2005 HONDA ELEMENT — Problems, Recalls & Safety Data

The contact owns a 2005 Honda Element. The contact stated that while at a complete stop, the vehicle began to tilt sideways while depressing the accelerator pedal. The vehicle became inoperable. There was no warning light illuminated. The contact pulled off to the shoulder of the roadway. Upon inspection of the vehicle, the contact discovered that the rear driver’s side control arm had separated from the frame of the vehicle, causing the rear wheel to tuck in underneath the wheel hub. Due to the failure, the vehicle was towed to an independent mechanic where it remained undiagnosed. The dealer was contacted and stated that based on the pictures, the entire suspension needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 124,000.

Air bag in drivers seat deployed when I shut rear door. Car was running at the time.

The contact owns a 2005 Honda Element. The contact stated while inspecting the vehicle, the contact noticed that the rear trailing arm mount was severely rusted. The vehicle was taken to an independent frame mechanic, where the contact was informed that the rear trailing arm mount could fracture. The vehicle was taken to the dealer, where the contact was informed that the VIN was not included in an unknown recall. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 190,000.

The left rear control arm pulled out of the subframe and floor panel and hit the pavement facing forward, the direction in which the car was moving. The left rear tire pulled out and away from the vehicle, and the car lurched downward. There were sparks. I was pulling away from a gas pump at a service station. I stopped the car immediately and had it towed to a mechanic. There was no warning. There were no unusual sounds or movements prior to the incident. Approximately 100 miles before the incident, a licensed mechanic did a safety inspection and test drove the vehicle prior to doing maintenance on other parts of the car. Two different mechanics inspected the vehicle and determined it was unsafe to repair it. The control arm broke off due to excessive rust and corrosion, which was not visible during the safety inspection, because the area was visually blocked by a strut.

Rear unibody rust through allowing the drivers side rear trailing arm to become detached. Pulling up to stop sign very slowly luckily. At speed this failure would have assuredly led to a crash from loss of control. Calls have been placed to local Honda dealer as well as American Honda where I was informed there was no recall for this problem in the USA.