2006 HONDA PILOT Structure Problems

The contact owns a 2006 Honda Pilot. The contact stated that following a State Safety Inspection, the vehicle failed due to extensive corrosion to the rear suspension and to the rear trailing arm. The contact was advised by the State Inspector not to drive the vehicle due to the advanced state of corrosion. The contact had researched online and related the failure to NHTSA Campaign Number: 23V228000 (Structure). The contact had called the manufacturer and was informed that the vehicle was not included in the recall. The vehicle was not taken to a dealer or independent mechanic. The vehicle was not diagnosed and was not repaired. The failure mileage was approximately 175,000.

DRIVING ON THE CITY STREETS ABOUT 15 MPH AROUND A CORNER THE SPARE TIRE FELL OFF FROM THE BOTTOM OF THE VEHICLE. UPON FURTHER INVESTIGATION THE CABLE THAT HOLDS THE SPARE TIRE WAS FRAYED. THE END OF THE CABLE WAS FOUND ON THE STREET ALONG WITH THE SPARE TIRE. THIS EVENT CAUSED NO DAMAGE TO MY VEHICLE OR ANY OTHER VEHICLE OR PEDESTRIANS(HAPPENED IN FRONT OF AN ELEMENTARY SCHOOL AFTER DROPPING OFF MY KIDS). IF THIS INCIDENT WOULD HAVE HAPPENED ON THE FREEWAY, IT MIGHT HAVE HAD A DIFFERENT OUTCOME. *TR

THE REAR DOOR/HATCH OF OUR 2006 HONDA PILOT HAS AN ISSUE WITH THE LATCHING MECHANISM. THE ACTUAL MECHANISM ON THE REAR HATCH HAS BECOME DISCONNECTED FROM THE FRAME AND IS ABLE TO MOVE FREELY ABOUT. THIS CAUSES THE REAR HATCH TO NOT LATCH, LATCH PARTIALLY, OR LATCH BUT STILL ALLOW THE REAR HATCH TO SLIGHTLY MOVE. THE LATCHING MECHANISM IS ONLY BEING HELD IN PLACE (IN A CONFINED AREA) BY THE PLASTIC PANELING OF THE CAR. SINCE THE LATCH IS NO LONGER ATTACHED TO THE FRAME, THE MOVEMENT OF THE MECHANISM DETERMINES IF THE REAR HATCH IS GOING TO LATCH OR NOT. WHEN IT IS LATCHED, THE ONLY ITEM SECURING THE MECHANISM IS THE PLASTIC PANELING. THE MECHANISM ITSELF IS NOT DEFECTIVE OR BROKEN HOWEVER; THE WAY THE MECHANISM HAS BEEN SECURED SEEMS TO BE THE ISSUE. THE MOST CONCERNING ASPECT IS HOW A DOOR LATCH MECHANISM COULD BECOME DISCONNECTED...

TL* THE CONTACT OWNS A 2006 HONDA PILOT. THE CONTACT STATED THAT AFTER ROLLING DOWN THE REAR DRIVERS SIDE WINDOW, IT WOULD NOT ROLL BACK UP. A POPPING NOISE COULD BE HEARD COMING FROM THE WINDOW WHILE THE CONTACT ATTEMPTED TO ROLL IT BACK UP. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE ACTUATOR FOR THE WINDOW FAILED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE AND CURRENT MILEAGES WERE 86,912.

2006 HONDA PILOT-SEVERE INTERIOR LEAK IN FRONT PASSENGER SIDE FLOORBOARD, EXTENDING TO DRIVER'S SIDE FLOORBOARD. UNKNOWN HOW LONG THIS HAS BEEN OCCURRING. THE CARPET IS SATURATED. THE CARPET PAD UNDERNEATH IS ALSO SATURATED. MILDEW, MOLD AND BODY RUST WILL DEVELOP. HONDA ISSUED SERVICE BULLETIN (07-010) FOR THIS PROBLEM ON FEB. 8, 2007. DEALER DISCLAIMS ANY RESPONSIBILITY FOR SERVICE BULLETIN WORK, DUE TO OUTSIDE OF THEIR 3 YEAR WINDOW. NO ACCIDENTS/ VEHICLE DAMAGE PRIOR TO FINDING SOAKED CARPET. REGULAR MAINTENANCE DONE PER MANUFACTURER'S SCHEDULE. VEHICLE STILL UNDER EXTENDED WARRANTY. LACK OF NOTICE ABOUT SERVICE BULLETIN CAN LEAD TO MOLD ISSUES, BY EXTENSION TO RESPIRATORY ISSUES. HONDA CAN PREVENT THIS POTENTIAL PROBLEM BY NOTIFYING OWNERS, NOT WAITING FOR THEM TO DISCOVER SATURATED, SOAKED, AND IN SOME INSTANCES FROZEN CARPET INSIDE THE CAR. *TR

BEGAN NOTICING A MUSTY SMELL IN THE VEHICLE, FOLLOWED SEVERAL MONTHS LATER BY A SLOSHING SOUND THAT EVENTUALLY MANIFESTED ITSELF INTO A ROLLING WAVE OF WATER THAT SWEPT OVER MY FLOOR MATS. WATER IS SATURATING THE CARPETS (THINK OF A WET SPONGE) AFTER ENTERING THE VEHICLE PASSENGER COMPARTMENT THROUGH UNDETERMINED POINTS AT OR NEAR THE FIREWALL. THIS DEFINITELY OCCURS WHENEVER THE VEHICLE IS DRIVEN IN RAIN, WHEN DRIVEN OVER WET AND SNOW-COVERED ROADS, AND WHEN SITTING IN A CAR WASH. I HAVE NOT DETERMINED IF IT OCCURS WHILE THE VEHICLE SITS UNUSED IN THE DRIVEWAY. THE DEALER HAS REMOVED, CLEANED, REINSTALLED, AND RESEALED A "BODY PLUG" THAT WAS SUPPOSEDLY IMPROPERLY SEALED AT THE FACTORY; YET, EVEN AFTER THIS SERVICE WORK, THE PROBLEM PERSISTS. SEARCHING THE WEB, I'VE NOTICED OTHER HONDA PILOT AND RIDGELINE OWNERS EXPERIENCING THE SAME TYPE OF WATER LEAKAGE PROBLEM; AND, WITH VARYING DEGREES OF SUCCESS, DEALERS SEEM...