiper arm assemblies are not able to be lifted away or disentangled from the windshield glass due to the specific design interference of the hood. ************* Without properly clearing the wiper arms, wiper blades and windshield of ice and snow, operating the vehicle is not safe. *************

Small pebble was kicked up onto the Front Windshield on normal 35 mph street driving. I have read up on many instances that the Kia Telluride has had many issues with thin or defective glass that is not able to withstand simple small rocks.. This is a MAJOR safety issue and concern that KIA must acknowledge for 2021 and 2022 Telluride owners.. Apparently they noted issues on the 2020 when they were released. In many cases creating a small chip that becomes a major crack once it starts running.. Ours was attempted to be repaired by Safelite AutoGlass.. But still a few months later the crack expanded and began getting longer. KIA must begin to extend warranties for Telluride Owners as this glass is NOT meeting safety standards in protecting passengers.. It may become more evident if someone eventually gets seriously injured if the cracking / shattering glass enters the...

Driver side wiper gets stuck and won’t wipe in intermittent mode. Sporadically stops in auto mode.

While puling down our gravel driveway at a low rate of speed, a small gravel rock hit the passenger side lower corner of our windshield causing a very small circular chip in the glass. Day 0 - We pulled into our garage immediately evaluating what we knew happened because we heard it... and we couldn't find ANYTHING. Day 1 - The next morning we looked again and found the tiniest dot (and I mean dot sized) and felt SO glad that it wasn't bigger than that. Day 3 - The indented "dot" became a full blown cracked line about 5 inches long and continued to grow in size a little more each day... until we had no choice but to replace the windshield entirely as it expanded across the entire windshield, from passenger side bottom corner to the driver's side upper corner! This is not normal. I've had several gravel...

The vehicle is available for inspection. The vehicle windshield just cracked while the vehicle was parked in a driveway. Something must be defective in the manufacturing process. Windshield that just crack for no reason can cause safety concerns while driving for the passengers and other vehicles. The car was not being driven but simply the windshield cracked. We have not yet got it inspected by the dealer or other party/agency. The issue has not been recreated yet. Since it was parked it is unknown if any indicator lights or other warning occurred. This happened in the City of Orange California July 1, 2023. I would like a response from your agency about if others have reported this problem because Kia Motors was not very helpful. Where else can I get information about this issue? What else should we do? Please help.

My windshield cracked in March 2023 from a small stone on passenger side. In June 2023 I had the windshield replaced by Kia. 2 weeks later, windshield cracked from under the A post on the driver side. Kia dealership has said it was an outside source of impact, but it broke while driving, normal conditions and only vehicle on roadway. Kia is refusing to replace windshield again. 1st windshield was $1200. 2nd windshield the dealership offered not to charge labor, windshield will still cost $950.

2 cracked windshields that spidered out after a small pebble.

Saturday July 8 2023 heard crackling sounds like static coming from approximately 3/4 across the front console. Turned off radio, disconnected phone. Sounds continued, with no connection to road conditions or speed. Sunday July 9 2023 sounds continued intermittently. Monday July 10 2023 crackling sounds continued until a loud pop was heard. Windshield cracked at approximately 3/4 across the front and center of vertical (mid passenger vision). Very small center dot with three lines - looks like a bowtie or cat whiskers - intersecting at the dot, with a horizontal and two diagonal lines. Crackling sounds have since ceased. No impact to the windshield was detected prior to the crackling sound beginning.

The windshield is fragile. A small rock hit the windshield at highway speed and started to crack. This is the 2nd time this has happened. 11,000 miles on the vehicle and getting the windshield replaced for a seconded time. KIA needs to make the glass alot stronger to hold up to a minor rock chip.

A minor rock hit the windshield and caused a 1 inch crack approximately. It would have been small enough to fill in, however, the next day it spread to more than half the windshield after being in the sun. There is an existing letter referencing this exact issue from 2019 and looks like this is still an ongoing issue with the Telluride models and has not been remedied. https://static.nhtsa.gov/odi/tsbs/2019/MC-10168561-0001.pdf

windshield cracks without visible reasons on highway

The windshield easily cracked during standstill and parked. The vehicle was relatively new at 8000miles. There was no visible evidence as to debris coming from outside.

Minimal impact caused immediate massive cracking across majority of front windshield. Spoke with others who own the same vehicle have had similar issues with fragile windshield glass

While driving, a small rock hit the the windshield. This caused a circular Crack in the windshield. The crack seemed excessive given the low rare of speed (approximately 25mph). My concern is that if the windshield cracks easily from a small rock at a low speed, it won't hold up at higher speeds or to an average sized piece of road debris.

1. Windshield. Yes. Pics have been taken. 2. Windshield cracked just sitting in driveway having not been driven at all the day before it was noticed. Has increased in size drastically over only 2 days 3. Car has a svc appt for 2/17/23 for inspection. 4. No to any. 5. None. Does not apply. When windshield cracked was bounced, the vehicle was not driven at all the day before. 2 days prior, there was no visible Crack or chip of any kind. Sunshade is used every day. The size of the Crack grew immensely over the course of just 2 days.

