2011 JAYCO PINNACLE — Problems, Recalls & Safety Data
N/A
Safety Rating
3
Owner Complaints
2
Recalls
0
Service Bulletins
0
Investigations
Overview of the 2011 JAYCO PINNACLE
The 2011 JAYCO PINNACLE has received a total of 3 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). There have been 2 recall campaigns affecting this vehicle, covering issues with EQUIPMENT, POWER TRAIN:AXLE ASSEMBLY. The most commonly reported problem area is the Electrical System (2 complaints).
Recalls for the 2011 JAYCO PINNACLE
NHTSA has recorded 2 recalls for the 2011 JAYCO PINNACLE, potentially affecting up to 845 vehicles.
Recall 10V500000 — EQUIPMENT
| 836 vehicles affected
Defect: JAYCO IS RECALLING CERTAIN MODEL YEAR 2011 TRAVEL TRAILERS AND FIFTH WHEELS MANUFACTURED FROM AUGUST 16, 2010, THROUGH OCTOBER 1, 2010, EQUIPPED WITH ATWOOD 35 SERIES RANGE OVENS. A POTENTIAL EXISTS FOR A SMALL FRACTURE WITHIN THE LINE DELIVERING GAS TO THE OVEN CAVITY BURNER. SUCH A FRACTURE MAY CAUSE PROPANE GAS TO LEAK FROM THE LINE.
Consequence: A PROPANE LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE AND/OR EXPLOSION CAUSING PROPERTY DAMAGE AND/OR PERSONAL INJURY.
Remedy: JAYCO IS WORKING WITH ATWOOD AND WILL REPLACE OR REPAIR THE STOVES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 8, 2010. OWNERS MAY CONTACT ATWOOD AT 1-574-266-4749 OR JAYCO AT 1-574-825-0608.
View full details →Recall 10V469000 — POWER TRAIN:AXLE ASSEMBLY
| 9 vehicles affected
Defect: JAYCO IS RECALLING CERTAIN MODEL YEAR 2011 PINNACLE FIFTH WHEEL TRAILERS EQUIPPED WITH DEXTER AXLES. ON SOME AXLES, CRACKS COULD APPEAR IN THE SPINDLE WELD.
Consequence: THESE CRACKS CAN PROPAGATE AND CAUSE THE SPINDLE TO DETACH FROM THE AXLE TUBE, RESULTING IN THE SEPARATION OF THE WHEEL END FROM THE VEHICLE, CREATING A ROAD HAZARD THAT INCREASES THE RISK OF A CRASH TO OTHER VEHICLES, AND COMPROMISES THE DRIVER'S CONTROL OF THE VEHICLE INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: JAYCO IS WORKING WITH DEXTER AXLE AND WILL INSPECT THE AXLE SERIAL NUMBER AND REPLACE IT IF IT FALLS WITHIN THE SERIAL NUMBER RANGE. REPLACEMENT OF THE AXLE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER...
View full details →Owner Complaints for the 2011 JAYCO PINNACLE
3 complaints have been filed with NHTSA for the 2011 JAYCO PINNACLE. Below is a breakdown by vehicle component.
