2019 ISUZU N-SERIES — Problems, Recalls & Safety Data
N/A
Safety Rating
0
Owner Complaints
1
Recall
13
Service Bulletins
0
Investigations
Overview of the 2019 ISUZU N-SERIES
The 2019 ISUZU N-SERIES has received a total of 0 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). There has been 1 recall campaign affecting this vehicle, covering issues with ELECTRICAL SYSTEM:WIRING. 13 technical service bulletins have been issued by Isuzu Technical Center of America, Inc. for this model year.
Recalls for the 2019 ISUZU N-SERIES
NHTSA has recorded 1 recall for the 2019 ISUZU N-SERIES, potentially affecting up to 16,766 vehicles.
Recall 19V647000 — ELECTRICAL SYSTEM:WIRING
| 16,766 vehicles affected
Defect: Isuzu Technical Center of America, Inc. (Isuzu) is recalling certain 2017-2019 N-GAS HD and Chevrolet Low Cab Forward 3500 and 4500 vehicles and 2018-2019 Isuzu FTR and Chevrolet Low Cab Forward 6500XD vehicles. The power supply bolt in the relay box may not have been properly tightened during harness production at the supplier. This may lead to melting of the...
Consequence: A stall can increase the risk of a crash.
Remedy: Isuzu will notify owners, and dealers will inspect the relay box power supply bolt, tightening it as necessary. If the harness or relay box is found to be damaged, it will be replaced or repaired, free of charge. The recall...
View full details →Owner Complaints for the 2019 ISUZU N-SERIES
No complaints have been filed with NHTSA for the 2019 ISUZU N-SERIES.
Safety Rating for the 2019 ISUZU N-SERIES
NHTSA has not yet tested the 2019 ISUZU N-SERIES in its New Car Assessment Program.
Technical Service Bulletins for the 2019 ISUZU N-SERIES
Isuzu Technical Center of America, Inc. has issued 13 technical service bulletins (TSBs) for the 2019 ISUZU N-SERIES. TSBs are notices sent by manufacturers to their dealers describing a known issue and the recommended repair procedure.
SB18-L-002C — ENGINE
Some customers may experience an illuminated Malfunction Indicator Light (MIL) with DTC P20EE Diesel Exhaust Fluid (DEF) System NOx Trap Low Efficiency set without an apparent cause. New calibrations for the DEF Control Unit (DCU) have been developed to address this concern.
IB18-X-001F — EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
IDA is a diagnostic program that provides: 1. DTC Analysis 2. DPF Early Regeneration Warning Detailed instructions on how to use the IDA are included in this bulletin.
SB18-L-002B — EXTERIOR LIGHTING
SOME CUSTOMERS MAY EXPERIENCE AN ILLUMINATED MALFUNCTION INDICATOR LIGHT (MIL) WITH DTC P20EE DIESEL EXHAUST FLUED (DEF) SYSTEM NOX TRAP LOW EFFICIENCY SET WITHOUT AN APPARENT CAUSE. NEW CALIBRATIONS FOR THE DEF CONTROL UNIT (DCU) HAVE BEEN DEVELOPED TO ADDRESS THIS CONCERN. FOLLOW THE DIAGNOSTIC FOR THIS DTC. IF NO...
SB18-L-002B — FUEL SYSTEM, DIESEL
SOME CUSTOMERS MAY EXPERIENCE AN ILLUMINATED MALFUNCTION INDICATOR LIGHT (MIL) WITH DTC P20EE DIESEL EXHAUST FLUED (DEF) SYSTEM NOX TRAP LOW EFFICIENCY SET WITHOUT AN APPARENT CAUSE. NEW CALIBRATIONS FOR THE DEF CONTROL UNIT (DCU) HAVE BEEN DEVELOPED TO ADDRESS THIS CONCERN. FOLLOW THE DIAGNOSTIC FOR THIS DTC. IF NO...
