2019 KIA STINGER — Problems, Recalls & Safety Data

Wiring harness has been severed, chewed through, or burnt. Multiple times. If my phone listed down below does not work call [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The issue involves the high-pressure fuel pump covered under Recall 23V634000 (Kia SC281). When the recall was marked as “completed” at the dealership, only a software update was performed. The required inspection of the fuel pump and potential replacement were never carried out. Two years later, the vehicle began experiencing problems consistent with the recall defect, including loss of power and engine performance issues. This indicates the recall remedy was not properly completed, and the defective fuel pump was left in place. The safety risk is that the vehicle may lose motive power while driving, increasing the likelihood of a crash. This problem could potentially affect other owners if recalls are being closed without full inspection or replacement. The symptoms have been observed during regular driving and can be reproduced. The vehicle has not yet been inspected by Kia for the current issue beyond the original recall visit. Warning lights and drivability issues began appearing recently, which align with the defect described in the recall notice. The high-pressure fuel pump is available for inspection upon request.

The car had fuel pump recall I had it fixed on 10/24 now the car has the same issue but your kia refuses to fix it. My warranty company is replaceing the fuel pump but not the reprogramming of it but why is it my issue if it is a recall to begin with that wasn’t fixed or I would not need a high pressure fuel pump and have the same problem. Kia states they only fix one time so now I’m responsible to have it programmed when it was a recall to begin with

I brought my vehicle in for the recall SC300 and they discovered that my oil pressure switch is leaking which is on top of the engine. This is causing a leak and oil pressure light to come on intermittently. Same part as the Kia Sorento, cadenza, and the Sedona that all had the warranty extended recall to 15 years or 150,000 miles. Every Kia forum has people complaining about the same issue and being charged $3000-5000. This can cause an engine fire if left unchecked just like the recall SC300. There is a backlog for that part to come in to fix the issue and people are driving with the light flickering because they don’t know the oil pressure switch is leaking over there engine and down to the EPU which could start a fire as well.

Car was idling louder than usual, engine light came on. Car felt like it wanted to go forward while in park. Dealership diagnosed bad fuel pump and sensor. Had to replace fuel pump, sensor and gaskets with fuel line too.