I was traveling on a local road at approximately 35 mph, with only 1 other vehicle near me. I heard a crack, but did not see any rock hit the windshield. I immediately saw a spider crack form on the driver's side. The car is less than a month old and the windshield has no previous wear.

Windshield cracked. Also oxidation on trim on both sides of windshield.

1st crack in windshield was a pebble, the 2nd was a bug that hit windshield.

Windshield cracked with less than 5,000 miles on the vehicle. I noticed it after picking it up from the dealership for an oil change.

I was driving on the highway at a speed of 55MPH when a small rock hit my windshield. It was not a large rock, probably closer to a pebble. My Telluride’s front Windshield cracked immediately to a length of almost 20 inches long, horizontally.

Windshield is a safety hazard, I have not had the car for 3 months and have already had to repair it due to it having multiple cracks and chips.

Small rock hit windshield on very edge, the initial impact only produced a chip not much larger than the tip of a ballpoint pen but within minutes a large crack has spread at least 18" across the windshield. Based on research online this is unfortunately a very common issue and has been going on since at least 2019 when the company acknowledged the issue with a "goodwill" customer service initiative to replace damaged windshields for this exact issue. Still waiting to hear from dealer on potential resolution.

While driving at approximately 35 MPH, with no vehicles, pedestrians, lawnmowers, trees, road hazards, etc., near, the windshield spontaneously cracked near the passenger side pillar. The initial crack was circular with spider-webbing, the longest of which was approximately 6 inches (not exact due to being measured with a hand as reference). The vehicle was immediately parked, and upon return to the vehicle 1 hour and 45 minutes later, the spider-webbing had spread to approximately half the length of the windshield from the initial crack at the passenger side, to the driver side. My wife confirmed that there were no vehicles traveling the opposite direction, no pedestrians, overpasses, trees, vehicles, or other logical causes near the vehicle immediately following the initial crack. It seemed to occur spontaneously, my wife stated she heard what she could best describe as "the sound of glass cracking like in a horror movie" and observed the...

Windshield is cracked and only after 3 weeks of purchasing. The crack is in the top middle of the windshield and is spreading very rapidly across the passenger side. Very disappointing considering the price of the vehical!

Crack appeared in center of windshield after being parked in my driveway overnight. The crack is approximately one inch in diameter and circular.

I have experienced 3 windshield cracks within the visual field since purchasing the vehicle new. Each time the pebbles are small and the crack is requiring complete windshield replacements

I was the first car in line stopped at a traffic light - no vehicles in front of me - and I heard a loud pop. Immediately, I noticed a curved crack in the upper center of the windshield that wrapped below the rear view mirror area. There was no impact to the glass at the time - the windshield just simply popped for seemingly no reason whatsoever. This has been an issue on 2020 and 2021 Kia Tellurides, and Kia has been aware of this issue for a while, blaming it on a "windshield bonding problem" at the factory.

We have had the vehicle for less than a year and the windshield has already broken twice from very small/light pebbles. The star caused by the most recent one was so small we didn't even hear it and has now spread to a 30"+ crack across windshield. We learned through researching that the windshields on these cars are becoming notorious for easy breakage and we do not feel safe having such a weak windshield.I have been driving for 18 years and have only ever once before had a windshield need replacement. The crack is so large I am afraid the glass will fall through while driving and it distorts the view. Should not have to keep replacing the windshield for every grain of sand that strikes it!

Windshield crack developed 6 inches above from bottom from drive side when driving on highway after 2 hours of drive. No one near my vehicle and not related to any Collison. Crack increased from 3 inch to half of the screen on parked car. Not inspected by police or insurance company as of now. Went to dealer in Norwood, MA and person at dealership reviewed and confirmed it happed without any specific external hit.

Windshield cracking on a brand new 2022 telluride. This could cause severe issues at high speeds.

Windshield. Windshield was chipped by a flying rock or piece of debris on the right side just at the edge on February 14, 2022. Within one to two weeks a crack had formed and went two-thirds of the way across the windshield in the view of the driver. Windshield was repaired on March 31, 2022. On April 13, 2022, less than two weeks from the replacement, a flying rock hit the windshield and caused a chip at the very bottom of the middle of the windshield. Within two weeks the chip had formed a crack and went half way up the windshield, turned, and went almost all the way across the passenger side of the windshield - in the view of the passenger. it appears many Kia owners have had the same issue with small chips causing extreme cracks in the windshield which resulted in having to replace the windshields...

Completely random windshield crack with unknown cause. Doesn't appear to be from impact, discovered after vehicle had been sitting undisturbed in private driveway, no wear near other persons, vehicles, or poor weather.

Windshield has a long crack with nothing impacting the glass