IB18-J-002A — FUEL SYSTEM, DIESEL
RECENTLY, THE ESSENTIAL TOOLS - DPF INJECTOR CLEANING KIT (EN-52575), INJECTOR CLEANER ACCESSORY KING (EN-52575-50), AND INJECTOR SEAL INSTALLER AND SIZER (J-46911) - WERE SHIPPED TO ISUZU DEALERS. ISUZU HAS DEVEOPED A PROCEDURE TO REMOVE THE CARBON BUILDUP FROM THE DPF FUEL INJECTOR TIP AND TO MAINTAIN THE INJECTOR PERFORMANCE...
IB16-J-001B — EQUIPMENT
SOME CUSTOMERS MAY EXPERIENCE A "CRANK NO START" CONDITION IN THE VEHICLES LISTED ABOVE. THE FOLLOWING DIAGNOSIS MIGHT BE HELPFUL IF THE VEHICLE EXHIBITS THE SYMPTOM(S) DESCRIBED IN THIS INFORMATION BULLETIN.
SB19J001A — LANE DEPARTURE
SOME CUSTOMERS MAY EXPERIENCE ISSUES WITH OIL DRIPPING FROM THE AIR CLEANER OR AN OIL SOAKED FILTER ELEMENT, ALONG WITH ILLUMINATED CHECK ENGINE (CEL) AND CHECK AIR FILTER WARNING LAMPS. THE PURPOSE OF THIS BULLETIN IS TO ANNOUNCE THE AVAILABILITY OF A NEW AIR INLET DUCT THAT WILL REDUCE THE...
CB19N001A — EQUIPMENT
ISUZU MOTORS LIMITED HAS DECIDED THAT CERTAIN 2019 MODEL YEAR ISUZU N-SERIES TRUCKS PRODUCED BETWEEN AUGUST 24, 2018 AND NOVEMBER 17, 2018 AND EQUIPPED WITH 5.2L (4HK1) DIESEL ENGINES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 101 - CONTROLS AND DISPLAYS AND CANADA MOTOR...
CB19N001A — ENGINE AND ENGINE COOLING:ENGINE:DIESEL
ISUZU MOTORS LIMITED HAS DECIDED THAT CERTAIN 2019 MODEL YEAR ISUZU N-SERIES TRUCKS PRODUCED BETWEEN AUGUST 24, 2018 AND NOVEMBER 17, 2018 AND EQUIPPED WITH 5.2L (4HK1) DIESEL ENGINES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 101 - CONTROLS AND DISPLAYS AND CANADA MOTOR...
CB19N001A — EQUIPMENT ADAPTIVE/MOBILITY
ISUZU MOTORS LIMITED HAS DECIDED THAT CERTAIN 2019 MODEL YEAR ISUZU N-SERIES TRUCKS PRODUCED BETWEEN AUGUST 24, 2018 AND NOVEMBER 17, 2018 AND EQUIPPED WITH 5.2L (4HK1) DIESEL ENGINES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 101 - CONTROLS AND DISPLAYS AND CANADA MOTOR...
Showing 10 of 13 technical service bulletins.
NHTSA Investigations for the 2019 ISUZU N-SERIES
There are no NHTSA defect investigations on record for this vehicle.
Other Model Years of the ISUZU N-SERIES
- 2014 ISUZU N-SERIES — 0 complaints
- 2015 ISUZU N-SERIES — 0 complaints
- 2016 ISUZU N-SERIES — 0 complaints
- 2017 ISUZU N-SERIES — 0 complaints
- 2018 ISUZU N-SERIES — 0 complaints
- 2019 ISUZU N-SERIES (current)
- 2020 ISUZU N-SERIES — 0 complaints
- 2021 ISUZU N-SERIES — 0 complaints
- 2022 ISUZU N-SERIES — 1 complaint
- 2023 ISUZU N-SERIES — 0 complaints
- 2024 ISUZU N-SERIES — 0 complaints
Other ISUZU Models
- ISUZU RODEO — 3,295 total complaints
- ISUZU TROOPER — 713 total complaints
- ISUZU ASCENDER — 280 total complaints
- ISUZU AXIOM — 238 total complaints
- ISUZU AMIGO — 220 total complaints
- ISUZU RODEO SPORT — 143 total complaints
- ISUZU HOMBRE — 142 total complaints
- ISUZU PICKUP TRUCK — 93 total complaints