2001 HYUNDAI ACCENT Engine And Engine Cooling Problems

APPROXIMATELY 3000 MILES AFTER HAVING A 60,000 MILE SERVICE INVOLVING REPLACEMENT OF ALL BELTS, INCLUDING TIMING BELT USING HIGH QUALITY BELTS OF KNOWN QUALITY, A HIGH VOLTAGE ARCHING CONDITION IS OBSERVED ON THE FACE OF THE HARMONIC BALANCER (HB). ARCH IS APPROX. .250-.500 INCH IN LENGTH AND PROJECTS FROM THE OUTERMOST EDGE OF THE HB TOWARD THE CENTER OF SAME. USING A JUMPER CABLE CONNECTED TO THE NEGATIVE BATTERY TERMINAL, ARCH CAN BE PULLED FROM THE OUTER EDGE OF HARMONIC BALANCER, BUT NO OTHER PULLEY SURFACE NOR BELT SURFACE. CONDITION IS INTERMITTENT AND FORCED REPRODUCTION HAS NOT BEEN POSSIBLE, BUT OCCURS WITH SUFFICIENT FREQUENCY TO PERMIT TROUBLESHOOTING. CONDITION HAS NOT BEEN PREVIOUSLY OBSERVED. AFTER EXTENSIVE DIAGNOSIS, IT APPEARS THE INSULATOR RUBBER BETWEEN MATING PARTS OF THE HB HAS DEGRADED RESULTING IN EXCESSIVE INTERNAL RESISTANCE WHICH RESULTS IN STATIC CHARGE GENERATED BY BELTS TO ESCAPE PULLEY INTERIOR, DISCHARGING OVER THE EXTERIOR...

DT*: THE CONTACT STATED WHILE ACCELERATING AT VARIOUS SPEEDS, THE ENGINE HESITATED, AND STALLED WITHOUT WARNING. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT REPAIR SHOP, WHO DETERMINED THE ENGINE COILS WERE WORN AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS ALERTED.

ALTERNATOR PULLEY NOT ALIGNED WITH CRANK PULLEY. TRIED SHIMMING, TIGHTENING AND NOTHING WORKS. CAUSES BELT TO SLIP OFF AND CAR TO OVERHEAT. CAR OVERHEATED AND WARPED HEAD AND COLLAPSED PISTON RINGS. ENGINE IS AVAILABLE. *JB

ALL WERE WARRANTY REPAIRS. THE IGNITION COIL WENT OUT FIRST. THEN THE CATALYTIC CONVERTER. THE BODY WAS JUST A MINOR THING, A RAIN RAIL CAME LOOSE, AND IT HAD TO BE REPLACED. FINALLY, THE CAR CAUGHT FIRE ON 09-02-03 AND IT IS TOTALLY. I ONLY HAD IT TWO YRS. AND IT ONLY HAD 31,000 MILES ON IT. IT HAS A HISTORY OF STALLING OUT ON TRIPS OF 30 MILES OR MORE, IT WOULD RESTART SOON THOUGH. CAR IS A TOTAL LOSS.