2002 KIA RIO CINCO Electrical System Problems

ELECTRICAL LINE FROM REAR OF BRAKE SWITCH IS SHORT IN LENGTH AND UNSECURED RESULTING IN WIRE DAMAGE THAT SHORTS ELECTRICAL FUSE TO SWITCH. RESULTS IN BRAKE LIGHT FAILURE AND POSSIBLE REAR END COLLISION DUE TO NO BRAKE LIGHTS. NEW SWITCH FROM FACTORY WAS INSTALLED BY KIA DEALERSHIP- BUT PROBLEM PERSISTS. THE VEHICLE IS A 2002 KIA RIO CINCO. I'M WORRIED FOR MY FAMILY'S AND OTHERS SAFETY. THIS IS A DESIGN DEFECT, THAT I FEEL THE CONSUMER SHOULD NOT HAVE TO BEAR THE EXPENSE. *TR

APPROXIMATELY 1.5 YEARS AGO I WAS HAVING A PROBLEM WITH THE CAR HESITATING ON THE HIGHWAY AND THE CHECK ENGINE LIGHT COMING ON. I BROUGHT MY CAR TO THE KIA DEALERSHIP (HAMILTON, ON) FOR DIAGNOSIS AND THEY DIAGNOSED THE PROBLEM AS BEING THE MASS AIRFLOW SENSOR. I HAD THEM REPLACE THE SENSOR (250$CAD) AND DO A 300$ TUNE UP ON THE CAR. TWO DAYS LATER THE CHECK ENGINE LIGHT CAME BACK ON AND I BROUGHT IN BACK TO THE DEALER. BY THE TIME I HAD THE CAR AT THE DEALER THE LIGHT HAD GONE OFF AND THEY SAID TO BRING IT BACK WHEN IT WAS ON. FINALLY AFTER A NUMBER OF VISITS THEY DETERMINED THAT THE ECM NEEDED A FLASH. THEY FLASHED THE ECM AND THE CAR SEEMED FINE. APPROX 3 WEEKS AGO THE CAR STARTED HESITATING AGAIN AND I BROUGHT IT BACK TO THE DEALER. THEY FOUND A BULLETIN...

VEHICLE REPEATED STALLS IN THE MIDDLE OF TRAFFIC WHILE DRIVING, TOOK IT TO DEALER THE REPLACED HARNESS. DURING A SUDDEN STOP VEHICLES CHECK ENGINE LIGHT CAME ON, TOOK IT TO DEALER CANNOT FIND ANYTHING WRONG WITH IT. ONCE AGAIN CAR SHUTS OFF IN THE MIDDLE OF THE ROAD HAD THE CAR TOWED SPENT 24 HRS WITH DEALER, DEALER CANNOT FIND OUT THE PROBLEM DIAGNOSTIC TEST RUN AND CANNOT FIND ANYTHING WRONG WITH CAR. TOOK THE CAR HOME TODAY, DEC 1, CAR SHUTS OFF AGAIN AND WILL NOT START. CAR RUNS LIKE IT WANTS TO SHUT OFF