| Component | Complaints | Crashes | Fires | Injuries | Deaths |
|---|---|---|---|---|---|
| Electrical System | 2 | 0 | 0 | 0 | 0 |
| Tires | 1 | 0 | 0 | 0 | 0 |
Most Recent Complaints
KEPT SMELLING HOT WIRES AND BURNING PLASTIC SMELL. SERVICE TECH WAS ALREADY IN CAMPGROUND SO WE CALLED THEM OVER TO INVESTIGATE AND THEY DISCOVERED THE IOTA MODEL ITS-50R AUTOMATIC TRANSFER SWITCH HAD BURNT WIRES. OUR UNIT IS PREPPED FOR A GENERATOR BUT WE DO NOT HAVE ONE INSTALLED SO WE QUESTION HOW/WHY THIS TRANSFER SWITCH SHOULD GO BAD SINCE IT'S NOT USED. REPEATED EMAILS TO JAYCO ARE NOT OFFERING MUCH INFORMATION. WE SAW WHERE OTHER TRANSFER SWITCHES HAD BEEN RECALLED AND WONDERED IF OUR SWITCH WAS ONE OF THOSE BUT WE COULD NOT FIND RECALL NOTICE. ARE THERE ISSUES WITH THIS MODEL ALSO? THEY KEEP ASKING IF A POWER SURGE CREATED THE ISSUE. THE CAMPER IS HOOKED UP TO A 50A SURGE PROTECTOR AT OUR SEASONAL CAMPSITE SO THIS SHOULDN'T BE AN ISSUE. AND, IT'S NOT A SINGLE WIRE THAT IS BURNT BUT SEVERAL WHICH IS A MAJOR MALFUNCTION. I'M UPLOADING A PDF OF THE EMAIL CONVERSATION WITH JAYCO,
TL* THE CONTACT OWNS A 2012 (NA) JAYCO PINNACLE EQUIPPED WITH GOODYEAR MARATHON ST TIRES, SIZE: ST235/80R16. WHILE THE VEHICLE WAS BEING TOWED AT 55 MPH, THE DRIVER'S SIDE TIRE EXPERIENCED A BLOW OUT. THE RV WAS TAKEN TO AN INDEPENDENT MECHANIC TO HAVE THE TIRE REPLACED. THE CONTACT WAS CONCERNED THAT THE TRAILER WAS SOLD WITH THREE YEAR OLD TIRES. THE CONTACT ALSO STATED THAT THE BATTERIES IN THE RV EXPLODED WITHOUT WARNING. THE TRAILER WAS TAKEN TO THE DEALER TO HAVE THE BATTERIES REPLACED. THE DEALER REPLACED THE BATTERY; HOWEVER, THE BATTERIES EXPLODED AGAIN AFTER A FEW DAYS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE DOT NUMBER WAS UNKNOWN. THE APPROXIMATE TIRE AND VEHICLE FAILURE MILEAGE WAS 1,400.
TL* THE CONTACT OWNS A 2012 (NA) JAYCO PINNACLE EQUIPPED WITH GOODYEAR MARATHON ST TIRES, SIZE: ST235/80R16. WHILE THE VEHICLE WAS BEING TOWED AT 55 MPH, THE DRIVER'S SIDE TIRE EXPERIENCED A BLOW OUT. THE RV WAS TAKEN TO AN INDEPENDENT MECHANIC TO HAVE THE TIRE REPLACED. THE CONTACT WAS CONCERNED THAT THE TRAILER WAS SOLD WITH THREE YEAR OLD TIRES. THE CONTACT ALSO STATED THAT THE BATTERIES IN THE RV EXPLODED WITHOUT WARNING. THE TRAILER WAS TAKEN TO THE DEALER TO HAVE THE BATTERIES REPLACED. THE DEALER REPLACED THE BATTERY; HOWEVER, THE BATTERIES EXPLODED AGAIN AFTER A FEW DAYS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE DOT NUMBER WAS UNKNOWN. THE APPROXIMATE TIRE AND VEHICLE FAILURE MILEAGE WAS 1,400.
Safety Rating for the 2011 JAYCO PINNACLE
NHTSA has not yet tested the 2011 JAYCO PINNACLE in its New Car Assessment Program.
Technical Service Bulletins for the 2011 JAYCO PINNACLE
No technical service bulletins have been reported for this vehicle.
NHTSA Investigations for the 2011 JAYCO PINNACLE
There are no NHTSA defect investigations on record for this vehicle.
Other Model Years of the JAYCO PINNACLE
- 2010 JAYCO PINNACLE — 0 complaints
- 2011 JAYCO PINNACLE (current)
- 2012 JAYCO PINNACLE — 0 complaints
- 2013 JAYCO PINNACLE — 0 complaints
- 2014 JAYCO PINNACLE — 4 complaints
Other JAYCO Models
- JAYCO EAGLE — 67 total complaints
- JAYCO PRECEPT — 66 total complaints
- JAYCO JAYCO — 64 total complaints
- JAYCO DESIGNER — 43 total complaints
- JAYCO GREYHAWK — 30 total complaints
- JAYCO SENECA — 29 total complaints
- JAYCO ALANTE — 23 total complaints
- JAYCO JAY FLIGHT — 18 total complaints