2018 KIA NIRO PHEV Power Train Problems

I received KIA letter about the recall SC276 for HCA issue around 1/15/24. I brought my 2018 Kia Niro PHEV to Kia Dealer in San Jose. They inspected and concluded that the vehicle is safe with the recall SC276. However, they did not replace the fuse as stated in Kia's recall instructions. Ten days later, I was on the road, slowing down at the intersection and the car suddenly lost power, the Dashboard show the message for 'EV System failed'. My battery was fully charged at work, which is 2 miles away. My gas tank was full and I couldn't start my car again. Lucky enough, I was 1/4 mile away entering a Freeway. I couldn't imagine what would happen if I was on Freeway. Police stopped by, put road warning while I scrambled to get a tow truck. An hour later, they was able to move my car off...

The contact owns a 2018 Kia Niro. The contact received notification of NHTSA Campaign Number: 23V534000 (Power Train) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2018 Kia Niro. The contact received notification of NHTSA Campaign Number: 23V534000 (Power Train) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2018 Kia Niro. The contact received notification of NHTSA Campaign Number: 23V534000 (Power Train) however, the part to do the recall repair was not yet available. An undisclosed dealer was contacted and confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

2018 KIA NIRO PLUG-IN HYBRID, 16,235MI. VEHICLE HAS BEEN IN 5 TIMES IN LAST SEVERAL MONTHS FOR A TOTAL OF OVER 30 DAYS IN SHOP. TRANSMISSION WILL DO A VERY HARD DOWNSHIFT INTERMITTENTLY WHEN STOPPING. MAKES VEHICLE DIP HARD..NOTICEABLE ON DASH CAM VIDEO. ON HARDER ACCELERATION, POWER TRAIN HAS TROUBLE DECIDING WHAT TO DO AND OFTEN THERE IS A NOTICEABLE DELAY IN ACCELERATION. FEELS SORT OF LIKE IT IS SLIPPING, BUT IS A DELAY IN POWERING THE ELECTRIC MOTOR FULLY AND STARTING THE GAS MOTOR.THIS HAS CAUSED A COUPLE CLOSE CALLS WHEN PULLING INTO TRAFFIC EXPECTING THE CAR TO REACT APPROPRIATELY. SOME ONLINE RESEARCH SHOWS THIS IS NOT AN UNCOMMON OCCURRENCE. DEALER HAS REPLACED A HYDRAULIC ACTUATOR, BLED SYSTEM AND REPROGRAMMED PCM. THIS FIXED A SQUEAK NOISE IN POWER TRAIN BUT NOT THE HARSH/ERRATIC OPERATIONS. AS FOR THE BRAKES, RECENTLY, DEPRESSING THE BRAKE WITH MORE THAN LIGHT PRESSURE CAUSES A...

THE TRANSMISSION FAILS TO ENGAGE IMMEDIATELY TO THE GEAR SHIFTED TO. WHEN STATIONARY AND WITH THE VEHICLE IN REVERSE, IF YOU PROCEED TO PRESS THE ACCELERATOR AND THE VEHICLE STARTS TO MOVE BACKWARDS, THE VEHICLE WILL CONTINUE TO ROLL IN THE REVERSE DIRECTION EVEN AFTER SWITCHING THE GEAR SELECTOR TO DRIVE AND PRESSING THE ACCELERATOR. THIS PROBLEM HAPPENS WHEN SWITCHING FROM EITHER DRIVE TO REVERSE OR REVERSE TO DRIVE.