2004 HYUNDAI XG350 Structurebody Problems

CAR WAS PARKED NEVER HAD ANY ISSUES WENT TO CRANK IT UO IT JUST BURDT INTO FLAMES AND BURNED TO THE GROUND ENGINE WAS SNOKING AND SNOKE COMING FROM UNDERNEATH AND WSS OIURING OUT FLAMES BURNED UP IN LIKE 20 MINUTES OR SO FIRE DEPARTMENT HAD TO COME PUT IT OUT CAR IS NOTHING BUT SCRAP METAL NOW.

TL* THE CONTACT OWNS A 2004 HYUNDAI XG350. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED ABNORMAL VEERING AND THE STEERING COLUMN WAS LOOSE. THE FAILURE OCCURRED WITHOUT WARNING. HALL HYUNDAI NEWPORT NEWS LOCATED AT 12872 JEFFERSON AVE NEWPORT NEWS, VA WHERE IT WAS DIAGNOSED AS SEVERE CORROSION ON THE FRAME. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 200,000.

I WAS DRIVING FROM VIRGINIA TO NEW YORK ON ROUTE 17 TO ROUTE 81. I EXITED TO GET TO A GAS STATION. WHILE TURNING LEFT FROM A FOUR-LANE ROAD INTO THE GAS STATION, MY VEHICLE MADE A CRASHING SOUND AND STOPPED IN THE MIDDLE OF ON-COMING TRAFFIC. IT FELT LIKE WE HIT SOMETHING BIG. I COULD NOT MOVE THE CAR. WE HAD IT TOWED TO A GARAGE, WHERE WE LEARNED THE CV AXLE HAD SNAPPED. THEY ALSO HAD TO REPLACE RS SPINDLE AND RS BALL JOINT BECAUSE THEY HAD RUSTED OUT. THERE WAS COSMETIC DAMAGE DONE TO BODY WHEN THE AXLE BROKE AND THE CAR WENT DOWN HARD. *TR

WE OWN AN XG350 HYUNDAI. CAR WAS BROUGHT IN TO DEALER UNDER MANUFACTURER'S RECALL FOR CORROSION OF SUBFRAME APPROXIMATELY THREE YEARS AGO. DEALER PERFORMED MANUFACTURER-SUGGESTED REPAIRS: DRILLED HOLES IN SUBFRAME AND TREATED WITH ANTI-CORROSIVE. THREE YEARS LATER, SUBFRAME COMPLETELY ROTTED OUT AND CAR IS A DANGER TO DRIVE. PROBLEM WAS FOUND WHEN WE NOTICED WHEEL MISALIGNMENT (LOOKED LIKE RIGHT FRONT WHEEL WAS SKEWED) AND THAT CAR COULD NOT GO OVER EVEN SMALL BUMPS WITHOUT SLIDING ACROSS THE ROAD. THE GENTLEMAN WHO INSPECTED THE CAR FOR WHAT WE THOUGHT WAS GOING TO BE AN ALIGNMENT, SAID THAT THE CAR WAS EXTREMELY DANGEROUS AND IN HIS OPINION, WAS "TOTALED". WE HAD TO HAVE THE CAR TOWED TO THE DEALERSHIP AS IT IS TOO DANGEROUS TO DRIVE THE 2 MILES. WHEN WE CALLED THE HYUNDAI DEALER, HE AGREED TO REPLACE THE SUBFRAME AT NO COST, ADMITTING THAT THIS WAS A HYUNDAI PROBLEM. I...