2005 KAWASAKI KL650A — Problems, Recalls & Safety Data

Check any vehicle history by VIN - Free vehicle history report

N/A

Safety Rating

2

Owner Complaints

1

Recall

ACTIVE RECALL

0

Service Bulletins

0

Investigations

Overview of the 2005 KAWASAKI KL650A

The 2005 KAWASAKI KL650A has received a total of 2 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). There has been 1 recall campaign affecting this vehicle, covering issues with ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE. The most commonly reported problem area is the Engine (1 complaint).

Recalls for the 2005 KAWASAKI KL650A

NHTSA has recorded 1 recall for the 2005 KAWASAKI KL650A, potentially affecting up to 33,693 vehicles.

Recall 07V486000 — ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

| 33,693 vehicles affected

Defect: ON CERTAIN MOTORCYCLES, INSUFFICIENT TIGHTENING OF THE MUFFLER MOUNTING BOLTS COULD ALLOW THE BOLTS TO LOOSEN.

Consequence: IF THE BOLTS LOOSEN COMPLETELY, IT IS POSSIBLE FOR THE MUFFLER TO SEPARATE FROM THE MOTORCYCLE AND CREATE THE POTENTIAL FOR A CRASH.

Remedy: DEALERS WILL TIGHTEN TWO MUFFLER MOUNTING BOLTS TO THE PROPER TORQUE FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 22, 2007. OWNERS MAY CONTACT KAWASAKI AT 1-866-802-9381.

View full details →

Owner Complaints for the 2005 KAWASAKI KL650A

2 complaints have been filed with NHTSA for the 2005 KAWASAKI KL650A. Below is a breakdown by vehicle component.

Most Recent Complaints

#10643472 | ENGINE | | 3,723 miles
BALANCER CHAIN BEGAN MAKING NOISE ATTEMPTED FACTORY RECOMMENDED ADJUSTMENTS. CONCERN WAS UNRESOLVED. REMOVED STATOR COVER FOUND QUADRANT AND TENSIONER BROKEN. *TR
#10279419 | ENGINE AND ENGINE COOLING | | 62,150 miles
ON THE BASIS OF ANECDOTAL INFORMATION I REPLACED THE STOCK BALANCER CHAIN TENSIONER ON MY 2005 KAWASAKI KLR 650 MOTORCYCLE. THESE HAVE BEEN KNOWN TO HAVE PROBLEMS IN THIS AREA, AND SURE ENOUGH THE SPRING THAT IS TO TENSION THE BALANCE CHAIN AS IT WEARS WAS BROKEN AND INOPERATIVE. THIS MEANT THAT IF I HAD NOT REPLACED THE TENSIONER ADJUSTER AND SPRING, THE CHAIN THAT RUNS THE BALANCER WOULD HAVE CONTINUED TO WEAR AND STRETCH TO THE POINT OF POSSIBLE CATASTROPHIC FAILURE. IT IS NICE THAT AMERICANS ARE MAKING A LIVING MAKING THESE PARTS, BUT HOW MANY BIKES DO NOT GET THIS REPAIR. I MENTION THIS AT DEALERSHIPS AND THEY ACT LIKE I AM SPEAKING A FOREIGN LANGUAGE. *TR

Safety Rating for the 2005 KAWASAKI KL650A

NHTSA has not yet tested the 2005 KAWASAKI KL650A in its New Car Assessment Program.

Technical Service Bulletins for the 2005 KAWASAKI KL650A

No technical service bulletins have been reported for this vehicle.

NHTSA Investigations for the 2005 KAWASAKI KL650A

There are no NHTSA defect investigations on record for this vehicle.

Other Model Years of the KAWASAKI KL650A

View all KAWASAKI KL650A model years →

Other KAWASAKI Models

View all KAWASAKI models →

Check any vehicle history by VIN - Free vehicle history report