2003 KIA RIO Engine And Engine Coolingengine Problems

WHILE DRIVING DOWN THE ROAD WITH MY TWO YEAR OLD IN THE CAR, THE ENGINE SEIZED UP AND STALLED. THE CAR CURRENTLY WONT START AND HAD TO BE TOWED TO THE REPAIR SHOP. HOWEVER, WE JUST HAD ALL OF THE ROUTINE MAINTENANCE TO THE CAR LESS THEN 300 MILES PRIOR TO THE ENGINE SEIZING. THE CHECK ENGINE LIGHT NEVER CAME ON. AS OF TODAY, THEY DON'T KNOW WHAT THE PROBLEM IS EXCEPT THAT THE ENGINE SEIZED. THERE WAS NO PRIOR INCIDENTS WITH THE CAR AND IT WAS ALWAYS SERVICED ON TIME. *TR

TIMING BELT BROKE AT 72000 MILES WITHOUT WARNING. KIA SAYS CHANGE AT 60000 MILES IN KY, BUT WARRANTY IN CA ALLOW FOR 105000 MILE CHANGE. KIA REFUSED TO HONOR WARRANTY. STRANDED FOR 45 MINUTES. HAD TO PAY DIAGNOSTIC TESTING AT KIA DEALER. *TR

BOUGHT 2003 KIA RIO NEW. IN JAN 2005 AT ABOUT 53,000 MILES I HEARD A RATTLE AT ABOUT 50 MILES PER HOUR. IN A FEW SECONDS THE ENGINE JUST SHUTDOWN (TIMING BELT BROKE WHICH DESTROYED THE ENGINE) KIA REPLACED UNDER WARRANTY. MAY 21 2008 WHILE DRIVING ABOUT 45 MILES PER HOUR WE HEARD A SQUEAL AND AGAIN THE ENGINE SHUTDOWN. COASTED TO A STOP, ONCE AGAIN THE TIMING BELT WHICH MEANS ANOTHER ENGINE (58,000 SINCE THE LAST ENGINE) NO LONGER UNDER WARRANTY (AN ENGINE COST ALMOST AS MUCH AS THE CAR ITSELF). *TR

THE CONSUMER TOOK THE VEHICLE TO DEALERSHIP TO CHECK FOR A STRONG ODOR INSIDE OF THE VEHICLE. THE FUMES/ODORS BECAME VERY HEAVY WHEN DRIVING WHICH CAUSED THE DRIVER TO BECOME ILL. THE CONSUMER WAS INFORMED BY THE MECHANIC THAT THE ODOR THE DRIVER WAS SMELLING WAS CALLED KOSMOLINE AND WOULD EVENTUALLY DISAPPEAR. *AK THERE WAS A NAUSEATING SMELL OF BURNING RUBBER OR PLASTIC FROM THE TIME OF PURCHASE. THE CONSUMER WAS ALLERGIC TO THE SMELL AFTER BREATHING THE MELTING KOSMOLINE AND OR UNDERCARRIAGE FOR OVER 3K MILES. THE SMELL HAD COME FROM THE VENTS AS WELL WHEN THE VEHICLE WAS STOPPED. THE VEHICLE EXPERIENCED A HARD START FROM A COLD START THE DEALER WAS UNABLE TO DUPLICATE THE PROBLEM. *SC *JB

WHILE DRIVING 35 MPH STEERING WHEEL WOULD PULL TO THE RIGHT, AND A LOUD NOISE WOULD BE COMING FROM THE STEERING WHEEL. ALSO, VEHICLE WOULD STALL FOR NO REASON WHILE DRIVING. DRIVER WOULD MAINTAIN CONTROL AND PULL TO THE SIDE OF ROAD. HAD VEHICLE TOWED TO DEALERSHIP, AND MECHANIC COULD MOT DETERMINE THE CAUSE OF EITHER PROBLEM.*AK

WHILE DRIVING VEHICLE WOULD RUN HOT. DEALER HAS REPLACED THE ENGINE ONCE, AND REPLACED AUTOMATIC TRANSMISSION TWICE. HOWEVER, PROBLEM CONTINUED. DEALER HAD NOT FOUND A SOLUTION FOR THE PROBLEM. *AK