2003 HONDA GL1800 Structurebody Problems

TOLD BY HONDA THE FRAME RECALL WAS DONE IN 2012. IN 2020 I INSPECTED THE FRAME AND THERE ARE CRACKS IN THE FRAME AGAIN WHERE THE RECALL STATED THEY WOULD BE. THE REPLACEMENT FRAME IS CRACKING. BOTH MAJOR CRACKS ARE AT THE WELDS AT THE REAR PASSENGER FOOT PEGS

TL* THE CONTACT OWNS A 2003 HONDA GL1800. THE CONTACT STATED THAT UPON INSPECTION IT WAS DISCOVERED THAT THE FRAME WAS FRACTURED. THE CONTACT INDICATED THAT THE FRACTURE WAS LOCATED AT THE MID SECTION OF THE LEFT SIDE OF THE MOTORCYCLE. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE LOCAL DEALER TRIKES BY RODNEY LOCATED AT 1672 LINDEN AVE, ZANESVILLE, OH 4370 WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOT YET NOTIFIED. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN THE NHTSA CAMPAIGN NUMBER: 05V027000 (STRUCTURE). THE FAILURE MILEAGE WAS 138,000.

HONDA SAFETY RECALL SERVICE BULLETIN GL1800 #14 REVISED: SEPTEMBER 2008 STATES THAT MY MOTORCYCLE IS ONE OF THE AFFECTED UNITS FOR THE RECALL (I.E. THE FRAME WELDS NEED TO BE REINFORCED). THAT WORK HAS NEVER BEEN DONE. HOWEVER, THE RECORDS FOR DOING A VIN CHECK ONLY GO BACK 15 YEARS, AND A LOCAL HONDA DEALER SAYS NO FIX IS NEEDED.

TL* THE CONTACT OWNS A 2003 HONDA GOLDWING. THE DEALER INSPECTED THE VEHICLE AND FOUND PREMATURE CRACKS IN TWO PLACES UNDER THE PASSENGER SIDE FLOORBOARDS. THE MECHANIC WAS TO FURTHER DIAGNOSE THE MOTORCYCLE TO DETERMINE WHAT PARTS NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE. UPDATED 09/29/16*LJ *TR

TL* THE CONTACT OWNS A 2003 HONDA GOLDWING GL 1800 MOTORCYCLE. THE CONTACT STATED THAT WHILE THE VEHICLE WAS BEING SERVICED BY THE DEALER, THE DEALER ADVISED THE CONTACT THAT THE LEFT SIDE OF THE MOTORCYCLE FRAME WAS CRACKED. THE MANUFACTURER WAS CONTACTED BUT THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGES WERE 103,000.

WHILE INSPECTING THE MOTORCYCLE NOTICED THAT FRAME HAD SEPARATED FROM THE CROSS MEMBER. THE DRIVER WAS UNABLE TO MOVE OR DRIVE THE MOTOR CYCLE TO THE DEALER. THE DRIVER HAS CONTACTED THE DEALER FOR APPOINTMENT. *NM THE CONSUMER WANTS TO KNOW IF NHTSA CAN HELP SOLVE THIS PROBLEM OF HONDA SELLING DEFECTIVE MOTORCYCLES TO THE PEOPLE OF CONNECTICUT UNTIL THEY SOLVE THIS PROBLEM, SO THEY AREN'T PUTTING THEIR LIVES IN DANGER. *BF *NM

FRAME CRACKED ON EITHER SIDE OF LOWER FRAME. DEALER STATED THEY WILL RESTORE THE FRAME. CONSUMER BELIEVED THAT A RESTORED FRAME WILL CRACK AGAIN. *AK