2009 HARLEY-DAVIDSON SOFT TAIL Power Train Problems

CLUTCH LEVER SEEMED FAR TO REACH, TOOK IN FOR INSPECTION AND/OR POSSIBLE ADJUSTMENT. CAME BACK WITH CLUTCH LEVER STICKING OR RATCHETING, NO LONGER SMOOTH TO OPERATE. THIS MADE IT VERY HARD TO OPERATE IN THE FRICTION ZONE NEEDED FOR SLOW OPERATION AND TURNING AROUND. CLUTCH WOULD POP AND JUMP FORWARD ALMOST CAUSING TO FALL OVER MANY TIMES. TOOK IN FOR REPAIR.....LUBED AND GROUND OUT THE INSIDE OF WEAR AREA ON LEVER AND UNIT THAT THE CLUTCH CABLE COMES INTO. WAS TOLD THAT IT WOULD WEAR DOWN IN TIME AND BECOME SMOOTH, THAT THIS IS TYPICAL OF THIS MODEL OF MOTORCYCLE. PROBLEM NOT FIXED AND DEALER DOES NOT KNOW OF ANY WAY TO REPAIR THIS PROBLEM. I HAVE DUMPED THE BIKE SEVERAL TIMES DUE TO THE LACK OF A SMOOTH CLUTCH, IT IS HARD TO CONTROL AND MUST BE ABLE TO CONTROL FOR TURNING AROUND OR PARKING, ETC. THERE IS NO...

HARLEY DAVIDSON 2009 FLHTCU (PLACED HERE AS VEHICLE SECTION ONLY LISTS 5 MODELS AND NOT THIS ONE) AUDIBLE LOUD KNOCK COMING FROM THE PRIMARY CHAIN CASE ON EACH ENGINE STARTUP. KNOCK APPEARS TO ORIGINATE FROM THE COMPENSATOR SPROCKET ASSEMBLY WHICH CUSHIONS THE DRIVE SIDE CRANKSHAFT SPROCKET AND THE PRIMARY DRIVE ASSEMBLY WHEN STRIKING EACH OTHER AT ENGINE STARTUP. MANY COMPENSATOR SPROCKET ASSEMBLIES HAVE BEEN FOUND IN FAILURE MODE AND HAVE BEEN REPLACED WITH A MORE ROBUST UNIT (FACTORY INSTALLED ON 2010 AND LATER MODELS) UNDER WARRANTY. FAILURE IN SERVICE COULD BE CATASTROPHIC AND OPERATOR INJURY OR DEATH COULD RESULT. MANUFACTURER IS AWARE OF ISSUES BUT HAVE NOT RECALLED ANY UNITS FOR REFIT OF UPGRADED COMPONENT. *TR

PURCHASED A 2009 HARLEY DAVIDSON ( NEW ) IN JUNE OF 2010. AT 1700 MILES THE BOLTS THAT HOLD THE REAR SPROCKET TO THE WHEEL HAVE BACKED OUT CAUSING WHAT COULD HAVE BEEN A CATASTROPHIC FAILURE IE: REAR WHEEL LOCKING UP AT A HIGHWAY SPEED AND CAUSING A CRASH. HARLEY DAVIDSON MECHANICS STATED TO ME THIS IS NOT THE FIRST ONE THEY HAVE SEEN. I CANNOT BELIEVE THAT HD HAS NOT INSTITUTED A RECALL, THEY HAVE TO BE AWARE OF PROBLEM THROUGH FEEDBACKS FROM SHOPS. THIS IS NOT SOMETHING TO MESS AROUND WITH, THIS CAN BE LIFE THREATENING, SOMETHING NEEDS TO BE DONE IMMEDIATELY TO CORRECT THIS "DEFECT" AND I MEAN " NOW " THIS MINUTE YOU RECEIVE THIS. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR