2025 KIA EV6 Electrical System Problems

initially filed XXX (1/2/2026) 2nd (additional info) filed XXX (2/10/2026 3rd (3 page service report) XXX (2/11/2026) Vehicle is registered to Christopher Rojik, however it is my car that I drive, etc. today I am filing this for you folks that since I filed the complaint with Kia Corp. and sent them the service report, etc. Today, 2/19/2026 I received a formal Settlement Agreement and General Release to sign and accept. I am not signing it, as well as it fully releases Kia from any future issues, etc. outside of the warranty and whatever other details it claims. This will or should be the last for me to file. I had no idea they send me this kind of offer. As it is listed specifically as a "GOODWILL GESTURE" and they are not accepting fault or something like that. I attached inidividual pages, hopefully I can upload them as pdfs,...

I was reversing my car in the parking lot and I heard a pop. Immediately I had a check electrical system warning. Preceding this the car was doing things which may have implied issues with the 12 V battery. Occasionally walking up to the car would not automatically open the car. Or other times, touching the driver handle did not unlock the car. The car is now at the dealership. They have confirmed failure of the HV fuse, ICCU failure, which also blew the 12 v battery. They have ordered the parts but it is currently on back order. The car could drive but after looking up this issue if the 12 v battery had drained it would have been inoperable.

Started my car while I was out and heard a pop sound. Warning message appeared saying "check electrical vehicle system". I was able to drive but when getting onto the freeway, I started to lose acceleration and go into limp mode. I pulled over on the freeway and had to get car towed to dealership. Dealership service center confirmed that my ICCU part failed. The vehicle to my knowledge hasn't been viewed by anyone other than the dealership.

I charged overnight at work. When leaving I heard a loud pop and the check EV system light came one. The vehicle would no longer drive over 40mph. I made it a mile and it dropped to 20mph. The dealership has had my car for over a week. From research it seems to be the ICCU as many others have had problems with.

initial filed #11708370 (1/2/2026) 2nd filed #11717025 (2/10/26) Yesterday afternoon (2/10/26), I was told by Jim Shorkey Kia Wexford PA that no error codes are on the EV6, it is ready for pick up. Before I received this call, there was a software update done on the EV6 (see service records) I attached 2 photos of the software update as well. ICCU ASSY was replaced, etc. was told per Shorkey Kia since there are no issues with my EV6, as of Friday when they initially called to say my vehicle was ready for pick up, Kia considers my problem resolved. I know I’ll be paying for the car rental for X number of days, even though the EV6 did not get the software update until this past Tuesday, yesterday 2/10/26, which cleared the 3 codes that were still showing on the Kia app earlier morning yesterday, screenshot of that attached...

prior case 11708370 filed 1/2/2026 spoke with [XXX] 1/22/2026. Friday 2/6/2026 Shorkey Kia Wexford calls and tells me my EV6 is fixed I can pick it up. I go into the Kia App and still have the same 3 codes as before; P056216 VCU, C160404 FR_Radar, and C28B186 ADAS_DRV. I tell them later that day when I had time to open the app to make sure the codes were corrected, called them back and said until these codes are cleared, my vehicle is not fixed. Tuesday 2/10/2026 I get a called from same person at Shorkey Kia in Wexford, telling me my vehicle is fixed, I can pick up my vehicle, same person her name is Maggie. I told Maggie to hold while I bring up the Kia app, I still see the same 3 codes: P056216, C160404, C28B186. I told her the codes are still active, and as long...

I have experienced a ICCU failure at 7200 miles on my 2025 EV6 GT Line. This failure is a safety hazard as it will quickly disable the vehicle and strand the occupants wherever they be at the time of failure. (highway, back roads, day or night). There are warning lights when this occurs, but there is a very limited time to get to safety, depending on the state of charge of the onboard 12v battery. This issue has been ongoing since this vehicle came out in 2022. There have been a number of recalls to address the problem, but apparently without success. I see postings all the time with others experiencing this failure. When I inquired about the availability of the replacement ICCU, I was told that the part was on national back order. I was also told there were 147 units in transit, 47 were already spoken for. This...

11/28/25 on freeway car lost power and would only go 25mph and warning light came on. After short distance full power came back. 12/14/25 earliest appt with dealer and could not find problem. 01/09/26 Lost power and took car to dealer. Dealer said bad battery and they replaced battery. 1/20/25 lost power again and limped to dealer. Dealer found bad ICCU. They are now waiting for new ICCU to replace. When your driving 55 mps on freeway and suddenly drop to 25mph this is dangerous. The apx date required below is when I have taken the car and dealer confirmed ICCU problem not the original problem date of 11/28/25.

ICCU failure at 3889 miles not charging and 12v battery failure

Failure to charge properly on both alternating current and direct current platforms. Trips electrical breakers at residence while charging at home on AC current. The vehicle will only DC fast charge for a few minutes before charge session is prematurely terminated. I have been told by the KIA that it is a failure in the integrated charge control unit (ICCU). They told me there were 47 current problems right now in the state of Tennessee. I have not been issued a recall at this time. The logistics for getting a new ICCU could 2 weeks or greater. This problem could be catastrophic on long road trips.

Erratic behavior before pulling out of parking lot: STOP vehicle check power, check 12V battery Stop safely engage parking brake. All dash lights started flashing, going black, power couldn’t be maintained, thankfully not on highway yet. Complete car failure, had to have 2025 EV6 jumped 4 times, battery still showed 41% charged, couldn’t keep charge to even get car in neutral for tow or doors locked. After each jump from tow company, power would last for less than 3-5 seconds, then dead, completely dead vehicle nothing worked.

I was driving on the highway when I heard a pop like a loud fuse sound from the back seat area. Suddenly the car dropped 15 mph from 70 mph to 55 mph and the battery and electrical system warning lights came on and the vehicle said check electrical system. I was able to continue with my hazard lights on to exit the highway, at which point the max speed of the vehicle dropped to 45 mph. It would not go faster no matter how hard I pushed the gas pedal. I was able to pull over to a gas station and park in a spot but the vehicle had to be towed. When the tow truck arrived, the vehicle also flashed with the 12V battery low warning. It was diagnosed as a failed ICCU, which rapidly drained the 12V battery. The car is only 4 months old with about...

After 2474 miles, the vehicle Integrated Charging Control Unit (ICCU) failed in my 2025 Kia EV6 making the vehicle undrivable so it had to be towed to the Kia dealer. The ICCU was replaced under warranty. The failure of the ICCU in Kia, Hyundai and Genesis electric vehicles is fairly common and they have yet to come up with a permanent solution.

Driving down local (residential) roads, the ICCU died; towed to dealership 12/3/2025. All 12 volt electrical was inoperable. So no hazard lights, no shift to neutral, no locking the doors. It was towed to the dealer. ICCU is now being ordered. The Master Warning light and 12V battery warning light illuminated. I was fortunate to be able to park in a parking lot just before all electrical died. An Internet search shows that this is a known issue; and, even after the replacement the situation can happen again. Took delivery 6/28/25. So, not even 6 months old.

On 2025-11-12, my car got BMS error P1B9700. On 2025-11-13, I took the car to local Kia dealer. The error is for battery temperature sensor. After 1 week, thst sensor have not been replaced nor any other numerous minor electrical defects were fixed. My car was just parked in dealer lot the whole time. No communication from Kia or dealer how to fix this potentionly dangerous battery problem.

Power completely dropped while driving in traffic. This occurred several times. I could have easily been rear ended. Also, I could have been stuck within an intersection, I could have been broadsided. I see researched this issue and found it was widely written about in KIA EV6 online forums. Kia should have checked for issues before I leased the 2025 EV and informed me before I made a decision to lease vehicle. This occured in first weeks I drove the new car.

I was driving over to walk my friends dog and I was pulling into the overflow parking area and my car just speed up and it would not stop. I went up a curb and I hit a small tree went down another curb crossed the street and then up another curb and the break would not stop the car. I finally just cut the car off

ICCU failure caused loss of power on interstate. I almost got in a wreck because of this. Kia dealer refused to look at my car. Took vehicle to independent repair shop who diagnosed issue.